2016 Lincoln MKC

80 complaints on file, page 1 of 4.

1. Filed Sep 22, 2026Failure Sep 1, 2026Eagan, MNFuel/propulsion system, Power train, Suspension

   I purchased this vehicle 3 weeks ago from CarMax Brooklyn Park, MN. Within 50 miles of driving, the vehicle threw a Ford Diagnostic Trouble Code P1450 indicating a Unable to bleed up fuel tank vacuum( excessive vacuum in the fuel tank). This defect causes an improper fuel tank vacuum, presenting an immediate engine stalling hazard at highway speeds. Concurrently, the vehicle has a very noticeable floorboard/chassis vibration at 60+ mph when releasing the foot of accelerator, making highway operation highly unstable. CarMax's warranty service department at Brooklyn Park has actively denied authorization to let me use a certified RepairPal partner facility located 10 minutes from my house. Instead, they are explicitly demanding that I drive this defective, stall-risk vehicle on the highway for over 45 minutes to their Brooklyn Park dealership to receive warranty service. Forcing a consumer to drive a vehicle with a known highway powertrain vibration and a critical EVAP vacuum fault creates an immediate, severe highway safety hazard.

   NHTSA complaint 11766044
2. Filed Aug 26, 2026Failure Jun 26, 2021Watertown, WISteering

   The vehicle displayed service advanced track, hill assist and traction control warning lights and immediately locks up steering and jars the steering wheel pulling vehicle to left or right abruptly before returning to normal. It has continued to happen and I’ve taken the vehicle to the dealership numerous times and they state they are unable to replicate yet it continues to happen and codes .this vehicle is throwing codes consistently and kicks off traction control. It’s almost caused me to hit another vehicle and a few of the cement barrier’s and put me in ditch a few times since the initial incident.

   NHTSA complaint 11759744
3. Filed Aug 14, 2026Failure Aug 14, 2026Chula Vista, CAElectrical system

   Two years waiting for recall repair (rear-backup camera). Lincoln Mfg notified that a pending recall/repair for driver's rear-camera was required. As of 08/14/2026 the repair has not been performed by Lincoln Mfg or it's agents. Rear-camera fails to work consistanly and is a danger to pedestrians. Local dealerships (Sedano Lincoln, Arron Ford , and Pacific beach Ford) have failed to repair the known camera issue upon inspection. My only recourse is contract an independent technician to make the vehicle safe to operate.

   NHTSA complaint 11756986
4. Filed Jul 8, 2026Failure Jun 28, 2026Taylorsville, KYEngine

   2.0 Ecoboost coolant intrusion in cylinder #4 issue with block defect. Ford Motor Company wont cover issue.

   NHTSA complaint 11749189
5. Filed May 20, 2026Failure Dec 28, 202356,000 milesKaty, TXBack over prevention

   The contact owns a 2016 Lincoln MKC. The contact took the vehicle for a recall repair for notice received NHTSA Campaign Number 25V572000 (Back Over Prevention). The dealer advised the contact that they had to go through the radio to complete the recall repair but this would be at the owners expense. The contact stated that the radio went out when the rearview camera went out. The manufacturer was not notified of the issue. The contact believes that the issue with the radio is related to the recall. The approximate failure mileage 56,000.

   NHTSA complaint 11739043
6. Filed May 15, 2026Failure Jan 12, 2026North Port, FLEngine

   My 2016 Lincoln MKC with a 2.0L EcoBoost engine experienced coolant intrusion into cylinder 3, leading to engine misfire and check engine light to turn on. The dealership confirmed the issue for $176.55 and recommended a full long block engine replacement, estimated at over $11,000. This failure occurred at 98,000 miles. Two weeks before this, the check engine light illuminated and we took it to a repair shop where we paid $628 to repair the purge valve and fuel pressure sensor, while it was most likely this coolant intrusion both times! Ford and Lincoln (including concierge) have refused any assistance in this matter. The local dealership has also said that they cannot help us with any of the cost. I've found this to be a very well documented problem/engine design failure, Including HTSA ID Number: 10162062 Manufacturer Communication Number: TSB 19-2172 entitled Components: ENGINE AND ENGINE COOLING The TSB acknowledges a design-related coolant leak into the engine cylinders that can cause white smoke, misfire, rough running, and warning lights. Ford’s recommended repair is to replace the long block assembly. In addition, this appears to be the exact issue described in Ford TSB 19-2346, which covers 2017–2019 model year vehicles with the 2.0L EcoBoost engine, including the Lincoln MKC and MKZ. I believe this is a widespread design defect and request NHTSA’s investigation to ensure proper manufacturer accountability. I am so thankful that this car does not belong to one of my daughters as it poses a severe safety hazard on the road and it is going to be a huge financial setback that we may not recover from.

   NHTSA complaint 11738186
7. Filed May 6, 2026Failure Dec 10, 2025Lavalle, WIEngine

   I have Coolant intrusion in cylinder #2 91000 miles this should be a recall it's a problem that's well documented There's a recall for the back up camera hope the camera can see through the white smoke!

   NHTSA complaint 11736199
8. Filed Apr 28, 2026Failure Apr 28, 202660,000 milesLong Beach, CAEngine, Engine and engine cooling

   The contact owns a 2016 Lincoln MKC. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to a dealer, where it was diagnosed that the supercharger-A and the under boost needed to be replaced. The vehicle was repaired; however, the check engine warning light was illuminated again. The manufacturer was not notified of the failure. The failure mileage was approximately 60,000.

   NHTSA complaint 11734365
9. Filed Mar 11, 2026Failure Jun 1, 202570,000 milesSeminole, FLBack over prevention

   The contact owns a 2016 Lincoln MKC. The contact received notification of NHTSA Campaign Number: 25V572000 (BACK OVER PREVENTION); however, the part to do the recall repair was not yet available. The contact stated that while in reverse(R), the rearview camera intermittently displayed a distorted image with squiggly, horizontal lines. The contact stated that the failure obstructed the driver's view while in reverse(R). The local dealer was contacted about the failure and confirmed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The failure mileage was approximately 70,000.

   NHTSA complaint 11723574
10. Filed Feb 12, 2026Failure Nov 11, 2024Springfield, ILElectrical system, Engine, Power train

    When driving you could smell fumes, it would jerk, and kick in and out of gear and would have no heat. Coolant was always low with no visible leaks to the mechanic.

    NHTSA complaint 11717638
11. Filed Jan 22, 2026Failure Jan 22, 2026Florissant, MOEngine

    I have a coolant leak and the dealership states that it's located in the engine.

    NHTSA complaint 11712783
12. Filed Jan 22, 2026Failure Mar 16, 2025Florissant, MOUnknown or other

    Ford does not have the parts to repair my car; my rear camera gets fuzzy at times

    NHTSA complaint 11712782
13. Filed Dec 10, 2025Failure Sep 10, 2025200,000 milesHenderson, TXBack over prevention

    The contact owns a 2016 Lincoln MKC. The contact received notification of NHTSA Campaign Number: 25V572000 (BACK OVER PREVENTION); however, the part to do the recall repair was not yet available. The contact stated that the rearview camera displayed a black screen or was glitching while the vehicle was in reverse(R). The contact stated that the failure obstructed the driver's visibility, which prevented the driver from safely operating the vehicle. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The failure mileage was approximately 200,000.

    NHTSA complaint 11704256
14. Filed Dec 9, 2025Failure Dec 31, 1969Little Rock, ARFuel/propulsion system, Service brakes, Steering

    As far as everybody did and shut down three times in a major intersections as far as to completely shut off or keep up with the camera activity and it seems to not be able to empower through the cabin or central part of the cabin where the computer is stored when I had my f****** completely turn itself off and ran or red lights just to barely make it to my house and in the car would not start I had various problems with his car and I admit paid thousands at this point to see it keep up with it and I've seen it the under several recalls and just now seeing that my car is reaching some of the max amount that I've ever even been issue. I've never received an email on this car having a recall because I moved a few years ago and although I pick up my mail there I've never received anything from Lincoln or have I had any things in the middle for you guys my main concern is getting this rental car in place while all these updates I haven't paid for are completely addressed immediately and in their entirety no longer putting my life safety and the lives of others at risk around me

    NHTSA complaint 11704024
15. Filed Oct 16, 2025Failure Aug 1, 2025158,000 milesSan Antonio, TXEngine, Engine and engine cooling

    The contact owns a 2016 Lincoln MKC. The contact stated that while starting the vehicle, the vehicle was shaking, and the check engine warning light was intermittently illuminated. The contact stated that her brother had replaced the spark plugs and ignition coils. The vehicle was taken to the dealer, who determined that there was coolant intrusion into the engine. The contact was informed that the spark plugs and coils needed to be replaced with OEM parts, and the turbocharger, purge valve, vacuum line, long block, and fuel pressure sensor needed to be replaced. The contact stated that her nephew replaced the spark plugs and ignition coils with OEM parts, and AAMCO replaced the fuel pressure sensor; however, the failure recurred. The vehicle was not repaired. The manufacturer was made aware of the failure and advised the contact to report the failure to the NHTSA Hotline. The failure mileage was approximately 158,000.

    NHTSA complaint 11693918
16. Filed Sep 6, 2025Failure Aug 18, 2025North Port, FLEngine, Power train

    At 85,000 miles I was experiencing a grinding noise coming from my front end when making sharp turns to left or right. Took car to my mechanic immediately for diagnosis. They found the motor mounts and rear differential is binding and close to failure. My mechanic contacted FOMOCO to see about a replacement for the rear differential and was told that there were not any available due to a REDESIGN of the product. He was asked to check back in two weeks! Two weeks w/o my transportation! I replaced the motor mounts, (85Kmi?) After researching on line, several ford & lincoln sites the problems I am experiencing are not unique or infrequent on Lincolns and ford Edges. It would seem to me that these problems are frequent enough to have the manufacturer ininitiate a recall on these products! My mechanic also works on our Sherriff department vehicles and their Ford Edge units are experiencing same problems. I would hope these problems will initiate an investigation into this matter!

    NHTSA complaint 11685464
17. Filed Aug 26, 2025Failure Aug 15, 2025Calhoun, GAEngine, Fuel/propulsion system

    While driving a short distance to work, my 2016 MKC check engine light came on. The previous week I noticed that the engine hesitated slightly when it first started, but it drove normally. However, when the light came on, my husband took the vehicle to the dealership where we bought it in Dec 2019. We were shocked when we were told this was a very common problem with this type of engine, a 2.0 eco boost, and that the engine would have to be replaced due to coolant intrusion, at the cost of $9300! The vehicle only has 57,000 miles on it and has always been maintained at Prater Ford Lincoln in Calhoun GA. After some research I've found this to be a very well documented problem/engine design failure. Ford and Lincoln have refused any assistance in this matter. The local dealership where we purchased it has told us they won't provide any assistance either. The vehicle is currently in the shop, and the engine is being replaced. It was supposed to be completed 5 days ago. Why hasn't there been a recall? Even though there were no deaths or injuries in my case as well as the others on this site, the financial burden is immense! Since this is such a well-documented problem, there should be a recall on the affected engines, or at the very least some assistance should be provided by Ford and/or Lincoln to the unfortunate owners of these vehicles. Thank you.

    NHTSA complaint 11683109
18. Filed Aug 5, 2025Failure Jul 31, 2025Arlington Heights, ILEngine

    Engin light came on, was diagenosed as coolent leaking in spark plug , or Bad head gasket.

    NHTSA complaint 11678445
19. Filed Aug 2, 2025Failure Jul 4, 2025Douglasville, GAPower train

    Was at the Drive-thru ordering speaker and the car would not shift out of park and could not manually be shifted into neutral so the car could be moved. Drive-thru ordering window was blocked for 16 hyrs. Had to have the car towed with dolly. Vehicle was inspected by independent mechanic and found that the bushing was damaged.

    NHTSA complaint 11678022
20. Filed Jul 18, 2025Failure Mar 1, 2025120,000 milesLakeland, FLEngine and engine cooling

    The contact owns a 2016 Lincoln MKC. The contact stated that while driving at an undisclosed speed, there was white smoke coming from the exhaust pipe. Upon inspection, the contact discovered a low coolant level. The vehicle was taken to an unknown dealer, who determined that there was coolant intrusion into cylinders #2 and #3. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 120,000.

    NHTSA complaint 11674460