SUV, gasoline, AWD/All-Wheel Drive, built in Canada. Owner complaints on file from Sep 26, 2018 to Sep 24, 2026.
Owner complaints about this model year, by the year they were filed with NHTSA.
Owner complaints by component. Hover or focus a bar for the crash, fire, injury or death count.
Check a specific vehicle by VIN on NHTSA's site: a campaign may cover only part of a model year's production.
| Campaign | Filed | Subject | Component | Vehicles | Remedy |
|---|---|---|---|---|---|
| 20V-668 | Oct 29, 2020 | Start/stop accumulator endcap may have missing bolts | Powertrain | 194,105 | Part replacement |
| 19V-667 | Sep 19, 2019 | Fuel tanks may have been manufactured with an improperly sealed seam, possibly allowing fuel to leak along the seam near the fuel inlet | Fuel system | 301 | Part replacement |
| 19V-184 | Mar 7, 2019 | Rear-right seat may have insufficient welds on the head-restraint bracket | Seats | 120 | Part replacement |
| 18V-576 | Aug 30, 2018 | Rear brake caliper pistons may have an insufficient coating causing gas pockets to form, potentially reducing rear brake performance | Brakes | 210,628 | Not stated |
The full text of every complaint filed with NHTSA about this model year, newest first. Complaints are filed by owners and are not verified by NHTSA; NHTSA removes personal details before publishing.
302 complaints on file, page 1 of 16.
The contact owns a 2019 Chevrolet Equinox. The contact stated that while driving at an undisclosed speed, the accelerator pedal was depressed and went to the floorboard, but the vehicle hesitated to accelerate before lurching forward. Additionally, the vehicle lost motive power while driving 60-70 MPH and decelerated to 10 MPH. The engine revved while stopped at a red light, and the RPM was at HIGH. The check engine warning light was illuminated. The contact stated that the vehicle was taken to the dealer on six occasions for the recurring failure. The contact stated that DTC: P0401 and P0521 were retrieved and cleared after securing the air box cover after the first failure. The second time, the EGR housing was clogged with carbon, and the oil sensor failed internally and was replaced. The third time, the wiring harness and unknown sensors were replaced. The fourth time, an unknown sensor and module were replaced. The fifth time, the dealer replaced the transmission with a used transmission, but the failure persisted. The vehicle was then taken back to the dealer, and it was determined that the driver's side CV axle seal, NOx sensor 1, MAF sensor, passenger side front wheel bearing, two front tires, four TPMS, intake manifold, and air temperature sensor mount needed to be replaced. The manufacturer was made aware of the failure by phone. The failure mileage was approximately 89,000.
NHTSA complaint 11766711Car has less than 75,000 miles and needs a new transmission
NHTSA complaint 11762267The power liftgate on my 2019 Chevrolet Equinox experienced a sudden mechanical failure without warning. I pushed the automatic liftgate button and the liftgate raised normally. Once raised, the upper mounting bolt securing the power liftgate actuator severed. The actuator broke loose, struck the rear taillight assembly and pushed it outward approximately one inch, and the liftgate came crashing down without warning. My [XXX] grandson was approaching the rear of the vehicle to retrieve his golf clubs. Fortunately, he had not yet reached the area beneath the liftgate when it fell. Had he or another person been standing beneath it, I believe the sudden uncontrolled closing of the liftgate could have caused serious injury. The failure was confirmed during repair by an independent mechanic who is a former GM mechanic. He had considerable difficulty extracting the severed mounting bolt and repaired the actuator/bolt failure at a cost of approximately $400. The mechanic retained the failed parts, including the severed bolt, and they are available for inspection upon request. The actuator also displaced the rear taillight assembly. The mechanic attempted to reseat it, but the taillight still does not sit flush with the vehicle, so damage resulting from the incident remains. The vehicle and failed components have not been inspected by GM, police, or an insurance representative. I reported the incident to General Motors and received a GM case number. GM declined reimbursement because the repair was performed outside a GM dealership. There were no warning lamps, warning messages, or other symptoms that I noticed before the failure. The liftgate appeared to operate normally until the sudden failure.I reported the incident to GM under case #XXX and requested the case be reopened because the taillight remains displaced and does not sit flush. The failed parts, including the severed bolt, were retained by my mechanic and are available for inspection. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA),
NHTSA complaint 11760553While driving and turning on a flashing yellow arrow, I was hit by a truck and upon impact, my seatbelt came unbuckled and my body was thrusted into the dash, my Left knee took the impact from next to the steering wheel and my thigh was slammed into the steering wheel.
NHTSA complaint 11760489Unusual engine noise inspection at 86011 miles determined engine failure do to metal shavings and particles found in engine oils and oil filter by GM Dealership wher serviced only by them at mileage intervals on record and purchased new in 2019.
NHTSA complaint 11758764Hard brake pedal and Service Assist message. This issue was recalled for trucks and larger SUVs but not the Equinox. This is a known safety issue to Chevrolet, making my vehicle undrivable until I can come up with the $1,500 to have it towed and repaired.
NHTSA complaint 11757499The contact owns a 2019 Chevrolet Equinox. The contact stated that while driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. The contact stated that the vehicle unintendedly decelerated. The contact stated the failure reoccurred. The transmission failed to shift out of first gear, and the RPM was elevated. No warning lights were illuminated. The vehicle was towed to the dealer, where it was diagnosed with transmission failure. The contact was informed that the transmission needed to be replaced. The vehicle was being repaired. The contact referenced an unknown recall; however, the VIN was not associated with a recall related to the failure. The manufacturer was made aware of the failure, and a case was filed. The failure mileage was approximately 81,000.
NHTSA complaint 11757448In May 2026 while driving home from her job in downtown St. Louis, my daughter was driving my equinox. While traveling on the highway at the speed limit of 55 miles an hour her brakes failed and she came within a few feet of rear ending a full gas tanker truck. She was able to maneuver to the shoulder of the highway and avoid an accident. After a few moments of the engine, idling the engine completely stopped working and shut down. After having the car towed to my local mechanic at a Midas shop, they began the diagnosis. I began similar research online to find cases of similar things happening. What was diagnosed is that the vacuum pump on the brake line was faulty and broke. Pieces of this pump made their way into my engine and ruined two of the cylinders in my engine. The car is now not drivable and needs a replacement engine. Chevy knew about this faulty, vacuum pump part and they did issue recalls on other vehicles using the same part. They have also issued technical bulletins to their technicians for a diagnosing this failed vacuum pump. I have tried to contact Chevy and they have offered me no assistance. I know a class action suit has been filed for this very same issue. Chevy is aware of this issue. Chevy‘s choice to use a part they knew was faulty. Almost led to the death of my daughter.
NHTSA complaint 11755541Car fails to move while in reverse, the rpm’s accelerate but the car doesn’t move the transmission seems to not be griping when in reverse i get a reading from diagnostic saying P2723
NHTSA complaint 11753369I was driving and the suv moved forward with a jump like that scared myself, this happened several times. I just had my oil changed at the dealership of which I been working with for 20 years. A few of my sensors went out at the same time. On June 19-26 my suv refused to change gears. I pulled over and tried again. Made it home and towed it to the dealership June 22. I noticed that there are two car factories having the same issue and had a repull, so I thought that my suv would be included. Well, Not, my suv is from another factory that has no recalls. Dealership wasn’t working with me until July 17th after I reported them to BBB-and General Consumer. I met with the dealership July 24, and offered me 11600.00 just for fixing the transmission. I can’t get an answer if anyone else from factory number three has had the same problem as myself and the other two factories. My SUV is seven years and 81,000. Dealership offered to buy my car for 500.00 as is.. and after the transmission only 1000.00. This is crazy!!! I bought new and they are the only dealership that has worked on my car. I only put premium gas. Why does it matter what factory if they all have the same problems. Thank you..
NHTSA complaint 11752619To Whom It May Concern, I am submitting this formal complaint regarding my 2019 Chevrolet Equinox and the repeated failure of its brake vacuum pump. This is not an isolated repair issue. I have had the brake vacuum pump replaced or repaired three separate times, and each failure has placed my safety, and the safety of others, at serious risk. The first failure was the most terrifying. While driving approximately 65 miles per hour on my way to work, I suddenly applied the brakes and discovered that I had almost no braking assistance. The brake pedal became extremely hard, and the vehicle failed to slow down as expected. I was fortunate that traffic conditions allowed me to avoid a catastrophic accident. Had another vehicle stopped suddenly in front of me, or had a pedestrian entered the roadway, the outcome could have been fatal. Unfortunately, this was not an isolated event. The brake vacuum pump has failed two additional times, resulting in similar symptoms, including the sudden loss of brake assist and an extremely hard brake pedal. Each occurrence has left me questioning whether my vehicle is safe to operate. I recently learned that General Motors is facing a proposed nationwide class action lawsuit alleging that certain Chevrolet Equinox vehicles suffer from a defective brake vacuum pump that can fail without warning. According to the lawsuit, this defect causes a sudden loss of power brake assist, significantly increasing stopping distances and creating a serious safety hazard. The lawsuit also alleges that GM was aware of brake vacuum pump issues through technical service bulletins and customer complaints dating back several years. My personal experience mirrors these allegations exactly. The failures on my vehicle occurred without warning and created an immediate safety emergency. The fact that I have experienced this same dangerous failure three separate times strongly suggests that replacing the component alone has not corrected the underlying defect.
NHTSA complaint 11750577The contact owns a 2019 Chevrolet Equinox. The contact stated that while driving approximately 65 MPH, the brake assist warning light illuminated. The contact stated that the brake pedal was depressed but was stiff. The brake pedal was pressed with force to slow the vehicle. The contact pulled over to the side of the road, and the message "Engine Power Reduced" was displayed, and the check engine warning light illuminated. The vehicle was towed to a dealer, where it was diagnosed and determined that the mechanical vacuum pump had exploded and there were metal shards inside the engine oil, camshaft, and the timing jump, and that the engine was blown and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was unknown.
NHTSA complaint 11750245I was driving on the freeway at 64 MPH when my Brake Assist alert appeared on my dashboard. At that time I lost assisted braking capability. I was able to steer and stop my vehicle on the shoulder of the freeway. I turned the car off and was unable to start the car again. The car was towed to the dealership where they stated “ Hi Erika, the vacuum pump on your engine seized and broke the shaft and damaged the tone ring on the camshaft, there are quite a bit of metal pieced in the engine due that that failure. Unfortunately, the solution is a remanufactured engine at the cost of $11500.00 parts and labor plus tax. How would you like to proceed?” Currently we are opting to not replace the motor. It is apparent that this is a common issue with this year/make/model of vehicle.
NHTSA complaint 11748925The Fuel Pump Control Module (FPCM) connector corroded and disabled the fuel pump system. My car's fuel system failed while driving, and I had to pull over. After further research, I found that this particular FPCM and connector are located by the rear passenger axle and are exposed to the weather elements. This makes corrosion highly likely and poses a significant security threat for drivers, as there was no warning or engine light indication until moments before the failure. This is a design flaw and should be recalled by the manufacturer immediately.
NHTSA complaint 11742004Vacuum pump went out while driving down the interstate causing hard breaking. Break pedal was extremely hard to push down putting us at risk of not being able to break in time. There were on and off alerts to service breaks assist, however it was not consistently an alert. We replaced the vacuum pump and the issue seems to be resolved. The pump is not available as we tossed it in the trash.
NHTSA complaint 11738065The contact owns a 2019 Chevrolet Equinox. The contact stated that while driving at an undisclosed speed, the braking system became inoperable, and the brakes unexpectedly locked up with no warning lights were illuminated. The vehicle was taken to an independent mechanic, who diagnosed the vehicle and retrieved trouble code TSB-21NA268. The contact was informed that the brake vacuum pump connected to the crankshaft had failed and needed to be replaced. The vehicle was not repaired. The dealer was contacted. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 61,000.
NHTSA complaint 11738048Vacuum pump failed: On May 28th, 2025 the brake pedal on our 2019 Chevrolet Equinox became very hard along with check engine light, a "Reduced Power" notification, and "Brake Assist Failure" notification. After a mechanic inspected the engine, he found that the vacuum pump had shattered. The mechanic replaced the pump with an OEM replacement from GM. On May 11th, 2026 the same exact issue happened again. 1. The vehicle and/or part is available for inspection. 2. Anyone driving or riding in the vehicle is at risk due to the difficulty of braking. 3. The vehicle/component has not been inspected by the manufacturer since the 2nd incident.
NHTSA complaint 11737135The transmission system failed abruptly. I pulled away from a stoplight, had accelerated to 20-25 mph, and then the car came to a sudden stop, as if someone had put on an emergency brake. It continued to act as if the brake was on when I tried to go forward or reverse. I put it into neutral so that I could push it off the road. I realized it would drive slowly in neutral, so I drove it less than a mile back to my workplace. Regarding safety, I nearly got rear-ended when the car stopped suddenly. This endangered me and the other driver. I was headed to the freeway, then would have been crossing a bridge, to get home, so the danger could have been amplified. The dealership's service manager told me that something internally had failed in the transmission. As far as I know they haven't taken it apart to find out what internally failed. They told me that the transmission needed to be replaced. As far as I know, no one has inspected the internal components of the transmission. There were no warning lamps, messages, or symptoms prior to this incident.
NHTSA complaint 11736777I was trying to stop at a light and the brakes wouldn't work. I almost crashed into the car in front of me but I had to step on it really hard to stop. Then the brakes were stiff and it was hard to stop. I brought it to a Chevy dealer yesterday and they said the vacuum pump exploded and pieces were in the engine, and it messed up the cam shaft. This is 5l worth of damage. When I looked it up online it seems this has been an issue with GM cars and the equinox was left out of the recall which could have prevented this. I have 95k miles on this car and never had an issue until now. However it is not worth spending 5k on a car that is high in mileage.
NHTSA complaint 11736352Air bags did not deploy at all on passenger side after collision with a utility pole. Once vehicle stopped drivers side air bag was release but did not deploy the way it should to prevent injury. SUV was totaled per insurance company due to extensive damage on passenger side
NHTSA complaint 11734827Technical service bulletins and other notices the manufacturer sent to dealers. A bulletin is not a recall; the 60 most recent are listed.