2015 Volvo XC60

47 complaints on file, page 1 of 3.

1. Filed Aug 6, 2026Failure Aug 2, 2026Marana, AZAir bags, Steering, BodyCrash1 injured

   The vehicle's Supplemental Restraint System (SRS) safety network experienced a total electrical blackout, resulting in complete airbag non-deployment during a severe unibody-deforming hit-and-run collision. The vehicle was stationary when a high-speed car rammed the passenger side and front profile. Kinetic forces split the cast aluminum steering rack housing completely in half, fractured front CV axle joint cages, and shifted the engine subframe mounts (creating physical gaps and shiny mechanical abrasions beneath the rust layer). Despite catastrophic structural distortion—which twisted the greenhouse safety cage and cracked the windshield directly beneath the laser cluster—zero front, side, or curtain airbags deployed. No dashboard SRS warning lights illuminated prior to or after the crash.A post-crash scan by a Master Mechanic confirms high-speed CAN-bus fragmentation, storing module timeouts U016700, U042268, and steering column resistance deployment inhibitors B1C0224, B1CO424, B1C0524. Additional codes include P134600, P134613, P261086, P0A0F68, C006468, B109B15, B116415, and B108467.Teardown reveals extensive, pre-existing saltwater intrusion residue inside passenger footwell fuse blocks (Centers B/C) and the under-hood relay box, plus green cupric carbonate oxidation on chassis grounds. This induced extreme electrical resistance, blinding the SRS module's ability to read the crash pulse. Occupant safety was heavily compromised; the driver sustained a severe concussion, whiplash, and active neurological time-loss blackouts after being struck by flying cabin cargo during the pulse. Both front seatbelt receiver buckles permanently bound and locked. The vehicle was inspected by local police under an active criminal hit-and-run report. Diagnostic logs are preserved and available for federal review.

   NHTSA complaint 11755236
2. Filed Jul 17, 2026Failure May 16, 2026Cedar Park, TXEngine

   Engine blew up while my daughter was driving due to excessive oil consumption. Issue known by Volvo but we bought the car in 2023 and the 8year warranty recall was just about to expire and we knew nothing about it. Very dangerous

   NHTSA complaint 11751199
3. Filed Jan 5, 2026Failure Jul 3, 2025Washington, DCEngine, Vehicle speed control

   Component/System that failed: The engine (T5 Drive-E) experienced sudden loss of propulsion and entered reduced engine performance mode. The vehicle is currently available for inspection and was towed to an authorized Volvo dealer following the incident. How safety was put at risk: On July 3, 2025, while driving approximately 75 mph on a crowded interstate highway in rural Ohio with cruise control engaged, the vehicle suddenly and without warning lost propulsion. Traffic included semi-trucks and other vehicles, with limited shoulder availability. The sudden loss of acceleration at highway speed created an immediate risk of rear-end collision and left the vehicle unsafe to operate. Confirmation or reproduction: Prior to the failure, in July 2024 at approximately 92,000 miles, I reported abnormal oil consumption to an authorized Volvo dealer and raised a known Volvo service advisory related to oil consumption in the T5 Drive-E engine. The dealer acknowledged the advisory but refused testing, stating the vehicle did not meet Volvo’s internal threshold. After the failure, a service agent acknowledged that this issue is known to occur in this model at approximately this mileage. Inspections: The vehicle was serviced at an authorized Volvo dealer in Bethesda, Maryland just days prior to the incident. Following the failure, the vehicle was towed to an authorized Volvo dealer in Columbus, Ohio. Volvo Cars USA has not repaired the vehicle and denied a goodwill request. Warnings or symptoms prior to failure: There were no warning lamps or messages prior to the loss of propulsion. The engine warning light and a “Reduced Engine Performance” message appeared only after power was lost.

   NHTSA complaint 11708737
4. Filed Sep 1, 2025Failure Aug 20, 2025Savannah, GAEngine, Power train

   The vehicle shakes and engine abruptly shuts off even after a new tune up

   NHTSA complaint 11684302
5. Filed Jul 28, 2025Failure Feb 15, 2023Bellevue, WAEngine, Fuel/propulsion system

   02/15/2025 I received a letter for oil consumption recall that was dated on 02/03/2023. Appointment was made same day I received the letter on 02/15/2023 and appointment couldnt be set sooner then 02/23/2023 which is the date the Oil consumption was done at Volvo of Bellevue. They changed the oil and sealed it and had me drive it 1000 miles, they said I didn't have an oil consumption problem and I disagreed because I told them I have to put in oil all the time. They said it has exceeded the 8yr or 100K miles of the extended warranty of the vehicle which ever comes first. I argued it had less then 100K miles when I got the letter on 02/15/2023 and the appointment couldnt be set til 02/23/2025 and Volvo of Bellevue said not to worry about it and they would take care of the recall. But after they had me pay for the oil change they said it exceeded the 100K miles and 8 yrs age of the vehicle. I argued the letter was sent to me after the vehicle was 8 years old and the avg miles of 12K was over 100K miles and I argued this was a known problem with Volvo but they kept on selling these vehicles knowing these vehicles have oil consumption problems. They refused to fix the car unless I paid them Thousands and thousands and thousands of dollars. I trusted what they told me that there was no oil consumption and in less then 7K miles later my engine smoked from their oil change and there was no oil in the vehicle as the engine had consumed all the oil and my car sat in my driveway for 22 months and I replaced many parts and still car wouldn't run. I took it back to Bellevue Volvo on 07/23/2025 to see what was wrong with the vehicle and they said the pistons were bent.

   NHTSA complaint 11676798
6. Filed Jun 10, 2025Failure May 22, 2025108,000 milesBothell, WAFire supressionFire

   The contact owned a 2015 Volvo XC60. The contact stated that while driving on a main road at 25 MPH, when a message was displayed on the instrument panel that stated "Engine Performance Degraded" and the vehicle experienced a significant reduction in automotive power, the contact proceeded to pull over and a few moments later smoke was emitted from the front end of the vehicle, the contact immediatley exited the vehicle and shortly afterwards the vehicle was engulfed in flames. The contact mentioned that the vehicle was serviced at the dealer prior to the fire. The origin of the fire was unknown. The vehicle was unoccupied during the fire. The location of the fire was the front passenger side of the engine compartment. The fire department arrived to extinguish the fire. A fire department report was filed. A police report was not filed. The vehicle was destroyed. The manufacturer was not notified of the failure. The approximate failure mileage was 108,000.

   NHTSA complaint 11666124
7. Filed May 4, 2025Failure May 4, 2025Houston, TXEngine

   My engine always continues to break down even after changing engine twice.

   NHTSA complaint 11658730
8. Filed Feb 3, 2025Failure Feb 2, 2025North Adams, MAChest clip, Buckle, Harness

   Chest clip is magnetized to assist with closing the clip - my clip does not stay latched shut, pops open at a slight push. I have another one of these seats, manufactured at a later date, and the chest clip needs the buttons pushed to open, so I know this is incorrect. Chicco does not feel the need to replace the seat, said they will send me a new retainer clip. If there was an option to attach a video to this complaint, I would.

   NHTSA complaint 11640491
9. Filed Dec 5, 2024Failure Nov 5, 2024111,000 milesHouston, TXEngine and engine cooling, Equipment

   The contact owns a 2015 Volvo XC60. The contact stated that every three weeks an oil change was performed on the vehicle. The contact stated that low oil level or oil empty messages were displayed. The vehicle was taken to the dealer who confirmed that the vehicle was consuming 15-quarts of engine oil every 6,000 miles driven. The dealer determined that oil was leaking into the pistons. The dealer stated that the pistons and piston rings needed to be replaced. The contact learned of an extended warranty coverage under NHTSA ID Number: 10234800 (Equipment). The vehicle had not been repaired. The manufacturer was made aware of the failure. The manufacturer confirmed that the vehicle was not covered under NHTSA ID Number: 10234800 (Equipment) extended warranty coverage due to the vehicle exceeding the mileage limitations. The approximate failure mileage was 111,000.

   NHTSA complaint 11628991
10. Filed Aug 17, 2024Failure Jul 14, 2024Glen Allen, VAEngine

    Volvo mechanics claim the engine seized due to alternator pulley failure, however, at the time of the event, the engine showed no oil on the dipstick despite having added multiple quarts of oil over the last three months. Volvo has issued an extended warranty letter to customers due to excessive oil consumption, but Volvo failed to provide this letter for this vehicle. I’ve checked Volvo databases for engines matching this extended warranty and confirmed the engine is in fact covered under this extended warranty. Due to Volvo’s failure to communicate this problem, my daughter continued to drive this vehicle until it completely lost power in high speed traffic on I-95 nearly causing an accident and stranding her on the side of the interstate for several hours. Upon arriving at the cite of this incident, I notice there was no low oil warning light illuminated on the dash, so I double checked oil dipstick and added at least two quarts of oil. Unfortunately the engine had already seized at this point and the vehicle was inoperable.

    NHTSA complaint 11609144
11. Filed Apr 25, 2024Failure Apr 17, 2024Chesterfield, MOElectrical system

    Vehicle failed to start after short trip (<5 miles) with no electrical power present. Jump started from another car after approximately 1/2 hour. Drove car to home, car stalled in driveway again with no electrical power. Replaced 5 year old battery car started fine then stalled on road during test drive while approaching an intersection and suffered loss of all electrical power including inoperative hazard flashers. Transmission went into park and car could not be moved out of active traffic lane. Car towed to repair shop where cracked fuse at positive battery terminal found (see photos attached). Repair shop contacted a Volvo dealer and was informed they typically see a couple vehicles a week for same issue.

    NHTSA complaint 11585107
12. Filed Apr 13, 2024Failure Apr 11, 2024Bridgewater, NJElectrical system, Warnings, Unknown or other

    VOLVO DEALER DESCRIBE AS ISSUE: Motor mounts: Front lower engine mount collapsed, other engine mount not yet verified. Power Steering: Stiff and hard to turn wheels. Transmission: Transmission shift sometimes is not easy to move up to down.

    NHTSA complaint 11582817
13. Filed Mar 1, 2023Failure Feb 22, 2023121,000 milesAlbion, MISensors

    The contact owns a 2015 Volvo XC60. The contact stated while driving 30 MPH, the vehicle inadvertently stopped without driver input. The contact was able to drive the vehicle to the residence. The vehicle was taken to an independent mechanic and the mechanic repaired the parking brake actuator. The manufacturer was not contacted. The failure mileage was 121,000.

    NHTSA complaint 11509752
14. Filed Oct 27, 2022Failure Mar 5, 2022Hayti, MOSeat belts

    Since buying our xc60 Feb 2022, anytime we have our grandchildren we buckle their high back car seats in the rear seat of our volvo. Every time we install the car seats, the seat belts will not lock after being buckled. The implications of a seat belt failing to lock a car seat down could he catastrophic. It doesn't matter how many times we expand the belt and release it, tap the brake, buckle or unbuckle the belts will not lock. This poses a life threatening danger to children who are supposed to be safely secured in their seats. Coincidentally, the driver belt randomly locks sometimes even choking me if I lean forward quickly to get a better view. This happens without any sudden braking or change of speed. I have not visited a service center regarding the issue yet, I plan to address the issue at the upcoming vehicle maintenance and service appointment. Parents or caregivers need to be aware of this possibly dangerous failure. I check the belt tightness for our grandchildren car seats every time we stop. Until there is a resolution in place, I will attempt to find something that will keep the belt locked for a temporary solution. Please investigate for more possible complaints and issue a warning regarding this issue.

    NHTSA complaint 11491124
15. Filed Sep 29, 2022Failure Sep 21, 2022Spindale, NCEngine

    Excessive Oil Consumption! Safety issue with the speed at which the oil is depleted! I just bought this car two weeks ago and I already have had to add a quart of "synthetic" oil TWICE!, in one Weeks time! This is a safety issue. I have driven less than 500 miles each time the car alerted me to needing a quart of oil. This car was serviced by Volvo of Greenville, SC for all of it's maintenance and based on the service records, I felt safe buying this vehicle because Volvo had always serviced it! I was robbed! This engine is a Lemon and I need it replaced!!!

    NHTSA complaint 11487158
16. Filed Sep 23, 2022Failure Sep 23, 2022Mesquite, TXEngine

    Between 1000 -1500 miles Oil Level low Refill 1quart/ 1 liter request come on, had no Ideal this Volvo xc60 consume that much oil, I buy Castrol Edge High mileage SAE 5W-30 for engines over 75k at $12.98 including tax add, buying once to twice amount add up ..

    NHTSA complaint 11486027
17. Filed Jun 21, 2022Failure Jun 20, 2022Coral Gables, FLFuel/propulsion system

    In approximately 2016 we noticed a strong smell of gasoline around our new car. There was a puddle of gasoline under the car in our garage. We had the car towed to the Volvo dealership and they replaced some fuel-line components under the hood. Two days ago we started to notice a strong smell of gasoline in the passenger compartment of the vehicle. I lifted the hood and and removed the engine cover. I noticed the fuel sensor on top of the engine had fuel on it. I went to the Volvo dealer and they would not sell me a new sensor, they no longer sold just the sensor. Now, you have to buy an improved sensor and fuel line combination kit. I had the car towed to a shop as it was not safe to drive with leaking fuel. It would seem to me if Volvo was having issues with the fuel sensor that required them to quit selling the original part and re-engineer the replacement part with a new hose that Volvo is aware of a problem. This is the second gasoline leak that we have had on this vehicle related to these fuel lines and sensors.

    NHTSA complaint 11470184
18. Filed May 28, 2022Failure May 21, 2022West Haven, CTEngine, Unknown or other

    My vehicle is having an oil consumption issue. I recently purchased a vehicle and the document stated that it was a oil change completed. Called the dealership to verify that a oil change Was indeed completed. Oil light came on stating that there was no or low oil. Arrive to oil change location and there was no oil reported in vehicle. Oil change completed, and 1600 miles later I have no oil in my vehicle again. I noticed the engine running a little harder than normal, and the car is extremely difficult catching acceleration. I contacted Volvo Cars LLC, and they suggested I bring my vehicle to a dealership to have it evaluated at a cost.

    NHTSA complaint 11466531
19. Filed Feb 5, 2022Failure Dec 25, 2021Baltimore, MDSeat belts

    Seat belt loose and doesn’t tighten with sudden stops. Consumer stated that dealer has not contacted her about replacing recalled seatbelt.*JB Consumer notified dealer multiple times and their response was, “we’re very busy and we need to get the part. You will get a call when it comes in.

    NHTSA complaint 11450591
20. Filed Sep 21, 2021Failure Sep 15, 2021Plumas Lake, CAElectrical system, Engine, Fuel/propulsion systemFire

    On 9/8/2021, Niello Volvo Sacramento service replaced my fuel pressure sensor and fuel line. On 9/15/2021, my engine caught fire and the car was deemed a total loss by insurance company. I drove from my home in Plumas Lake 95961 to Marysville approximately 10 miles away at 9:50 AM, at approximately 10:00-10:05 as I was nearing the end of my trip, a trouble light came on that said “engine performance decreased” and the picture of a turtle appeared on my dash screen, shortly after that another light appeared that said “battery not charging”, I parked my car in the Save Mart parking lot and exited and noticed some smoke coming out of the hood, it was light at first but increased quickly so I called 911 immediately. As I was on the phone with 911, flames began shooting out from under the hood, so I grabbed my fire extinguisher out of the back of my car and tried to put the fire out, but extinguisher was too small, a man from the grocery store brought out a bigger extinguisher, but fire continued to grow, by now the fire dept. arrived, opened the hood and after about 10 minutes extinguished the fire with a hose. I contacted Niello Volvo but they seemed disinterested in getting involved and after a second call to them, the service manager [XXX] hung up on me. I could have been killed! If my elderly husband or mother had been in the car with me, it would have been difficult to get them out! I want to know what caused the fire! Faulty electrical system, faulty fuel sensor/fuel line which had just been installed 7 days prior? Faulty engine? There are still many 2015 Volvo XC60’s on the road and I fear for anyone driving one if there is a problem in need of recall. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

    NHTSA complaint 11433750