2012 Volvo XC60

46 complaints on file, page 1 of 3.

1. Filed Jul 9, 2025Failure Jul 9, 2025Martinsburg, WVTires

   Four tires purchased June 2022. As of July 2025 with 17,500 miles on the tires there is ozone/weather cracking on the entire tire and the sidewall near the rim is failing with the cord visible on one tire.

   NHTSA complaint 11672211
2. Filed May 31, 2024Failure May 13, 202461,174 milesHendersonville, TNWindshield

   The contact owns a 2012 Volvo XC60. The contact stated that while it was raining, water seeped through the driver's side front windshield and onto the steering wheel. The contact placed a towel on top of the steering wheel to prevent water from damaging the electrical system. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 61,174.

   NHTSA complaint 11591814
3. Filed Jan 20, 2024Failure Jan 1, 2024Marietta, GAUnknown or other

   The windshield leaks constantly. I'm worried about the windshield blowing out or electrical components being damaged. This seems to be a constant complaint according to internet search. Why hasn't this been addressed as a safety issue and a recall ordered?

   NHTSA complaint 11566639
4. Filed Dec 22, 2023Failure Dec 21, 2023Pleasanton, CAVisibility/wiper

   During rain, water is leaking inside the car from the driver’s side windshield while I’m driving, obstructing my vision.

   NHTSA complaint 11561587
5. Filed May 19, 2023Failure May 12, 2023Bryan, TXAir bags, Seat belts, Seats

   It was explained to me that since the Back rear seat in the Volvo XC60 seatbelt had a fault that it alerted the SRS airbag system. In event of a crash the airbags in my car would not deploy and that the only remedy was to replace the entire seatbelt in the Volvo. To prove this point I took my car in to a Volvo dealership and the technicians offered the fix as the only way my cars airbags would work if i got it fixed.

   NHTSA complaint 11522879
6. Filed Nov 14, 2022Failure Oct 12, 2022Clifton, VAElectrical system

   On October 12, 2022 while driving home from the Schar Cancer Center in Fairfax, my 2012 Volvo XC60 experienced an end of life event. My check engine light came on when I entered my neighborhood. The car began sputtering and the gas pedal was delayed and at times, unresponsive. I was able to make it to my house and made an appointment to service my Volvo. My Volvo was towed to GT Peace Automotive on November 6. The three-week delay was due to their backlog of work. They are a trusted repair service and have provided service to all my vehicles over the past four years. The attached document indicates their assessment. Highlights include that the Volvo was a fire hazard in its current condition, the ignition coils were melted, and the circuits are shorted. GT Peace provided an estimate of $3,500 for repairs as a starting point to fully replace the engine harness. Their evaluation concluded that, based on other findings, the cost would easily go north of $3,500, possibly to $5,500. Based on this assessment and the CARFAX History Based Value of my vehicle (private party value of $10,170), it was in my best interest to donate the vehicle. I gave it to the Auto Tech program at Centreville High School on November 9, 2022.

   NHTSA complaint 11493444
7. Filed Oct 8, 2022Failure Oct 8, 2022Ramsey, NJUnknown or other

   A faulty radiator anti-tamper device caused loss of communication to the engine control computer. The check engine light turns on and “charging failure-service urgent” message pops up during driving. Which cause the drivers worry even panic. I talked to local dealer several times. I was told to change battery everytime. But my battery and alternator were both tested fine. The message could pop up right after full charged battery. There are many complains at Volvo forums. Volvo knows the issue, but they decided not to recall it. The check engine light and messages pops up on and off by itself. The DTC codes are normally U0286 and/or B1087. I am already changed one battery. The problem is still there. It could cause accident because the message pops up during driving on highway and cause unnecessary worry and panic.

   NHTSA complaint 11488496
8. Filed Aug 15, 2022Failure Aug 15, 2022Culver City, CAEngine

   "Failure Charging" warning advisory light came on the dashboard. This problem has been going on for the whole ten years I have owned this vehicle. I am the original owner of this Volvo and had some engine warning on the dashboard since the first month. I took vehicle in to the Culver City Volvo for 1000 miles check-up and annual oil change and check-up for 5 years under warranty and requested software update and reported the engine stalling during the first month. The "failure charging" or "engine check" or "dangerous" "immediate" repair needed signs came on sometimes and did not come on other time. When the "failure charging" sign comes on and the engine is turned off and restarted the warning would go away sometimes. I believe this is a Volvo vehicle computer software malfunction. I reported this problem to the dealer for 5 years during annual service appointments. This problem was not solved and I have lived with this, stupidly patient for 10 years. Today, problem light came on during biennial smog check for vehicle license renewal and failed the smog test. So, I informed the mechanic and tried a second test several minutes later and passed the second time because the software problem did not surface this time. So, my question is: has this Volvo software problem been reported by others as I have heard by word of mouth that this software problem is found on Volvo cars? And, has there been a recall to fix this Volvo software problem? When this "failure charging" sign comes on, it is very worrisome and makes me feel the vehicle may stop on the road.

   NHTSA complaint 11479461
9. Filed Jul 21, 2022Failure Jul 21, 2022Amherst, NHVisibility/wiper

   The front windshield was not properly sealed during manufacturing and is now leaking when it rains. Water drips down the inside of the windshield in front of the driver resulting in distraction and poor visibility. I also fear that in an accident the windshield would not perform as it should and would be a safety issue. I brought it to the Volvo dealer and they just said I had to have it replaced but they do not provide that service. I brought it to a windshield service center and the technician was able to push on the windshield with only his hand and confirm that it was not sealed and showed movement. They also mentioned that have seen this issue many times with these cars. There were no warnings other than the leak which started a few months ago.

   NHTSA complaint 11475160
10. Filed Jul 13, 2022Failure Jul 13, 2022Greenwood, INUnknown or other

    Lately my vehicle has been shutting off power when I hard right turn during parking everything shut off then I have to restart it again, but the scary part was what happened this morning I was driving on interstate and as I was charging lanes it almost powered off again but it picked up.

    NHTSA complaint 11473653
11. Filed Jun 2, 2022Failure Jan 15, 2022Milwaukee, WIWindshield

    The windshield was not sealed properly during manufacturing because of a problem with the sealant used. This has caused a leak from the windshield on both the driver and passenger side from the top of the windshield when it rains. This creates lowered visibility when driving with water on the inside of the car, and also causes driving distractions while operating the vehicle. This improperly installed windshield also has caused malfunctions in electrical components in the windshield. There are no warning lights for this issue, but the windshield must be resealed by an auto glass technician.

    NHTSA complaint 11467173
12. Filed May 5, 2022Failure May 5, 2022West Linn, ORVisibility/wiper

    Manufacturers original windshield began leaking. On inspection windshield is not properly bonded or adhered to vehicle body and is able to be pushed off the body of the vehicle with little pressure from the inside of the cabin. Windshield repair company advised me to look for a recall notice they were so concerned. Didn't find one, so I wanted to report a safety concern

    NHTSA complaint 11463555
13. Filed Mar 29, 2022Failure Mar 1, 2022Hingham, MAVisibility/wiper

    Original front windshield separating from frame of car. Leaking water during rain / melting snow. In cold weather forms ICE/FROST on INTERIOR posing visibility hazard! Autobody worker showed me how the windshield MOVED when he pushed on it with nothing more than his hand - warned me this is also a structural risk in case of crash. He stated he has personally seen hundreds of these on same model car for this year and the two following. Doesn't know why the company doesn't issue a recall!

    NHTSA complaint 11458849
14. Filed Mar 26, 2022Failure Mar 14, 2022Atlanta, GAVisibility/wiper

    Our 2012 Volvo XC60 has a problem with the seal along the top of the windshield, which allows water into the interior of the car. It can end up dripping onto my lap while driving, which is distracting and a potential safety issue, and it also can obstruct visibility as water runs down the inside of the glass.

    NHTSA complaint 11458433
15. Filed Jan 7, 2022Failure Dec 29, 2021Battle Ground, WAVisibility/wiper

    During heavy rains and movement there is water leaking into the vehicle along the top drivers inside of the windshield. It also drips onto the steering wheel which often startles me while actively driving. The windshield has no cracks and is the original windshield.

    NHTSA complaint 11446687
16. Filed Dec 29, 2021Failure Nov 24, 2021Noblesville, INUnknown or other

    There is a steady leak in the top left (driver side) of the windshield. Heard from the Tom Wood service and collision department that this is a common problem with these vehicles.

    NHTSA complaint 11445465
17. Filed Dec 16, 2021Failure Jul 1, 2020La Quinta, CAVisibility/wiper

    When it rains or I go through the car wash the windshield leaks water that runs down the inside of the glass and has stained the headliner

    NHTSA complaint 11444016
18. Filed Aug 14, 2021Failure Aug 14, 2021Austin, TXVisibility/wiper

    When it rains or when getting a car wash, the windshield leaks water into car.

    NHTSA complaint 11429078
19. Filed Aug 13, 2021Failure Jun 1, 2020Ramsey, NJBody

    The rain water leaking through windshield. It could cause rust in the frame, then cause the failure of whole structure. I checked the Volvo forums, seems there are many Volvo owners have similar issues. I owned other cars, it’s the first time I had leaking water through perimeter of windshield.

    NHTSA complaint 11428956
20. Filed Aug 6, 2021Failure May 7, 2021Torrington, CTVisibility/wiper

    My volvo windshield started leaking from the top seal. When it rains water runs down the entire inside of the front windshield.

    NHTSA complaint 11428081