Complaints over time
Complaints about the 2024 Ford F-600 SD peaked in 2025, with 1 filed
Owner complaints about this model year, by the year they were filed with NHTSA.
Source: NHTSA ODI complaints file. The lighter column runs through October.
Model year
2024 Ford F-600 SD
Other, diesel, 4WD/4-Wheel Drive/4x4, built in United States. Owner complaints on file from Jun 30, 2025 to Jun 30, 2025.
Recall campaigns covering this model year25.46M vehicles or units across those campaigns
Owner complaints1Close to the median 2024 other
Severity index0.02024 others average 11.8
First 24 months1Complaints in its first two years
Components
100% of complaints about the 2024 Ford F-600 SD name engine and cooling
Owner complaints by component. Hover or focus a bar for the crash, fire, injury or death count.
Source: NHTSA ODI complaints file. A complaint can name more than one component; it is counted under the first.
Recalls
2 recall campaigns cover the 2024 Ford F-600 SD
Check a specific vehicle by VIN on NHTSA's site: a campaign may cover only part of a model year's production.
| Campaign | Filed | Subject | Component | Vehicles | Remedy |
|---|---|---|---|---|---|
| 26V-104 | Feb 20, 2026 | When towing a trailer, the integrated trailer module (ITRM) may lose communication with the vehicle, possibly causing a loss of brake and turn… | Electrical system | 4,381,878 | Software update |
| 25V-315 | May 9, 2025 | Software error may cause the rearview camera image to delay, freeze, or not display when the vehicle is in reverse | Back-over prevention | 1,076,138 | Software update |
Source: NHTSA ODI recalls file.
Owner complaints
What owners reported about the 2024 Ford F-600 SD
The full text of every complaint filed with NHTSA about this model year, newest first. Complaints are filed by owners and are not verified by NHTSA; NHTSA removes personal details before publishing.
1 complaint on file, page 1 of 1.
- Filed Jun 30, 2025Failure May 31, 20252,950 milesLoomis, CAEngine
The contact owns a 2024 Ford F-600SD. The contact stated while driving 65 MPH, the vehicle lost automotive power. The contact shifted into neutral, restarted the vehicle, shifted into drive while looking for a safe place to pull over; however, the failure persisted. The contact stated that after several attempts to restart the vehicle, the vehicle was drivable. A dealer was contacted. The contact stated that the check engine warning light was illuminated. The vehicle was taken a dealer to be diagnosed; however, the result was unknown. The vehicle was not repaired. The manufacturer was notified of the failure but offered no assistance. The contact was referred to the NHTSA Hotline for assistance. The failure mileage was 2,950.
NHTSA complaint 11670309
Source: NHTSA ODI complaints file.
Investigations
NHTSA has not opened an investigation on this model year
Source: NHTSA ODI investigations file.
Service bulletins
29 manufacturer communications cover this model year
Technical service bulletins and other notices the manufacturer sent to dealers. A bulletin is not a recall.
- 25N10S1 Jun 23, 2026 · Other
Certain 2017-2025 F-450 – F-600 Chassis Cab Upfitted with an Aerial Bucket Frame Rail Crack - 26E01 Mar 10, 2026 · Other
Certain 2023 - 2026 Model Year F-250 – F600 Super Duty Vehicles with 6.7L Engines Powertrain Control Module (PCM) Software Update The affected vehicles were originally manufactured with Powertrain Control Module (PCM) software that did not provide the cor… - TSB 26-2086 Mar 2, 2026 · Service Bulletin/Repair Instructions
Some of the vehicles listed in the Model statement above may exhibit poor shift quality with an illuminated powertrain malfunction (wrench) indicator and diagnostic trouble codes (DTC) P2704 and P0771 stored in the transmission control module (TCM). This ma… - 25N10 Feb 17, 2026 · Other
Certain 2017-2025 F-450 – F-600 Super Duty Chassis Cab Upfitted with an Aerial Bucket Frame Rail Crack - TSB 26-2050 Feb 16, 2026 · Service Bulletin/Repair Instructions
This article supersedes TSB 24-2142 to update the Parts List, Service Procedure (Steps 1-2), and increase the labor operation allowances to reprogram the PCM/TCM. Some of the vehicles listed in the Model statement above may exhibit all of the following cond… - TSB 24-2259 Aug 22, 2024 · Service Bulletin/Repair Instructions
Some 2024 F-Super Duty/F-150 vehicles may exhibit a concern where the vehicle's center display screen gets stuck in a reboot loop of the Ford logo and eventually goes black. This may be due to a concern with the software on the telematics control unit modul… - TSB 24-2256 Aug 22, 2024 · Service Bulletin/Repair Instructions
Some 2023-2024 F-Super Duty vehicles built on or before 22-Jul-2024 and equipped with a 6.7L engine may exhibit an illuminated malfunction indicator lamp (MIL) with diagnostic trouble codes (DTC) P203B, P206B, and/or P2201:92 stored in the powertrain contro… - TSB 24-2142 Jun 6, 2024 · Service Bulletin/Repair Instructions
This article supersedes TSB 23-2376 to update the Part List and the Service Procedure. Some 2022-2024 F-550 and F-600 F-Super Duty vehicles equipped with a 10R140 automatic transmission and 6.7L diesel engine may exhibit an illuminated powertrain malfunctio… - SSM 52595 Jun 6, 2024 · Service Bulletin/Repair Instructions
When replacing the E clutch hub (7P211) on 2020-2024 F-Super Duty and 2024-2025 F-650/F-750 vehicles equipped with a 10R140 transmission, a new washer (7482) has been added and must be installed with the new updated E clutch hub. Refer to the Workshop Manua… - 24B27 May 13, 2024 · Service Bulletin/Repair Instructions
Certain 2023-2024 Super Duty and 2021-2025 Model Year Econoline Equipped With a 6.8L or 7.3L Gasoline Engine - Powertrain Control Module Software Update - SSM 52576 May 31, 2024 · Service Bulletin/Repair Instructions
2023-2024 F-Super Duty/F-53 Motorhome Chassis/F-59 Commercial Stripped Chassis and 2023-2025 F-650/F-750/E-Series vehicles equipped with a Dana rear axle and built on or after 01-Nov-2022 may have orange/red RTV sealant used as the gasket on the differentia… - SSM 52574 May 30, 2024 · Service Bulletin/Repair Instructions
Some vehicles equipped with SYNC4 may exhibit one or more of the following symptoms after all currently available accessory protocol interface module (APIM) software updates have been performed. - General system performance, stability, and intermittent syst… - SSM 52548 May 18, 2024 · Service Bulletin/Repair Instructions
Various vehicles equiped with 10R80/10R80 MHT/10R100/10R140 transmissions may require replacement of the seal kits (7153) when internal repairs are being performed. These kits come with 4 wheel drive (4WD) seals and will no longer include the 2WD seals. Whe… - SSM 52524 May 9, 2024 · Service Bulletin/Repair Instructions
Some 2023-2024 F-Super Duty vehicles built on 22-May-2023 and through 15-Dec-2023 may require repairs of the power steering system for various reasons. If repairing a power steering fluid leak at or near the power steering fluid cooler, a worm clamp (part n… - SSM 52477 Apr 24, 2024 · Service Bulletin/Repair Instructions
Some 2023-2024 F-Super Duty vehicles may exhibit various diagnostic trouble codes (DTCs) related to the steering angle sensor. Prior to any diagnosis, determine if the vehicle is equipped with an electronic steering actuator (ESA), also referred to as the p… - SSM 52476 Apr 24, 2024 · Service Bulletin/Repair Instructions
All accessory stick-on keyless entry keypads come with a wallet card containing the master code. If the accessory keypad was factory installed, this card will be placed in the glove box and should be handed to the vehicles owner during initial delivery. Un… - SSM 52467 Apr 23, 2024 · Service Bulletin/Repair Instructions
Some 2022 F-Super Duty vehicles equipped with a 12.3 inch center display screen and 2023-2024 F-Super Duty vehicles may exhibit DTCs B1D08 and/or B1D09 stored in the trailer module (TRM) with a Trailer Brake System Fault See Manual message in the instrument… - SSM 52455 Apr 18, 2024 · Service Bulletin/Repair Instructions
Some 2023-2024 F-Super Duty/F-53 Motorhome/F-59 Commercial Stripped Chassis or 2023-2025 E-Series/F-650/F-750 vehicles equipped with a gas engine may exhibit an illuminated MIL with ignition system DTC(s) P0352, P0353, P0354, P0355, P0357, P2303, P2306, P23… - SSM 52424 Apr 8, 2024 · Service Bulletin/Repair Instructions
Some 2023-2024 F-Super Duty vehicles equipped with a perimeter alarm and built on or before 27-Mar-2024 may exhibit a false alarm activation intermittently. This may be due to the software in the body control module (BCM). Monitor the BCM alarm event parame… - SSM 52423 Apr 8, 2024 · Service Bulletin/Repair Instructions
Some 2024 F-Super Duty non-Tremor vehicles equipped with four-wheel drive (4WD) may exhibit a slight rotational grinding noise from the front axle while driving in two-wheel drive (2WD). If the noise does not occur with the vehicle driven in 4WD, this may b… - SSM 52420 Apr 5, 2024 · Service Bulletin/Repair Instructions
Some 2023-2024 F-Super Duty vehicles may exhibit an illuminated powertrain malfunction (wrench) indicator with diagnostic trouble codes (DTC) P2122, P2123, P2127, P2128, and/or P2138 stored in the powertrain control module (PCM). The vehicle may or may not … - SSM 52389 Mar 26, 2024 · Service Bulletin/Repair Instructions
Some 2022-2024 F-Super Duty vehicles equipped with a 6.7L engine may exhibit an illuminated malfunction indicator lamp (MIL) with only diagnostic trouble code (DTC) U3012 stored in the PCM. If no drivability concerns or other DTCs are present, perform norma… - SSM 52363 Mar 15, 2024 · Service Bulletin/Repair Instructions
Some 2023-2024 F-Super Duty vehicles equipped with a trailer brake control module may exhibit a Trailer Disconnected message after cycling the ignition off and back on with a trailer connected. This may be due to the presence of an integrated battery charge… - SSM 52357 Mar 14, 2024 · Service Bulletin/Repair Instructions
Some 2021-2024 Bronco Sport vehicles equipped with a 1.5L EcoBoost engine may exhibit water coolant pump leaks. This may be due to contamination in the coolant system. To correct this condition and prevent recurrent water pump failures, perform a coolant sy… - TSB 24-2066 Mar 12, 2024 · Service Bulletin/Repair Instructions
This TSB supersedes article 24-2036 to update the vehicles affected. Some 2023-2024 F-Super Duty pickup vehicles built on or before 02-Jan-2024 equipped with a 6.7L engine may exhibit an illuminated MIL with diagnostic trouble codes (DTC) P0133, P0139, and/… - SSM 52345 Mar 8, 2024 · Service Bulletin/Repair Instructions
Some 2022-2024 various Ford/Lincoln vehicles equipped with SYNC 4 may experience concern where customers are receiving an error message when trying to enroll in connected services. This may be due to the gateway module (GWM) software. To correct the concern… - SSM 52335 Mar 6, 2024 · Service Bulletin/Repair Instructions
For 2015-2024 Ford and Lincoln vehicles equipped with turbocharged engines and customer concern of an engine oil leak, refer to Workshop Manual (WSM), Section 303-00 for oil leak inspection and testing methods. Ford has evaluated turbochargers replaced for … - SSM 52328 Mar 4, 2024 · Service Bulletin/Repair Instructions
Some 2021-2024 Bronco/F-150, 2023-2024 Escape/F-Super Duty vehicles equipped with SYNC 4 may experience a concern during accessory protocol interface module (APIM) programming where the vehicle's center display screen indicates USB Error. This may be due to… - SSM 52314 Mar 1, 2024 · Service Bulletin/Repair Instructions
During service and repair requiring removal and replacement of a crankshaft bolt and/or crankshaft damper, achieving proper torque of the crankshaft pulley bolt is critical. Incorrect torque may allow the bolt to loosen resulting in the timing gear breaking…
Source: NHTSA manufacturer communications files.