2019 Hyundai Santa Fe

200 complaints on file, page 1 of 10.

1. Filed Sep 23, 2026Failure Mar 26, 2026Georgetown, TXEngine, Power train

   On 03/26/2026, my 2019 Hyundai Santa Fe received Hyundai Service Campaign 9C2 (TSB 26-01-013H-1), which included an Engine Control Module (ECM) software update for Theta II emissions improvement. The vehicle did not have the following drivability problem before this software update. Immediately after the 9C2 update, the vehicle began jerking/bucking slightly at low speeds, most noticeably around 10-20 mph when coasting with no accelerator input or when applying very light throttle. Acceleration response also feels slower than before the update, with noticeable hesitation when the accelerator is pressed. The problem is most noticeable during the beginning of a drive when the vehicle is cold. After driving for some time and the vehicle warms up, the symptoms improve, although the change in drivability remains noticeable compared with operation before the update. There have been no warning lights or warning messages associated with the problem. The issue began immediately following the ECM software update. The vehicle has not yet been returned to the dealer for diagnosis or confirmation and is available for inspection. I am concerned about the safety implications of delayed or unpredictable acceleration response, particularly when entering traffic, crossing an intersection, or merging when timely acceleration may be necessary. I am reporting this because the condition began only after Hyundai Service Campaign 9C2 was performed and I believe NHTSA should evaluate whether this ECM software update is causing similar drivability and acceleration problems in affected vehicles.

   NHTSA complaint 11766397
2. Filed Sep 21, 2026Failure Apr 9, 2026Kapolei, HIEngine, Fuel/propulsion system, Unknown or other

   The vehicle experienced a sudden, intermittent engine stall while driving, specifically when slowing down or coasting to a stop in live traffic. When the engine dies, the vehicle immediately loses engine power, power steering, and power braking assist, creating an extreme safety hazard. After stalling, the vehicle refuses to restart for several minutes. An authorized Hyundai dealership previously replaced the high-pressure fuel pump under warranty to address this issue, but the dangerous stalling has persisted over the last 2,000 miles. The vehicle continues to randomly shut off without throwing a permanent check engine light or diagnostic trouble code, and the manufacturer has failed to correct this critical safety defect.

   NHTSA complaint 11765740
3. Filed Sep 17, 2026Failure Apr 15, 2025Sherman Oaks, CAEngine

   The car started having problems immediately after replacement with a new battery. The issue with the ISG (Idle Stop and GO System) started appearing. When the Auto Stop Indicator turns green, the car stalls which puts my life at risk. I have spoken to a number of mechanics and I am not getting a satisfactory answer on how to fix this problem.. One mechanic told me it was the starter which turned out not to be true. I have also spoken with a number of other mechanics and they are clueless on how this problem can be remedied. And the Hyundai dealter wanted $275 just to look at it but with no guarentee. The whole issue is putting my life and other motorists at risk.

   NHTSA complaint 11764874
4. Filed Sep 11, 2026Failure Sep 8, 2026Jenkintown, PA, PAEngineFire

   2019 Santa Fe with 80,000 miles showed signs of excessive oil consumption. Service was scheduled with licensed Hyundai franchise service center. Known oil consumption issues on Theta II engines for that year. Testing requires 3 steps. First step is to change the oil and document levels. Engine is tested for 1000 miles then returned to service center. After 1000 miles, service center reports 2.5 qts of oil per 1000 miles. Hyundai corporate was contacted where they approved warranty work for the vehicle. Step two requires Combustion Chamber Cleaning. During this portion of the work, service center calls about fire that took place immediately after a test drive. Dealership states engine and components destroyed.

   NHTSA complaint 11763606
5. Filed Sep 7, 2026Failure Aug 28, 2026East Aurora, NYFuel/propulsion system

   My vehicle had a very strong gas smell inside and outside of the car. I found a gas puddle under the car coming from the back of the vehicle. Car was hesitating when I stepped on the gas. I was afraid it may stall. I drove the vehicle to my regular service station. Vehicle has an active fuel leak and this is a fire hazard. I was very concerned whether the vehicle would stall and cause an accident. Warranty coverage was denied.

   NHTSA complaint 11762546
6. Filed Sep 2, 2026Failure Aug 20, 2026Sterling, VAEngine, Fuel/propulsion system, Power train

   Update Re: ODI Complaint Number: 11759237 Subsequent Actions and Manufacturer Refusal to Remediate Safety Defect: ​Following the [XXX], acute safety incident—where the vehicle lost motive power and entered severe limp mode on [XXX] immediately upon release from Sheehy Hyundai of Chantilly—the vehicle remained in dealer custody for 11 days (August 20–August 31, 2026). ​Failure to Diagnose Core Defect: Despite recurring total power loss, active diagnostic trouble code P00AF00 (Turbocharger Boost Control Module Performance), and four consecutive turbocharger destructions within 20,000 miles, the authorized dealership refused to conduct internal engine diagnostics, drop the oil pan, inspect the oil filter, or perform borescope checks. ​Physical Contamination Documented: On August 29, 2026, an on-site physical inspection confirmed sparkling metallic particulate suspended in the engine oil on the dipstick and substantial oil blow-by/intrusion into the turbocharger air intake line. ​Formal Denial of Safety/Warranty Coverage: On August 31, 2026, dealership management and Hyundai Motor America (Consumer Affairs Case #[XXX]) formally denied warranty assistance and refused engine teardown under the Theta II Lifetime Engine Warranty Settlement. Coverage was declined citing "outside influence" due to an aftermarket turbocharger assembly, while Hyundai refused to investigate the underlying engine failure contaminating and destroying the forced-induction system. ​Evidence Preservation: On August 31, 2026, the vehicle was towed to an independent facility to mitigate road hazards, conduct teardown diagnostics, and preserve the engine oil/filter for ISO-accredited spectrographic laboratory analysis. ​The manufacturer released an unsafe vehicle into traffic on August 20, 2026, and subsequently refused to investigate or remedy a documented internal engine failure that creates sudden, recurring loss of motive power. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

   NHTSA complaint 11761505
7. Filed Aug 28, 2026Failure Aug 27, 2026Waukesha, WIEngine, Fuel/propulsion system, Power train

   My vehicle recently received the Hyundai 9c2 emissions upgrade they required and since then the vehicle has had predictable acceleration issues for the first several minutes after the vehicle. While trying to slowly accelerate the vehicle with unpredictably lurch forward. Many people have been reporting this.

   NHTSA complaint 11760439
8. Filed Aug 24, 2026Failure Aug 20, 2026Sterling, VAEngine, Fuel/propulsion system, Power train

   The vehicle suffers from recurring, sudden loss of motive power and transitions into engine "limp mode" while driving in active, heavy traffic. This severe drivability defect has occurred on four separate occasions under Diagnostic Trouble Code (DTC) P00AF00 (Turbocharger/Supercharger Boost Control "A" Module Performance) and related boost/MAP faults (P0234). During these episodes, the vehicle abruptly loses acceleration capability without warning, creating an acute collision risk when navigating highway traffic and intersections. The turbocharger assembly has required replacement three separate times due to recurring oil contamination from the engine crankcase. Despite meticulous maintenance (documented synthetic oil changes every 3,000–5,000 miles since new), the manufacturer and dealership have repeatedly blamed peripheral turbo components rather than diagnosing or repairing the root cause (I suspect excessive engine crankcase pressure/piston ring blow-by based on the significant oil deposition on the turbo, map sensor, and pooling in the intake line).

   NHTSA complaint 11759237
9. Filed Jul 22, 2026Failure Apr 1, 2026Huntington, NYPower train

   Transmission was replaced under warranty by Hyundai in Nov 2024. Engine was replaced at 100600 miles in Nov 2025. Issues with the transmission were happening at that time but ignored by dealership as issues related to failing engine. Our mechanic confirmed in April that transmission was failing and told us to go to Hyundai. We went to dealer in April 2026. They confirmed transmission needed to be replaced. They were going to contact Hyundai USA. We received no updates despite many calls to the dealer. We had to call Hyundai USA directly. They opened a case. Dealer finally called and took car in and requested good faith repair by Hyundai USA. Hyundai USA responded 2 weeks later and is not covering anything. They replaced our transmission in Nov 2024 with a refurbished transmission that they NO LONGER MAKE. Clearly due to the fact that the refurbished part doesn’t work. They now want me to pay $8000 to repair transmission. My car has been maintained on schedule by my mechanic. All paperwork available. I have had Toyotas, Hondas and chevys that have lasted close to 20 years. This has been a horribly disappointing experience. And I now need to buy a new car for my 17 year old instead of handing down. I will NEVER buy another Hyundai. I want everyone to be aware of my experience. Disgusting customer service by Hyundai USA.

   NHTSA complaint 11752203
10. Filed Jul 12, 2026Failure Jul 8, 2026Macon, GAEngine, Fuel/propulsion system, Power train

    COMPLAINT SUMMARY: [XXX] / ENGINE THERMAL FIRE RISK / WARRANTY DECEPTION My 2019 Hyundai Santa Fe (2.4L GDI Engine) is experiencing severe powertrain degradation under the known Theta II engine defect class-action framework. On November 7, 2025, the vehicle logged a Permanent Diagnostic Trouble Code (DTC) P1326 via an independent scan, indicating catastrophic internal rod bearing wear. On XXX, the vehicle was brought to Hyundai of Milledgeville for safety recall verification. Instead of executing the mandatory corporate-directed Bearing Clearance Test (BCT) to replace the failing engine block, the service department committed technical campaign malpractice. The technician forced the 9C2 ECU Software Update directly over the locked mechanical fault to suppress the dashboard warning lights and alter the vehicle's ROM ID parameter limits. When caught via a photograph of their active GDS diagnostic tablet showing 7 historical system faults, the service manager provided a truncated printed report hiding Page 1 and omitting the critical P1326 powertrain code count to evade a warranty engine replacement. Due to these unmitigated delays, the vehicle has suffered severe consequential safety damage. The advanced engine degradation and oil consumption have flooded the exhaust system, melting the catalytic converter substrate and triggering a new DTC P042000 (Catalyst Efficiency) fault immediately after the dealer visit. The extreme engine vibrations have also damaged the transmission's torque converter clutch (DTC P074100). The dealership refused a service loaner and knowingly sent a disabled consumer and an elderly passenger away in an active, failing vehicle that presents a sudden stall-on-highway hazard and a severe thermal exhaust fire risk under extreme summer heat conditions. Hyundai Motor America Corporate has failed to provide emergency towing or alternative mobility accommodations despite a registered corporate case file. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(

    NHTSA complaint 11749805
11. Filed Jun 5, 2026Failure Mar 4, 2026Pikesville, MDEngine, Fuel/propulsion system, Power train

    On March 04, 2026, I took my 2019 Hyundai Santa Fe to the local dealer for oil change service. As part of that service visit, they performed Hyundai recall 9C1 which was supposed to lower tailpipe emissions. The next morning, and ever since, my vehicle ran differently. The engine had several 1000rpm surges and was sluggish at other times. This behavior has continued. Particularly when I first start out in the morning and the engine is cold. Never after the engine is warmed up. A visit to the Hyundai forum shows a growing list of other Hyundai owners who are experiencing the same issues. This recall is defective and should be corrected.

    NHTSA complaint 11742383
12. Filed Jun 5, 2026Failure Jun 4, 2026Philadelphia, PAEngine, Power train

    My 2019 Hyundai Santa Fe 2.4L (VIN: [XXX]) is experiencing a severe safety defect involving rapid engine oil starvation. The vehicle recently failed an official oil consumption test conducted by Fred Beans Hyundai of Abington, where it was documented that the engine consumed 1 quart of oil in just 881 miles (PA Request #XXX). This vehicle is equipped with the Theta II engine, which currently has active warranty extensions (TXXC and TXXI) specifically covering connecting rod bearing failure. Despite the documented severe oil loss—which is the primary known cause of connecting rod bearing wear and sudden engine seizure—Hyundai Corporate (Case #XXX) is refusing to evaluate the vehicle under these warranties. They have improperly classified my claim as a denied "goodwill" request and are refusing to perform a connecting rod bearing clearance test to determine if the bearings have been damaged by this starvation. Because Hyundai refuses to perform the required diagnostic safety protocols, the vehicle must be driven in an oil-starved condition. This poses an imminent and severe safety risk of sudden engine seizure, stalling, and complete loss of motive power at highway speeds without warning, which could result in a catastrophic crash. The manufacturer is ignoring their own failure thresholds and putting driver safety at risk. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

    NHTSA complaint 11742308
13. Filed May 30, 2026Failure Dec 1, 2025Farmingdale, NYPower train

    In December 2025, a Hyundai dealer performed Service Campaign 9C2 (TSB 25-01-087H), an ECU software update for the 2.4L GDI Theta II engine, during a routine annual NY state emissions inspection. Immediately following this update, the vehicle began exhibiting an RPM flare of approximately 1,200-1,500 RPM during upshifting under light acceleration. This behavior did not exist prior to the update. The condition occurs when ambient temperature is above 50°F and the vehicle has been parked 2+ hours after a prior drive. No warning lamps or fault codes have been present at any point. The issue has been confirmed across four dealer visits at two Hyundai dealerships over five months. Attempted remedies included transmission ECU updates and adaptive resets — none resolved the condition. On the fourth visit, the technician personally experienced the issue and identified reinstalling the pre-update ECU calibration as the likely fix, but stated the prior software version was unavailable. The repair order was nonetheless closed as "vehicle operating as designed." The case has been escalated to Hyundai Motor America National Consumer Affairs and forwarded to Hyundai engineering with no resolution to date. Multiple other 2019-2020 Santa Fe owners report identical post-9C2 symptoms on public forums, indicating a pattern associated with this campaign's ECU calibration. The unexpected RPM surge and erratic shifting during acceleration creates an unpredictable driving experience that could cause hesitation in traffic situations requiring smooth acceleration.

    NHTSA complaint 11741031
14. Filed May 21, 2026Failure May 7, 2025Tulsa, OKUnknown or other

    Vehicle: 2019 Hyundai Santa Fe, VIN [XXX] , exterior Quartz White Pearl. Component: Exterior factory paint (paint/trim). Complaint: This vehicle exhibits a systemic, progressive factory paint defect — excessive peeling and bubbling of the white finish that spreads from one body panel to the next. This is a known defect across this vehicle generation; Hyundai acknowledged it by issuing Warranty Extension Z05 (TSB 25-BD-004H), which extends paint coverage to 10 years/unlimited miles for affected white-paint vehicles including the 2019 Santa Fe. Hyundai repaired the hood under this warranty in 2025, during which the vehicle was out of service for 77 consecutive days. Since that repair, the defect has migrated to the adjacent fender and has also appeared on a door, demonstrating that it is spreading across the vehicle. Hyundai has offered to repaint only the single currently-visible panel rather than addressing the systemic defect. I am filing this complaint to document the defect and its progression, and to support the public record regarding factory paint failure on these vehicles. No crash, injury, or fire has resulted. The vehicle is owned by my spouse; I am submitting as authorized representative. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

    NHTSA complaint 11739369
15. Filed May 11, 2026Failure May 1, 2026Buda, TXUnknown or other

    Hyundai recently had a service campaign that was issued to address an emissions related issue in CA. The service campaign was 9C2 and the TSB was 25-01-087H. After this software update was applied to my vehicle the engine is now sluggish on a cold start and the transmission is shifting differently at low speeds and low gears. It appears that the performance of my vehicle has been compromised. There is a Hyundai forum where many Santa Fe owners are experiencing the same issues after the software update. I have notified the service advisor at my local Hyundai dealership.

    NHTSA complaint 11737086
16. Filed May 6, 2026Failure May 5, 2026Pine Bush, NYEngine, Suspension

    Engine is burning a tremendous amount of motor oil. Dealer does acknowledge engine is burning oil. No warning lights on. Told burning motor oil is normal for a hyundai engine. Engine can seize during driving with no warning and is a safety issue. Front struts are also failing. No warning and is a safety issue: Currently trying to get dealer to cover defective components under warranty. Nothing has been repaired or resolved as of yet.

    NHTSA complaint 11736151
17. Filed Apr 30, 2026Failure Oct 10, 2024Rowland Heights, CAPower train

    Vehicle Information: 2019 Hyundai Santa Fe Mileage at failure: approximately 109,000 miles Manufacturer: Hyundai Motor Company The vehicle experienced a complete failure of the automatic transmission system. The failed component is available for inspection upon request. At approximately 98,000 miles, the vehicle’s check engine light illuminated. I brought the vehicle to an authorized Hyundai dealership for diagnosis while it was still within the 100,000-mile powertrain warranty period. The dealership inspected the vehicle and advised that no issue was found, and no repairs were performed at that time. Approximately 11,000 miles later, the vehicle experienced severe transmission problems, which progressed to complete transmission failure at approximately 109,000 miles. Safety Risk: The transmission failure resulted in a sudden loss of power and reduced vehicle operability while driving. This condition presents a potential safety risk to the driver and surrounding traffic, particularly during normal roadway and highway use. Prior Inspection / Diagnosis: The issue was not identified or reproduced during the dealership inspection at approximately 98,000 miles when the check engine light was present. Other Inspections: The vehicle was inspected by a Hyundai dealership at approximately 98,000 miles. No inspection by police, insurance representatives, or manufacturer engineering personnel has occurred since the transmission failure. Warning Signs: Check engine light illuminated at approximately 98,000 miles Vehicle was taken to dealership for diagnosis at that time No specific transmission warning messages were displayed Dealership reported no issue found Maintenance History: The vehicle has been regularly maintained with oil changes performed approximately every 5,000 miles. Maintenance records are available for review upon request.

    NHTSA complaint 11734899
18. Filed Apr 21, 2026Failure Nov 13, 2025New Kensington, PAEngine

    Engine continuously burns oil excessively and the dealership is falsifying the oil consumption test. At my local oil change shop, there is no oil left on dipstick at 3,000 mile interval. When I took it to dealer for consumption test, they checked dipstick after 1,000 miles and it was OVER THE FULL LEVEL. How can the oil be over the full level? This indicates they overfilled it to begin with and invalidated the test. Hyundai corporate is doing everything they can do avoid addressing this issue with the 2.4 engine in these models. Additionally, the transmission already failed less than 70k miles on the car.

    NHTSA complaint 11732764
19. Filed Apr 13, 2026Failure Jan 6, 2026Herriman, UTEngine, Power train

    we took it in to be looked at after it had a o2 sensor go bad I changed the sensor and checked fluids I noticed the oil was a touch low and it had metal on the dipstick. I took in to dealership for repair / replacement and Hyundai denied the claim. Even after I have video proof from the dealer technician saying there is metal and bearing material in the oil. I took it to another dealership and they found metal in the oil control valve and still denied it. We got the car back because we were not provided a loaner or a rental. I called back in with concern that the car had a weird burning smell and the car would die. Then it started sounding weird as well. Then called again Saturday because I checked oil and it had fuel smell in the oil. Now today it left my family stranded on the highway. I have th 100,000 mile ten year warranty and the car is only at 83480 miles now when this all started it was at 82000. I have expressed my concern of safety before it finally left my family vernable to be injured in the lane that it died in This afternoon. Many denied claims and now very dangerous situation that was preventable and could have cause fire or death. I brought to manufactures attention early to prevent a accident happening. I was denied all the way through the process .

    NHTSA complaint 11730989
20. Filed Apr 5, 2026Failure Apr 5, 2026Mechanicsburg, PABody

    The door was completely shut - I was driving on the highway - no alarm on the instrument panel, fully stage 2 latched ( even if it is just stage 1 latched - the instrument panel gives an alarm - there was no alarms about door not fully closed) everything was normal. 15 minutes into the drive - I was exiting the highway, making a right hand turn - the door suddenly popped open, alarm went off on the instrument panel - thankfully did not swing open, I was able to hold onto the door. I shut the door again - drove for 200 Miles - no issue again. This was the first ever time I saw this issue at 90K miles

    NHTSA complaint 11729290