2008 Mini Cooper S

168 complaints on file, page 1 of 9.

1. Filed Mar 6, 2024Failure Mar 3, 2024111,000 milesKnightstown, INElectrical system

   The contact owns a 2008 Mini Cooper S. The contact stated that the check engine warning light was illuminated. Additionally, the windows would roll down independently and the sunroof would fail to close completely. The vehicle was taken to AutoZone, where it was diagnosed that the failure was related to the braking system; however, the contact stated that new brake hardware had been installed on the vehicle. The contact related the failures to NHTSA Campaign Number: 23V337000 (Electrical System); however, the part to do the recall repair was not yet available. The local dealer was contacted, but no assistance was provided. The vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 111,000. VIN tool confirms parts not available.

   NHTSA complaint 11575724
2. Filed Nov 17, 2023Failure Jul 1, 2023Topeka, KSElectrical system

   The contact owns a 2008 Mini Cooper S. The contact received notification of NHTSA Campaign Number: 23V337000 (Electrical System) however, the part to do the recall repair was not yet available. The local dealer was made aware of the issue and confirmed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

   NHTSA complaint 11555606
3. Filed Oct 28, 2020Failure Oct 23, 202081,253 milesHenderson, KYAir bags

   THE FRONT PASSENGER SEAT OCCUPANT DETECTION MAT SENSOR HAS FAILED. THE FRONT PASSENGER AIR BAG IS NOT ACTIVATE IN A CRASH WHEN THE SEAT IS OCCUPIED. RECALLS ACTIVE FOR THIS EXACT ISSUE FOR THE SAME MAKE IN OTHER YEARS AND MODELS ARE CURRENTLY RECALLED HOWEVER OTHERS ARE EXCLUDED.

   NHTSA complaint 11366861
4. Filed Sep 29, 2020Failure Jun 20, 202090,000 milesGraham, WAAir bags

   TO THE BEST OF MY KNOWLEDGE THE AIRBAG SYSTEM IS OFF LINE. THE PASSENGER AIRBAGS DO NOT TURN ON WHEN A PASSENGER IS SEATED. THE PASSENGER AIRBAG INDICATOR LIGHT SHOWS THAT IT IS NOT TURNING ON WITH OR WITHOUT A PASSENGER. ALSO THE DRIVERS SIDE AIRBAG INDICATOR LIGHT COMES ON THE DASHBOARD AND THE TACHOMETER WHEN I START THE VEHICLE. THIS PROBLEM BEGAN WHILE THE VEHICLE WAS PARKED AND STATIONARY.

   NHTSA complaint 11361883
5. Filed Sep 17, 2020Failure Sep 17, 202070,000 milesSpring, TXEngine

   TIMING CHAIN JUMPED OUT OF TIMING AND CAUSED BENT VALVES.

   NHTSA complaint 11355604
6. Filed Jun 4, 2020Failure May 29, 2020Eddy, TXAir bags, Seat belts, Seats

   WARNING MESSAGE FOR SEAT BELT TENSION/AIR BAG MALFUNCTION AND BOTH LIGHTS ARE ON. THE VEHICLE HAS 40+ THOUSAND MILES ON IT, I AM A SECOND OWNER. THIS PROBLEM JUST STARTED ON MAY 29, 2020. NO ACCIDENTS FOR THIS VEHICLE. COST FOR REPAIR IS OVER $2000 AND SO FAR THERE'S ONLY RECALLS FOR 2008 CONVERTIBLE WHICH I TOTALLY DON'T UNDERSTAND. THIS LOOKS TO BE AN ONGOING PROBLEM WITH THE MINI AND NEEDS TO BE ADDRESSED DUE TO THE AIR BAGS BEING AFFECTED. I CURRENTLY HAVE NO PHOTOS BUT CAN READILY SUPPLY PHOTOS UPON REQUEST. THE SEAT BELT LIGHT/AIR BAG EMBLEM SHOWS ON THE DASH SCREEN WHEN ENTERING THE KEY WHILE STATIONARY, NO ONE IS SITTING IN THE PASSENGER SEAT WHEN THIS HAPPENS AND DOES NOT GO AWAY WHEN OCCUPIED. *TR

   NHTSA complaint 11327289
7. Filed Jan 12, 2020Failure Dec 17, 2019144,000 milesSanta Cruz, CAElectrical system, Engine, BodyFire

   MY CAR CAUGHT FIRE WHILE DRIVING. I HAD BEEN DRIVING FOR ABOUT AN HOUR ON THE HIGHWAY. THERE WAS NO WARNING. NO CEL OR ERRORS ON THE DASH DISPLAY. CAR WAS RUNNING NORMALLY. I NOTICED SOME SMOKE. AFTER PULLING TO THE SIDE OF THE ROAD FLAMES STARTED COMING FROM UNDER THE HOOD. THE CAR WAS STILL RUNNING NORMALLY. I SHUT OFF THE MOTOR AND GOT OUT. BYSTANDERS EMPTIED AN EXTINGUISHER THROUGH THE FRONT GRILLE BUT WITHIN MINUTES THE ENTIRE VEHICLE WAS ENGULFED. CAR WAS ALMOST COMPLETELY DESTROYED. FIRE BURNED THROUGH THE FIREWALL AND CONSUMED THE INTERIOR.

   NHTSA complaint 11298643
8. Filed Dec 2, 2019Failure Nov 15, 201996,000 milesFort Worth, TXOccupant classification, Air bags

   PASSENGER SIDE AIRBAG SEAT MAT IS DEFECTIVE. JUST STOPPED WORKING. COST TO REPLACE IS OVER $2000. SO, THE WARNING LIGHT FOR DEFECTIVE AIRBAG SENSOR REMAINS ON.

   NHTSA complaint 11286523
9. Filed Apr 1, 2019Failure Mar 18, 201932,094 milesHomosassa, FLEngine

   AT 32000 MILES AN OIL LEAK WAS NOTED ON THE GARAGE FLOOR. THE FOREIGN CAR REPAIR SHOP TROUBLESHOT THE LEAK. FINAL OUTCOME: REPLACE SUPERCHARGER ASSEMBLY, VACUUM BRAKE BOOSTER PUMP AND INTAKE MANIFOLD GASKET. TOTAL COST $3,014.78 FOR A VEHICLE THAT HAS A TRADE-IN VALUE OF LESS THAN $5,000. THE FOREIGN CAR EXPERT WAS AMAZED THAT THE TURBO HAD TO BE REPLACED WITH SUCH LOW MILEAGE.

   NHTSA complaint 11193140
10. Filed Mar 28, 2019Failure Mar 1, 201970,674 milesColumbus, OHEngine

    WHILE DRIVING AT HIGHWAY SPEED ON I-71 N & N. BROADWAY EXIT IN COLUMBUS, OHIO ON MARCH 1, 2019 THE TIMING CHAIN BROKE AND CAUSED COMPLETE ENGINE FAILURE AND BENT ALL VALVES AND CYLINDER HEAD AND VALVES RESULTING IN $8821.97 IN DAMAGE TO MY ENGINE. THE CAUSE OF THE TIMING CHAIN FAILURE IS DUE TO THE PRINCE/PSA ENGINE DESIGN AND MANUFACTURING DEFECT ADMITTED TO IN THE CLASS ACTION LAWSUIT KNOW AS JOSHUA SKEEN AND LAURIE FREEMAN V. BMW OF NORTH AMERICA, L.LC. UNITED STATES DISTRICT COURT DISTRICT OF NEW JERSEY CIV. NO. 2:13-CV-1531-WHW-CLW. BMW DECLINED TO REPLACE MY ENGINE UNDER THE EXTENDED WARRANTY AGREED TO IN THE SETTLEMENT AGREEMENT OF THE ABOVE CITED ACTION. ALL AFFECTED VEHICLES SHOULD HAVE BEEN RECALLED AND MY ENGINE FAILURE COULD HAVE EASILY CAUSED LOSS OF LIFE. MY VEHICLE IS ONE OF THE CLASS VEHICLES, R56 N14 ENGINE PRODUCED BETWEEN 2006 THRU 2010. THIS IS A PRODUCT LIABILITY SAFETY CLAIM THAT IS NOT SUBJECT TO ANY STATUTORY/WARRANTY TIME LIMITATION. ALL CLASS VEHICLES SHOULD BE RECALLED DUE TO THE LOSS OF LIFE AND SAFETY RISKS. DO NOT WAIT FOR LOSS OF LIFE TO ENFORCE THE LIABILITY OF BMW FOR THEIR FAILURE TO SELF REPORT THE DESIGN DEFECT AND FAILURE TO VOLUNTARILY RECALL ALL AFFECTED VEHICLES.

    NHTSA complaint 11192292
11. Filed Mar 28, 2019Failure Mar 1, 201970,674 milesColumbus, OHEngine

    TL* THE CONTACT OWNS A 2008 MINI COOPER S. WHILE DRIVING 60 MPH, THE TIMING CHAIN FRACTURED, CAUSING A COMPLETE ENGINE FAILURE. ALL THE VALVES AND CYLINDER HEADS WERE BENT. THE CONTACT WAS ABLE TO COAST THE VEHICLE OVER TO THE SHOULDER EVEN AFTER THE VEHICLE LOST ALL POWER. THE VEHICLE WAS TOWED TO THE DEALER (MIDWESTERN AUTO GROUP, 6335 PERIMETER LOOP RD, DUBLIN, OH 43017, (614) 889-2571 WHERE IT WAS DIAGNOSED THAT THE ENGINE NEEDED TO BE REPLACED AT A COST OF OVER $8,000. THE CONTACT NOTIFIED THE MANUFACTURER AND WAS PROVIDED A CLAIM NUMBER. THE MANUFACTURER DID NOT ASSIST WITH THE WARRANTY OR RECALL,S BUT OFFERED TO PAY $2,000 TOWARDS THE REPAIR COST. THE OFFER WAS GOOD FOR SIX MONTHS. THE FAILURE MILEAGE WAS 70,674.

    NHTSA complaint 11192254
12. Filed Aug 24, 2018Failure Aug 24, 2018105,000 milesLolo, MTEngine

    MY MINI COOPER HAS A TIMING CHAIN PROBLEM IT RATTLES UPON STARTING AND I HAVEN'T DRIVEN IT .....I JUST FOUND OUT ABOUT THIS RECALL

    NHTSA complaint 11122106
13. Filed Jul 26, 2018Failure Mar 9, 2018136,000 milesChapel Hill, NCEngine

    THE VEHICLE LOST POWER WHILE DRIVING ON THE HIGHWAY AND A MINI DEALERSHIP HAS CONFIRMED THAT THE TIMING CHAIN IS THE PROBLEM ALONG WITH THE VALVES (POSSIBLY CAUSED BY THE TIMING BEING OFF). MULTIPLE CONVERSATIONS WITH MINI CUSTOMER RELATIONS HAVE GOTTEN NO WHERE AND THE MANUFACTURER REFUSES TO TAKE RESPONSIBILITY FOR THE KNOWN ISSUES WITH THE TIMING CHAIN IN THIS VEHICLE. DESPITE A CLASS ACTION LAWSUIT SPECIFICALLY ABOUT THE TIMING CHAIN, NO RECALL HAS BEEN ISSUED AND THE MANUFACTURER REFUSES TO ASSIST CUSTOMERS WITH NECESSARY REPAIRS TO THIS DEFECTIVE PART (AND OTHER DAMAGE CAUSED BY THE DEFECT). THESE TIMING CHAIN ISSUES ARE NOT ONLY AN UNDUE BURDEN ON THE CONSUMER, THEY CAN BE POTENTIALLY FATAL IF A TIMING CHAIN FAILS AT AN UNFORTUNATE MOMENT. MINI NEEDS TO ISSUE A RECALL.

    NHTSA complaint 11113824
14. Filed Feb 6, 2018Failure Jan 29, 2018120,000 milesBonifay, FLEngine

    WHILE TRAVELING ON I-10 IN TALLAHASSEE, FL AT HIGHWAY SPEED OF 70 MPH THE CAR SUDDENLY LOST POWER. BEING I THE CENTER LANE OF EIGHT (FOUR EACH DIRECTION) IT WAS ALMOST IMPOSSIBLE TO GET OUT OF TRAFFIC. SEVERAL VEHICLES MADE ABRUPT MANEUVERS TO AVOID A CRASH. ALSO AS I GOT OUT OF THE VEHICLE WAS NEARLY STRUCK BY OTHER CARS. I LATER FOUND OUT THIS WAS DUE TO A FAILED TIMING CHAIN WITH NUMEROUS COMPLAINTS AND NO RECALL. THERE WAS ALSO A CLASS ACTION SETTLEMENT AND STILL NO RECALL. THIS COULD HAVE WELL BEEN A FATAL INCIDENT.

    NHTSA complaint 11067188
15. Filed Jan 9, 2018Failure Jun 1, 201773,000 milesRichmond, VAElectronic stability control (esc)

    AS SOON AS CAR BEGINS TO MOVE THE DSC ERROR APPEARS AND THE DSC NO LONGER WORKS. I HAVE BEEN TOLD THAT THE SZL MODULE THAT CONTROLS THIS HAS FAILED AND APPARENTLY DOES THIS WITH OTHER MINI'S AS WELL.

    NHTSA complaint 11061450
16. Filed Dec 29, 2017Failure Nov 10, 201790,000 milesBonifay, FLEngine

    CAR TAKES A WHILE TO "WARM UP" HOWEVER AFTER A VERY SHORT DRIVE THE HOOD IS HOT TO THE TOUCH. IT ALSO SMELLS HOT. I LOOKED ON LINE AND SEEN SEVERAL COMPLAINTS AND THERE IS ACTUALLY AN AFTER MARKET 'DEFLECTOR' TO CHANNEL HEAT FROM THE HOOD. I HAVE NOTICED THE PLASTIC HOOD SCOOP IS DEFORMED FROM HEAT. I FEEL IT IS A MATTER OF TIME BEFORE A FIRE OR OTHER REACTION, E.G., HEAT CAUSES ANOTHER PART TO FAIL AND CAR WONT STOP, ACCELERATE OR OTHER CAUSING A CRASH. I ALSO NOTICED THE HEADLIGHT WIRING TO BE FRAYED AS IF IT HAS BEEN HOT.

    NHTSA complaint 11057397
17. Filed Oct 17, 2017Failure Jul 1, 2017115,000 milesMcdonough, GASteering

    TL* THE CONTACT OWNS A 2008 MINI COOPER S. WHILE DRIVING VARIOUS SPEEDS, SPECIFICALLY WHEN ATTEMPTING TO TURN THE VEHICLE, THE POWER STEERING SUDDENLY FAILED AND CAUSED STEERING CONTROL TO BECOME DIFFICULT. THE CONTACT STATED THAT THE POWER STEERING PUMP WOULD OVERHEAT, WHICH CAUSED THE CONTACT TO PARK THE VEHICLE UNTIL IT COOLED IN ORDER FOR THE POWER STEERING TO FUNCTION CORRECTLY. THE CONTACT CALLED MINI OF KENNESAW (2275 BARRETT LAKES BLVD, KENNESAW, GA 30144; 678-496-9565) WHO ADVISED THE CONTACT TO BRING THE VEHICLE IN FOR DIAGNOSTIC TESTING. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND INFORMED THE CONTACT THAT THE VEHICLE WAS NOT COVERED UNDER THE EXTENDED WARRANTY OR A RECALL. THE APPROXIMATE FAILURE MILEAGE WAS 115,000.

    NHTSA complaint 11034139
18. Filed Sep 16, 2017Failure Sep 1, 2017113,500 milesSpring City, PAAir bags, Seat belts

    SEAT BELT WARNING LIGHT COMES ON WHEN STARTING CAR. CALLED LOCAL MINI DEALERSHIP AND WAS TOLD THERE WAS AN "EXTENDED WARRANTY" FOR SEAT MAT SENSOR.

    NHTSA complaint 11023761
19. Filed Jul 18, 2017Failure May 31, 2017114,000 milesRedding, CAFuel/propulsion system

    MY CAR HAS 114,000 MILE ON IT. THE HIGH PRESSURE FUEL PUMP WAS REPLACED PER RECALL. THE ENGINE HAS FAILED WITH BAD INJECTORS, CYLINDERS AND RINGS. MECHANIC SAID THIS FAILURE IS PERVASIVE IN 2002 TO 2008 MODELS DO TO POOR DESIGN. THE COST TO REPAIR IS TOO HIGH.

    NHTSA complaint 11006136
20. Filed May 1, 2017Failure Feb 7, 201780,000 milesBoynton Beach, FLAir bagsCrash1 injured

    I WAS IN A BAD CAR ACCIDENT IN WHICH MY CAR WAS REAR ENDED. I WAS IN THE VERY MOST RIGHT HAND LANE ON THE HIGHWAY, AT A STOP IN STOP AND GO TRAFFIC. THE VEHICLE BEHIND ME DID NOT STOP, HITTING ME AT APPROXIMATELY 75 MPH. AS A RESULT, MY CAR SPUN OUT TO THE RIGHT AND HIT THE GUARD RAIL ON THE SIDE OF THE HIGHWAY HEAD ON. THE CAR THEN BOUNCED OFF OF THE GUARD RAIL, AND SPUN ABOUT 180 DEGREES TO THE LEFT, WHERE THE REAR END OF THE CAR THEN HIT THE SAME GUARD RAIL AND FINALLY STOPPED. WHEN THE CAR CRASHED INTO THE GUARD RAIL HEAD ON, THE AIR BAG DID NOT DEPLOY AND I HIT MY HEAD AND MY CHEST AGAINST THE STEERING WHEEL. I SUSTAINED A FRACTURE IN MY T2 VERTEBRAE AND BAD CHEST BRUISING.

    NHTSA complaint 10981563