2003 Volvo S80

26 complaints on file, page 1 of 2.

1. Filed Feb 5, 2024Failure Aug 18, 2023Ketchikan, AKAir bags

   See attached document for complaint

   NHTSA complaint 11570036
2. Filed Jun 10, 2023Failure Mar 15, 2023Canby, ORFuel/propulsion system

   In Tank Fuel Pump, problem was leaking at top of pump @ the inlet at the outlet & return valve, crack in the plastic mold. Was giving off fumes, totally unhealthy and waitin for someone to light up a cigarette for a total car explosion and death for all occupants. I have replaced the pump myself. Local Dealer wanted 1100 plus to replace out of my budget This in my view it should have been done by recall, local Jim Volvo of Portland, Oregon said no, out of warranty period. I disagree, If unrepaired, I would have been risking me and my family or occupants in the vehicle at the time. There are still many of these cars and other models & years that I found my research on the web that has had this same problem. I have a 1998 Volvo s70 that appears to be developing the same issue. I had come to like my 2003 S80, it will be my last Volvo My cost so far About $150, and 1st pump I installed was defective, had to start over [XXX] [XXX] INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

   NHTSA complaint 11526377
3. Filed Sep 27, 2022Failure Jun 11, 2021University Place, WAPower train

   The lovely GM transmission suddenly decided to not shift while going uphill. Pushing the accelerator just made the RPMs go up and up while the car did nothing. Then a warning light. Transmission service Then limp mode. And all I could do literally was go 5 mph then. It occurred as I was turning at a light. I did call my local volvo dealer who kind of laughed about the price of a new transmission and told me that was all I could do.

   NHTSA complaint 11486582
4. Filed Mar 11, 2022Failure Nov 29, 2021Sonoma, CAAir bags

   The contact owns a 2003 Volvo S80. The contact received a notification for NHTSA Campaign Number: 21V766000 (Air Bags). The dealer had been notified about the recall and an appointment was made for the recall repair. The contact then received a call that the appointment was cancelled due to parts not yet being available. The manufacturer was also notified of the recall and also stated that parts were unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the repair. The contact had not experienced a failure. Parts distribution disconnect.

   NHTSA complaint 11456300
5. Filed Dec 16, 2021Failure Dec 16, 2021Missoula, MTAir bags

   The vehicle has a recall and Volvo told me I have to drive 8 hours to another state to get it fixed by the closest dealership. I cannot do that - I need to have it fixed locally

   NHTSA complaint 11444009
6. Filed Jun 7, 2021Failure Jun 2, 2021North Liberty, IAFuel/propulsion system

   Within a week of purchasing the vehicle from a dealer, I discovered that the fuel tank has a leak, so its currently unsafe to drive. I found out about the leak when I brought it to an independent mechanic for service. I see that other vehicles of this model and year had been recalled for fuel leaks, so I wanted to report the issue.

   NHTSA complaint 11419916
7. Filed Oct 13, 2016Failure Sep 10, 2016LOS Angeles, CAElectrical systemFire

   TL* THE CONTACT OWNED A 2003 VOLVO S80. WHILE PARKED, THE BATTERY COMPARTMENT CAUGHT FIRE WITHOUT WARNING. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE AND FILED A REPORT. THERE WERE NO INJURIES. THE VEHICLE WAS NOT DIAGNOSED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN. THE VEHICLE WAS DESTROYED.

   NHTSA complaint 10915723
8. Filed Mar 14, 2016Failure Feb 22, 2016112,000 milesTobyhanna, PAFuel/propulsion system

   TL* THE CONTACT OWNS A 2003 VOLVO S80. THE CONTACT SMELLED FUEL INSIDE THE VEHICLE. IT WAS DIAGNOSED THAT THE FLANGE WAS CRACKED ON THE FUEL PUMP. THE MANUFACTURER WAS NOTIFIED. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 112,000.

   NHTSA complaint 10849576
9. Filed Jan 19, 2016Failure Nov 7, 2015144,077 milesLakewood, NJElectrical system, Exterior lighting

   TAKATA RECALL THE DASHBOARD LIGHTS ARE NOT WORKING AT ALL. I JUST BOUGHT THE CAR 2 MONTHS AGO. WITHOUT THE DASHBOARD LIGHTS NOT WORKING, IT IS VERY DANGEROUS. I CAN NOT SEE HOW MANY MPH I AM GOING, AND CAN'T TELL HOW MUCH GAS I HAVE. ALSO AT NIGHT, IT IS COMPLETELY BLACK IN THE DASHBOARD AND IS VERY DANGEROUS. THIS HAPPENS DAY AND NIGHT. IT HAPPENED AS SOON AS I DROVE IT OFF THE LOT. I CALLED THE DEALER, AND THEY DID NOT WANT TO TAKE CARE OF IT. I PURCHASED THE CAR AT MICHELE MOTORS, LOCATED ON RT.88, BRICK, NJ.

   NHTSA complaint 10820957
10. Filed Jun 25, 2013Failure Jun 23, 2013101,500 milesFountain Hills, AZFuel system, Gasoline

    MY CAR SHOWS EXACT SYMPTOMS OF THE VEHICLES INVOLVED IN NHTSA RECALL # 09V483. RECALL INVOLVED CARS IN THE HOT WEATHER STATES OF US. AT THE TIME OF THE ORIGINAL RECALL I HAVE RESIDED IN THE MASSACHUSETTS WHICH WAS NOT INCLUDED IN THE INITIAL RECALL. I HAVE MOVED TO ARIZONA IN THE SUMMER OF 2010 AND NOW MY CAR IS SMELLING GAS AS RECALLED VEHICLES. TRIED TO CONTACT VOLVO DEALERS AND THY ARE STATING SINCE MY VIN IS NOT IN THE DATABASE OF RECALLED VEHICLES THEY WILL NOT PERFORM REPAIR ( UNLESS I WILL PAY FULL PRICE OF COURSE ). *TR

    NHTSA complaint 10521782
11. Filed Jan 28, 2013Failure Jan 15, 2013152,000 milesFaribault, MNElectrical system

    DRIVER INFORMATION MODULE (DIM) ORIGINALLY STARTED DROPPING OUT AND RETURNING MULTIPLE TIMES DURING A TRIP, NOW IT IS GOING OUT COMPLETELY AFTER ROUGHLY 15 MILES, NO CLUSTER GAUGES OR DASH LIGHTS. WILL COME BACK ON AFTER COOL DOWN TIME OF ROUGHLY 2-3 HOURS. NO SPEEDOMETER, TACH, GAS OR TEMP GAUGES. SIGNAL LIGHTS WORK, BUT NO DASH INDICATORS. *TR

    NHTSA complaint 10495014
12. Filed Feb 8, 2012Failure Dec 1, 2011123,000 milesRiverdale, GAVehicle speed control

    TL* THE CONTACT OWNS A 2003 VOLVO S80. THE CONTACT WAS DRIVING APPROXIMATELY 60 MPH WHEN THERE WAS A SUDDEN REDUCTION IN ACCELERATION. THE ENGINE RPMS RACED CONTINUOUSLY. THE VEHICLE HAD NOT BEEN DIAGNOSED OR REPAIRED FOR THE FAILURE. THE MANUFACTURER WAS NOTIFIED OF THE DEFECT. THE APPROXIMATE FAILURE MILEAGE WAS 123,000.

    NHTSA complaint 10447163
13. Filed Oct 24, 2010Failure Oct 1, 201059,493 milesFolsom, CAService brakes, Electric

    I KEEP GETTING ABS MODULE FAILURE ON VOLVO S80; EVERY TIME WE TAKE OUR CAR TO VOLVO DEALER, THEY COME UP WITH SOME MODULE FAILURE DIAGNOSIS. SEEMS LIKE A VOLVO GENERIC ISSUE WITH ABS MODULE FAILURE MESSAGE. WE HAVE TRIED CONTACTING VOLVO ABOUT THIS AND THEY REALLY DID NOT HELP US. THEY HAVE ASKED ME TO TALK TO THE SERVICE MANAGER AT THE LOCAL VOLVO DEALERSHIP. HOWEVER SERVICE MANAGER HAS TOLD US THAT THIS IS NOT A TYPICAL VOLVO AND ASKED TO GET RID OF OUR CAR. PLEASE HELP. *TR

    NHTSA complaint 10362161
14. Filed Jun 12, 2010Failure Aug 5, 2009129,000 milesRumford, RIAutomatic transmission

    2003 VOLVO S80 T6 - GM TRANSMISSION NOTICED TRANSMISSION SHIFTING ODDLY BUT NO CODES. CODES CAME AFTER CLIMBING HILL, TOOK TO VOLVO DEALER. CODE (DTC) 0053 PRESSURE SWITCH LOCK UP. VOLVO SAYS REPLACE TRANSMISSION. SOFTWARE UPGRADED - DID NOT FIX. DECLINED. TRANSMISSION SHIFTS ODDLY, CAR REV'S AND WON'T SHIFT WHERE IT NEEDS TO CAUSING TROUBLE WITH ACCELERATION AND DECELERATION. THERE IS A CONSISTENT PROBLEM WITH VOLVO'S EARLY 90'S GM TRANSMISSIONS. *TR

    NHTSA complaint 10335976
15. Filed Jul 14, 2009Failure Jul 6, 2009Manorville, NYExterior lighting

    I HAVE A 2003 VOLVO AND TWICE I HAVE HAD TO HAVE THE FRONT LENS ON THE HEAD :LIGHT REPLACED, NOT BECAUSE IT WAS DAMAGED BY AN ACCIDENT BUT BECAUSE WHEN WATER HITS IT THE LENS CRACKS ( IT HAPPENS WHEN THE AUTO HAS BEEN RUNNING OR SITTING OUT OUTSIDE ) I BELIEVE THERE IS SOME KIND OF DEFECT IN THE LENS . THIS IS NOT A CHEAP EXPENSE, I HAVE PAID OVER $500.00 EACH TIME I HAVE IT REPAIRED. THE VOLVO DEALER I GO TO DOES NOT SEEM TO CARE TO INVESTIGATE THIS, BUT I AM GETTING TIRED OF PAYING FOR SOMETHING THAT IS NOT MY FAULT. *TR

    NHTSA complaint 10276822
16. Filed Jun 8, 2008Failure Jun 2, 200845,506 milesMontour Falls, NYFuel system, Gasoline

    HI, JUST HAD TO HAVE MY FUEL PUMP REPLACED TO THE TUNE OF WELL OVER A THOUSAND DOLLARS. COST AND PROBLEM FALL IN TO THE "UNREAL" CATEGORY. HARD TO BELIEVE THAT SOMETHING AS SIMPLE AS A FUEL PUMP HAS EVOLVED INTO A PIECE OF EQUIPMENT THAT APPARENTLY AS COMPLICATED AS SOMETHING THAT IS VITAL TO THE LAUNCH OF THE SHUTTLE. OH FOR THE DAYS WHEN A FUEL PUMP WAS ACTIVATED BY THE CAM SHAFT, HELD ON TO THE ENGINE WITH TWO BOLTS, COST FIVE DOLLARS, TOOK ABOUT TEN MINUTES TO REPLACE AND SELDOM FAILED. ACCORDING TO THE STEALERSHIP THAT DID MY WORK, IN ORDER TO GET TO THE FUEL PUMP, THEY HAD TO REMOVE THE REAR SEAT TO GET TO THE FUEL PUMP? I HAVEN'T HAD TIME TO SURVEY THE TOTAL AMOUNT OF DAMAGE THEY DID IN DOING THIS, BUT DO KNOW THAT THE HEADLINER AND STEERING WHEEL ARE COVERED WITH GREASY HAND PRINTS AND AFTER THREE DAYS THERE IS STILL A STRONG ODOR OF GASOLINE IN THE CAR. MY VOLVO IS AN 03 S80 WITH ONLY 45,000 MILES ON IT. IS THIS TYPICAL OF VOLVO DEPENDABILITY AND EXCELLENCE? GUESS I'M GOING TO HAVE TO GO JAPANESE. COMMENTS PLEASE. *TR

    NHTSA complaint 10230258
17. Filed Oct 24, 2007Failure Sep 20, 200735,990 milesPhoenix, AZ12v/24v/48v battery, Fuel system, Fuel pump

    AFTER PURCHASING A VOLVO S80 IN APRIL 2003 FROM VOLVO NORTH SCOTTSDALE, MY WIFE (WHO DRIVES THE CAR) BEGAN EXPERIENCING A FUEL INJECTION PROBLEM. EACH TIME THE CAR WAS ROUTINELY SERVICED AT VOLVO NORTH SCOTTSDALE, SHE COMPLAINED OF THE PROBLEM, BUT THE DEALER FAILED TO REPAIR IT. AFTER TIRING OF THE DETERIORATING SERVICE QUALITY AT VOLVO NORTH SCOTTSDALE, MY WIFE BEGAN HAVING THE CAR SERVICED AT POWELL VOLVO, TO WHOM SHE CONTINUED TO COMPLAIN OF THE FUEL INJECTION PROBLEM. THAT DEALER ALSO FAILED TO REPAIR THE PROBLEM. WHEN THE WARRANTY EXPIRED, MY WIFE HAD THE VEHICLE SERVICED AT AN INDEPENDENT MECHANIC, SWEDISH AUTO WERKS, TO WHOM SHE ALSO COMPLAINED OF THE FUEL INJECTION PROBLEM. AT THIS TIME, THE CAR HAD BEEN DRIVEN 35,990 MILES. BY THIS TIME, SHE WAS ALSO EXPERIENCING AN INTERMITTENT SLOW/LONG CRANK STARTING THE CAR, WHICH WAS THOUGHT TO BE DUE TO A FAILING BATTERY. SHE COMPLAINED OF THIS ALSO TO SWEDISH AUTO WERKS. SWEDISH AUTO WERKS DIAGNOSED THE CAUSES OF THE PROBLEM AS NOT ONLY A FAILING BATTERY BUT ALSO A CRACKED FUEL PUMP HOSE NIPPLE. IN ADDITION TO A NEW BATTERY, IT INSTALLED A NEW FUEL PUMP ASSEMBLY AT A COST OF $821.97. THE CAR NOW RUNS VERY WELL. IN A SUBSEQUENT CONVERSATION WITH ANOTHER VOLVO OWNER, MY WIFE LEARNED AND HAS SINCE CONFIRMED THAT THIS FUEL PUMP PROBLEM HAS BEEN RECURRENT WITH THE VOLVO S SERIES SINCE AL LEAST 2002-03 AND THAT VOLVO KNOWS OF IT. MY WIFE ALSO LEARNED THAT THERE HAS BEEN A "SILENT RECALL" PROMPTED BY THIS PROBLEM--I.E., IF THE PROBLEM IS RECOGNIZED BY A VOLVO DEALER, VOLVO WILL FIX IT AT NO COST TO THE OWNER. NEITHER VOLVO NORTH SCOTTSDALE NOR POWELL VOLVO IDENTIFIED THE PROBLEM DESPITE MY WIFE'S REPEATED COMPLAINTS TO THEM. BY OCTOBER 4, 2007 LETTER AND ATTACHED COPY OF THE REPAIR INVOICE TO VOLVO CUSTOMER CARE CENTER, I REQUESTED REIMBURSEMENT. IN REPLY, VOLVO DENIED MY REQUEST, STATING THAT THERE HAD BEEN NO RECALL. THE DATE BELOW IS WHEN THE REPAIR WAS MADE. *TR

    NHTSA complaint 10206798
18. Filed Jan 5, 2006Failure Dec 29, 200527,000 milesDurham, NCControl arm

    AN S80, 2003 NEW, LOST THE RIGHT FRONT WHEEL WHEN THE BALL JOINT FAILED AT 27,000 MILES. VOVLVO REPLACED THE RIGHT AND LEFT FRONT BALL JOINTS UNDER WARRANTY. THEY SAID THIS HAPPENS SOMETIMES. HAD WE NOT BEEN ON A LOCAL ROAD TRAVELLING 20 MPH THERE COULD HAVE BEEN SERIOUS INJURY. THE STEERING PROBLEM HAS EXISTED SINCE 3/05. THE VOVLO DEALERSHIP SAID, IN MARCH OF 2005 THE STEERING PROBLEM WAS DO TO A LOOSE HOSE CONNECTION WHICH THEY CORRECTED. THE CAR CONTINUED TO STEER, FROM TIME TO TIME, LIKE IT WAS PLANING. CROWN VOLVO OF CHAPEL HILL NC IS THE DEALER. THEY HAVE OFFERED TO TAKE OVER THE LAST TWO LEASE PAYMENTS IF I BUY A NEW VOLVO. *NM

    NHTSA complaint 10147035
19. Filed May 31, 2005Failure Feb 4, 2005Milford, CTUnknown or other

    CARRIER BIKE RACK AND 2 BIKES FLEW OFF THE ROOF OF A S-80 VOLVO(2003) WHILE DRIVING ON THE FLORIDA TURNPIKE.LUCKILY NO ONE WAS CLOSE BEHIND AND I WAS ABLE TO REMOVE THE WRECKAGE FROM THE HIGHWAY.I COMPLAINED TO VOLVO BUT THEY CLAIMED THAT IT WAS MY FAULT.NOTHING WAS REPLACED.SOMEWHERE IN THE MANUAL IT SAYS TO CHECK THE RACK.THERE IS NO WARNING LABEL ON RACK AND AS IT IS ENCLOSED THERE IS NO EVIDENT WAY TO SECURE.THERE ARE FINGERS IN THE SLOT ON TOP OF THE CAR BUT THE ROOF MATERIL IS SO FLIMSY THAT IT APPEARED TO HAVE ENOUGH GIVE SO THAT THE ROOF RACK COULD DISENGAGE.VOLVOS ATTITUDE ISS THAT THE DRIVER MUST CONSTATANTLY CHECK THE ROOF RACK. IF THIS IS SO THE LEAST THEY COULD DO IS PUT A WARNING LABEL ON SAME.I AM FOTUNATE NO ONE WAS INJURED BUT I THINK THERE IS A SERIOUS PROBLEM.I HAD A VERY LIGHT LOAD BUT I SEE VOLVOS WITH HEAVY BOXES ON THEM AND I SHUDDER TO THINK WHAT MIGHT HAPPEN.

    NHTSA complaint 10122509
20. Filed May 25, 2005Failure May 20, 2005Milton, MAFuel system, Fuel injection systemCrash2 injured

    RE: 2003, VOLVO S80. I HAD JUST PULLED INTO A PARKING SPACE AT MY PRESCHOOL SON'S SCHOOL, I WENT TO SHIFT GEARS AND TAKE MY FOOT OFF THE BRAKE AND MY CAR HAD A SUDDEN ACCELERTATION CAUSING ME TO BE WITHOUT CONTROL OF MY CAR FOR OVER 50 FEET, HITTING A TREE, 3 SHRUBS AND A 3000 LB. ROCK. MY PRESCHOOLER AND I SUSTAINED MINOR INJURIES BUT MY CAR IS TOTALLED. MY CAR IS IN AN AUTO BODY SHOP AWAITING INSURANCE APPROVAL FOR A TOTALLED CAR. MY SON IS TRAUMATIZED AND I WAS SHAKEN UP FOR DAYS. I AM CONCERNED THAT THERE WAS A MACHANICAL FAILURE BUT I HAVE NOT RECEIVED A CALL BACK FROM VOLVO ABOUT AN INVESTIGATION. I WOULD LIKE TO REQUEST A FORMAL INVESTIGATION INTO THIS.

    NHTSA complaint 10122130