1996 Audi A4

89 complaints on file, page 1 of 5.

1. Filed Apr 24, 2011Failure Apr 20, 2011Morgantown, PASuspension

   WHILE DRIVING WEST ON PENNSYLVANIA RT. 401 I DROVE OVER A SMALL BUMP IN THE ROAD, WHERE A DRAIN IS BURIED UNDER THE ROAD, AND THE PASSENGER SIDE FRONT LOWER A ARM SNAPPED IN HALF AT A SPEED OF 45 MPH CAUSING A CATASTROPHIC FAILURE AND THE CAR TO GRIND TO A HALT ON THE SHOULDER OF THE ROAD.

   NHTSA complaint 10397830
2. Filed Sep 17, 2009Failure Mar 1, 2009210,000 milesMarietta, GAElectrical system, Switch

   I HAVE 1996 AUDI A4 AND EXPERIENCING THE SAME RECALL PROBLEM AS NHTSA CAMPAIGN ID NUMBER: 06V403000, WHICH IS NOT ABLE TO RETURN THE IGNITION KEY TO THE RUNNING POSITION AFTER STARTING THE ENGINE. THIS CONDITION CAUSING ELECTRICAL ACCESSORIES SUCH AS WINDSHIELD WIPERS AND HEADLIGHTS TO BECOME INOPERATIVE INCREASING THE RISK OF A CRASH. I SEE THE FOLLOWING RECALL ON YOUR WEBSITE. BUT WHEN I CONTACT AUDI AT 1-800-822-2834, THEY SAYS MY 1996 AUDI A4 IS NOT QUALIFIED FOR THIS RECALL. VEHICLE MAKE / MODEL: MODEL YEAR(S): AUDI / A4 1996-1997 MANUFACTURER: VOLKSWAGEN OF AMERICA, INC MFR'S REPORT DATE: OCT 20, 2006 NHTSA CAMPAIGN ID NUMBER: 06V403000 N/A NHTSA ACTION NUMBER: N/A COMPONENT: ELECTRICAL SYSTEM:IGNITION:SWITCH POTENTIAL NUMBER OF UNITS AFFECTED: 28594. *TR

   NHTSA complaint 10284461
3. Filed Mar 31, 2009Failure Sep 9, 2008130,000 milesSaginaw, MIElectrical system, Exterior lighting, Windshield wiper/washer

   TL*THE CONTACT OWNS A 1996 AUDI A4. THE CONTACT HEARD A LOUD SQUEALING NOISE OUTSIDE THE VEHICLE WHEN HE STARTED THE IGNITION. THE RPM'S INCREASED AND THE IGNITION KEY FAILED TO RETURN TO THE ENGINE RUNNING POSITION. IMMEDIATELY, THE IGNITION KEY WAS TURNED MANUALLY TO THE "ON" POSITION TO RESUME NORMAL OPERATION. IN ADDITION, THE WINDSHIELD WIPERS AND HEADLIGHTS BECAME INOPERATIVE WITHOUT WARNING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR INSPECTION AND NHTSA CAMPAIGN ID NUMBER 06V403000 (ELECTRICAL SYSTEM:IGNITION:SWITCH) WAS REFERENCED. THE FAILURES WERE IDENTICAL, BUT THE VIN WAS EXCLUDED FROM THE RECALL. THE VEHICLE HAS NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS 130,000 AND CURRENT MILEAGE WAS 132,000.

   NHTSA complaint 10263784
4. Filed Nov 19, 2008Failure Nov 10, 2008200,000 milesLancaster, PASwitch

   TL*THE CONTACT OWNS A 1996 AUDI A4. THE CONTACT STATED THAT HIS KEYS WERE STUCK IN THE IGNITION. HIS VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER 06V403000 (ELECTRICAL SYSTEM:IGNITION:SWITCH). THE FAILURE AND CURRENT MILEAGES WERE LESS THAN 200,000. UPDATED 12-08-08 *BF UPDATED 12/10/08. *JB

   NHTSA complaint 10249337
5. Filed Mar 19, 2007Failure Nov 1, 2006HAM Lake, MNSwitch

   1996 AUDI A4 CUSTOMER HAD REPLACED THE IGNITION SWITCH THAN A WEEK LATER HE RECEIVED A RECALL LETTER. CUSTOMER SUBMITTED THE PAPER TO AUDI AND WAS GIVEN HALF PAYMENT CUSTOMER WOULD LIKE FULL REIMBURSEMENT**CC *JB

   NHTSA complaint 10186839
6. Filed Dec 16, 2006Failure Dec 13, 2006Windsor Locks, CTSeat heater/coolerFire

   1996 AUDI A4 QUATTRO WITH LEATHERETTE PASSENGER SEAT - HEATED SEAT WAS SET AT LEVEL 6 AND WHILE A PASSENGER WAS SITTING ON THE SEAT A HOLE THE SIZE OF TWO QUARTERS WAS BURNT INTO THE PASSENGER SEAT DUE TO THE HEATED SEAT STARTING A SMALL FIRE.. *NM

   NHTSA complaint 10176313
7. Filed Oct 13, 2006Failure Oct 10, 2006120,000 milesLOS Gatos, CASwitch

   DT*: THE CONTACT STATED THE VEHICLES STARTER COMPLETELY FAILED ON TWO OCCASIONS. THE FIRST TIME, THE VEHICLE WAS TAKEN TO AN INDEPENDENT REPAIR SHOP, WHO REPLACED THE STARTER. THE VEHICLE WAS DRIVEN BACK TO THE CONTACTS RESIDENCE WITH NO PROBLEMS. THAT SAME DAY, THE CONTACT ATTEMPTED TO START THE VEHICLE AND THE STARTER FAILED AGAIN. THE VEHICLE WAS PUSHED TO THE NEARBY INDEPENDENT REPAIR SHOP, WHO DETERMINED THAT THE IGNITION SWITCH WAS DEFECTIVE, AND WAS THE CAUSE FOR THE BURNT STARTER. THE CONTACT RESEARCHED THE PROBLEM ONLINE, AND NOTICED AN NHTSA RECALL #00V317000 REGARDING, ELECTRICAL SYSTEM: IGNITION: SWITCH. ON 10/13/06, THE MANUFACTURER WAS CONTACTED, WHO CONFIRMED THE VEHICLE WAS INCLUDED IN THE RECALL, BUT THE PERIOD TO HAVE THE RECALL WORK PERFORMED HAD EXPIRED.

   NHTSA complaint 10170742
8. Filed May 15, 2006Failure Apr 13, 2006Concord, CAAir bags

   THIS IS NOT RELATED TO A MANUFACTURER COMPLAINT, BUT I AM HOPING TO GET SOME INFO ON WHO TO CONTACT FOR AN ISSUE IN A PRIVATE PARTY USED VEHICLE PURCHASE. I RECENTLY PURCHASED A CAR WITH A CLEAN CARFAX REPORT AND THE SELLER SAID IT HAD NOT BEEN INVOLVED IN ANY COLLISIONS. UPON TAKING IT TO MY MECHANIC FOR A PART FAILURE (WITHIN 24 HRS OF PURCHASE) I WAS TOLD IT HAD BEEN IN A MAJOR COLLISION WITH AIRBAG DEPLOYMENT. THE AIRBAG COVERS HAD BEEN REPLACED, HOWEVER THE SRS LIGHT WAS EITHER REMOVED OR THE WIRES CUT SO IT WOULDN'T BE ILLUMINATED. ADDITIONALLY WE'RE CONCERNED THAT THE SEAT BELTS WERE NOT REPLACED. I'M WONDERING IF THERE IS ANY RECOURSE AGAINST THE SELLER WHEN THEY DO NOT DISCLOSE THE FACT THAT THE SAFETY EQUIPMENT IS NOT PRESENT. CALLS TO THE SELLER HAVE GONE UNANSWERED. *JB

   NHTSA complaint 10157589
9. Filed Feb 1, 2006Failure Jan 1, 200650,000 milesWashington, DCHorn

   I OWN A 1996 AUDI A4. THE HORN HAS INTERMITTENTLY WORKED SINCE I'VE OWNED THE VEHICLE - SINCE 1999. I'VE TRIED ON NUMEROUS OCCASIONS TO HAVE VARIOUS DEALERS FIX THE PROBLEM SINCE THERE IS AN OUTSTANDING RECALL NOTICE FOR THE HORN ASSEMBLY (CAMPAIGN: 96V088000) BUT I'M NOW FINALLY TOLD THAT MY VIN DOES NOT FALL INTO THE APPROPRIATE RANGE. HOWEVER, THE DESCRIPTION OF THE 1996 AUDI A4 PROBLEM MATCHES MY PROBLEM EXACTLY. I WAS TOLD BY A DEALER YEARS AGO THAT TO FIX THE PROBLEM, I WOULD NEED TO REPLACE THE LEATHER STEERING WHEEL, WHICH WOULD COST APPROXIMATELY $1,000. MY VIN SHOULD BE INCLUDED IN THIS RECALL NOTICE. PLEASE ADVISE. *JB

   NHTSA complaint 10149207
10. Filed Oct 27, 2005Failure Oct 10, 200590,500 milesOdessa, FLSwitch

    (1) I RECEIVED A RECALL NOTICE (LE RECALL) FROM AUDI OF AMERICA ON THE IGNITION SWITCH ON MY 1996 A4 SEDAN. THE RECALL WORK WAS PERFORMED ON 10/10/02. AT THAT POINT IN TIME THE ORIGINAL IGNITION SWITCH HAD BEEN PERFORMING CORRECTLY FOR 69 MONTHS BUT I HAD IT REPLACED BECAUSE OF AUDI'S RECOMMENDATION; NOT BECAUSE IT HAD A MALFUNCTION. (2)IN OCTOBER OF 2005 THE REPLACEMENT IGNITION SWITCH FAILED AFTER EXACTLY 36 MONTHS OF SERVICE. I HAD PROBLEMS WITH THE WIPER BLADES AND THE A/C. BECAUSE OF THE FAILURE I EXPERIENCED PREVIOUSLY ON THE 1997 AUDI I TURNED THE MOTOR OFF THEN OPENED THE CAR DOOR AND RESTARTED THE MOTOR. I HEARD WHAT SOUNDED LIKE THE STARTER MOTOR STILL ENGAGED SO I TURNED THE MOTOR OFF AND HAD THE CAR TOWED TO REEVES AUDI. (3)REEVES AUDI REPLACED THE IGNITION SWITCH AND BILLED ME ABOUT $661 BUT AFTER I COMPLAINED THEY GAVE ME A 15% DISCOUNT SO I ENDED UP PAYING ABOUT $571 (4)I CALLED AUDI OF AMERICA. THEY WERE ABLE TO PULL UP MY EARLIER COMPLAINT ABOUT THE 1997 A4 AND CREATED A NEW FILE FOR THE 1996 A4 (50407850). HOWEVER, THEIR FINAL WORD ON THE SUBJECT WAS THAT THEY STOOD BEHIND THE 15% DISCOUNT OFFERED TO ME BY REEVES AUDI. (5)BOTTOM LINE IS THAT FOR 2 AUDI AUTOMOBILES I HAD GOOD IGNITION SWITCHES THAT HAD SERVED 59 AND 69 MONTHS BE REPLACED BECAUSE OF AN AUDI OF AMERICA RECALL AND THEN HAD THE REPLACEMENT IGNITION SWITCHES FAIL AFTER 18 AND 36 MONTHS. I AM OUT OF POCKET OVER $2500 FOR A PROBLEM IDENTIFIED BY AUDI OF AMERICA AND SUPPOSEDLY CORRECTED BY REEVES AUDI OF TAMPA. HOW CAN A CAR MANUFACTURER IDENTIFY A PROBLEM (WAS IT A SAFETY RECALL), IDENTIFY CORRECTIVE ACTION, PUT OUT A RECALL NOTICE AND THEN HAVE THE IMPROVED PART FAIL IN SUCH A SHORT TIME SPAN. MY ORIGINAL IGNITION SWITCHES NEVER DID FAIL. (6)MY CONTENTION IS THAT AUDI DID NOT CORRECT THE PROBLEM WHEN THEY PERFORMED THE RECALL, IN FACT THEY MADE THE PROBLEM CONSIDERABLY WORSE. AUDI SHOULD BEAR THE RESPONSIBILITY OF REPAIRING THESE IGNITION SWITCHES A 2ND. TIME. *JB

    NHTSA complaint 10140964
11. Filed Oct 24, 2005Failure Jul 1, 200587,000 milesHatfield, PASwitch

    I OWN AN 1996 AUDI A4. RECENTLY, MY HEADLIGHTS AND TAILLIGHTS HAVE STOPPED FUNCTIONING ALL TOGETHER AT VARIOUS TIMES. SOMETIMES THEY WORK FINE THE NEXT MINUTE THEY WOULDN'T. ONE NIGHT I ALMOST GOT REAR-ENDED BY ANOTHER CAR BECAUSE MY REAR TAILLIGHTS WERE NOT ILLUMINATED. SO I TOOK THE CAR TO AUDI TO GET THE PROBLEM TAKEN CARE OF. WHEN I WENT TO AUDI, THEY TOLD ME I HAVE A BAD IGNITION SWITCH AND SAID THE PROBLEM WOULD PROBABLY BE TAKEN CARE OF WITH THE REPLACEMENT OF THE SWITCH. I GOT THE WORK DONE AND THEN WENT ON THE INTERNET TO CHECK ANY RECALLS FROM THE NHTSA. A RECALL #00V317000 CAME UP AND DESCRIBED THE EXACT PROBLEM I HAD WITH MY AUDI. HOWEVER, WHEN I CALLED THE DEALER AND AUDI THEY TOLD ME THE RECALL DID NOT APPLY TO MY VIN #. I FOUND IT HARD TO BELIEVE THAT THIS HAZARD WAS TAKEN CARE OF FOR A SELECT NUMBER OF CARS BUT THERE ARE STILL CARS OUT ON THE ROADWAY THAT HAVE THE SAME EXACT PROBLEM. I THINK AUDI WOULD HAVE BEEN MUCH MORE LIKELY TO PAY FOR THE REPAIRS IF THAT FORD F250 SUPER DUTY WOULD HAVE PLACED ITS V-8 IN MY PASSENGER'S SEAT AS IT ALMOST DID. IT WAS AN AWFUL CLOSE CALL FOR ME AND I AM HAVING A HUGE PROBLEM WITH AUDI NOT TAKING RESPONSIBILITY FOR THEIR DEFECTS. *NM

    NHTSA complaint 10140655
12. Filed Aug 29, 2005Failure Aug 26, 2005Midlothian, VASwitch

    PROBLEM WITH IGNITION SWITCH CAUSING THE RETURN SPRING FORCE TO BE INSUFFICIENT FOR RETURNING THE IGNITION KEY TO THE RUNNING POSITION AFTER STARTING THE ENGINE, ALSO CAUSING ELECTRICAL ACCESSORIES TO BECOME INOPERATIVE AND RUNNING DOWN THE BATTERY. THERE WAS A RECALL CONCERNING THE IGNITION SWITCH ON THE EXACT SAME YEAR (1996) AND MODEL (AUDI A4) AND REGARDING THE EXACT SAME IGNITION PROBLEM. I HAVE SPOKEN WITH THE DEALERS SERVICE DEPARTMENT AND THE MANUFACTURER CONCERNING THIS PROBLEM. THE RECALL THEY CLAIM DOES NOT INCLUDE MY VIN NUMBER. HOWEVER, MY CAR IS A 1996 AUDI A4 AND MY VEHICLE IS HAVING THE EXACT SAME SAFETY PROBLEM COVERED UNDER THE RECALL. THE RECALL #00V317000. *JB

    NHTSA complaint 10134659
13. Filed Jul 29, 2005Failure Jul 17, 2005115,000 milesBerwyn, PASwitch

    ALTHOUGH THE IGNITION SWITCH OF MY 1996 AUDI A4 WAS REPLACED UNDER RECALL IN AUGUST 2001, IT HAS THE SAME FAILURE ALMOST EXACTLY 4 YEARS LATER. THE SWITCH NEITHER ALLOWS THE CAR TO COMPLETELY SHUT OFF NOR ALLOWS THE WIPERS, LIGHTS AND INDICATORS TO FUNCTION. *NM

    NHTSA complaint 10130578
14. Filed Jul 1, 2005Failure Jul 1, 2005100,000 milesBergenfield, NJLower arm, Control arm

    1996 AUDI A4 - AUDI A4 FRONT CONTROL ARMS ALL FAIL AT AROUND 100,000 MILES. ALL 8 OF MINE WERE REPLACED. AUDI SENT OUT A TSB FOR 2 OF THE 8 CONTROL ARMS AND ARE JERKING PEOPLE AROUND WITH THE REIMBURSEMENT. THEY WANT PEOPLE TO PROVE THAT ALL SCHEDULED MAINTENANCE WAS DONE, YET THE PARTS IN QUESTION ARE NOT REPAIRABLE OR SERVICEABLE. ACCORDING TO MY AUDI DEALER, THIS IS AN ONGOING PROBLEM THAT HASN'T GOTTEN ANY BETTER, EVEN WITH THE LATEST MODELS. THESE COST BETWEEN $300 - $500 EACH TO REPLACE FOR A TOTAL OF $3000 FOR ALL 8. THEY ARE DOING EVERYTHING THEY CAN TO PREVENT PEOPLE FROM COLLECTING ON THIS AND THIS SHOULD COVER ALL 8, SINCE ALL 8 FAIL INSTEAD OF ONLY 2. THEY SHOULD BE HELD ACCOUNTABLE FOR THE LETTER AND PAPERWORK THAT I PROVIDED TO THEM FOR REIMBURSEMENT OVER 6 MONTHS AGO. EVERY AUDI A4 HAS HAD THIS PROBLEM AND CONTINUES TO HAVE THIS PROBLEM. AUDI SHOULD HAVE TO ANSWER FOR THE POOR DESIGN AND THE BOGUS TSB LETTER THAT THEY SENT TO OWNERS.

    NHTSA complaint 10127234
15. Filed Apr 22, 2005Failure Mar 10, 199864,000 milesVenice, CASwitch

    00 V 317 000/IGNITION SWITCH: THE IGNITION SWITCH WILL NOT RETURN TO THE RUNNING POSITION AFTER STARTING THE VEHICLE. THE CONSUMER WOULD HAVE TO MANUALLY TURN THE SWITCH BACK AFTER STARTING THE VEHICLE. THE CONSUMER NOTICED THE RECALL ON THE NHTSA WEBSITE AND NOTIFIED HER DEALER. THE DEALER INFORMED THE CONSUMER THAT HER VEHICLE IDENTIFICATION NUMBER WAS NOT COVERED UNDER THE RECALL. *JB

    NHTSA complaint 10119058
16. Filed Mar 25, 2005Failure Mar 24, 200595,000 milesPittsfield, MALower arm, Lower ball joint, Upper ball joint

    WHILE DRIVING 10 MPH DRIVER'S SIDE LOWER CONTROL ARM FAILED. AS A RESULT, THE BALL JOINTS SEPERATED.*AK

    NHTSA complaint 10115883
17. Filed Feb 26, 2005Failure Feb 26, 200527,000 milesGolden Valley, MNAir bags

    AIRBAG LIGHT IS ON. ALSO HORN HAS NOT WORK FOR THE LAST 3,000 MILES. CAR ONLY HAS 27,000 ON IT. BOTH OF THESE SAFETY ITEMS ARE VERY COMMON FAILURES ON AUDI A4. IT TIME THAT THE NHTSA DOES SOMETHING. REMEMBER ITS: "PEOPLE SERVING PEOPLE" AND NOT "NHTSA SERVING THE AUTOMOBILE MANUFACTURERS." *JB

    NHTSA complaint 10112202
18. Filed Feb 18, 2005Failure Nov 10, 200467,000 milesFoster City, CARecliner

    CONSUMER NOTICED THAT DRIVER'S SEAT FRAME WAS CRACKED. VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION, AND MECHANIC DETERMINED THAT DRIVER'S SEAT FRAME NEEDED TO BE REWELDED WITH OVERLAYING METAL. *AK *TT

    NHTSA complaint 10106693
19. Filed Jan 30, 2005Failure Jan 17, 200560,000 milesAudubon, PAFuel system, Delivery

    I DETECTED A STONG ODOR OF GASOLINE IN THE PASSENGER CABIN. I TOOK THE VEHICK IN TWO WEEKS AGO AND WAS TOLD THAT A LEAK WAS FOUND IN THE FUEL LINE AT A CRIMP, SPILLING DOWN THE WHEEL WELL ON THE FRONT PASSENGER SIDE. I WAS TOLD THAT THE COST TO PERFROM THE REPAIR WOULD BE $950 AS THE ONLY WAY TO ADRESS THE PROBLEM WAAS TO REPLACE THE ENTILE FUEL LINE FROM FRONT TO BACK. I DECLINED THE APPROVE THE WORK AND PICKED UP THE CAR IN ORDER TO GET A SECOND OPINON. THE CUSE OF THE LEAK IS A MANUFACTURING DEFECT AND I HAVE MADE AN APPOINTMENT TO HAVE AUDI TAKE A CLOSER LOOK AT THE PROBLEM.*AK

    NHTSA complaint 10108256
20. Filed Oct 4, 2004Failure Sep 27, 200498,238 milesCenterburg, OHSwitch, Starter assembly

    THERE WERE NO CRASHES AND NO INJURIES RELATED TO THIS INCIDENT. I PURCHASED A 1996 AUDI A4 QUATTRO, VIN [XXX], USED ON FEBRUARY 7, 2004. ON THE INCIDENT DATE THE INGITION SWITCH FAILED CAUSING DAMAGE TO THE STARTER MOTOR. THE VEHICLE WAS TAKEN TO OUR SERVICE DEALER, MIDWESTERN AUTO GROUP, DUBLIN, OHIO WHERE THE PROBLEM WAS DIAGNOSED AS A FAILURE OF THE INGITION SWITCH HOUSING. THIS IS THE EXACT SAME FAILURE THAT INITIATED A RECALL CAMPAIGN, NHTSA CAMPAIGN ID# 00V317000 (AUDI CAMPAIGN CODE LE). THE DEALER RESEARCHED THE AUDI DATABASE AND DISCOVERED THAT THE RECALL CAMPAIGN WAS COMPLETED ON THIS VEHICLE IN 2001. SUBSEQUENTLY, THE AUDI MANUFACTURERS REPRESENTATIVE, TO THE DISPLEASURE OF THE DEALER, HAS DENIED ANY CLAIM ON THIS INCIDENT PERTAINING TO THE RECALL. THE REPRESENTATIVE STATED THAT IT IS AUDI'S POLICY THAT ONCE A RECALL HAS BEEN COMPLETED ON A VEHICLE, IT WILL NOT HONOR ANY FURTHER CLAIMS EVEN IF THE PROBLEM IS EXACTLY THE SAME. A CALL TO THE AUDI CONSUMER ADVOCATE DEPARTMENT CONFIRMED THIS POLICY, INCIDENT # [XXX]. TWO ISSUES SURFACE BECAUSE OF THIS INCIDENT. THE FIRST ISSUE IS THE ADEQUACY OF THE SOLUTION TO THE INITIAL RECALL. THE SECOND ISSUE IS AUDI'S RESPONSE AND POLICY CONCERNING IDENTICAL FAILURES OF COMPONENTS ADDRESSED IN A PREVIOUS RECALL CAMPAIGN.THE PARTS ARE BEING REPLACED AT MY COST AND WILL BE RETAINED ALONG WITH THE SERVICE INVOICE. UPDATED 07/24/2012 *JS INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

    NHTSA complaint 10093553