2024 Ram 2500

59 complaints on file, page 1 of 3.

1. Filed Sep 22, 2026Failure Sep 6, 2026Massillon, OHElectrical system, Blind spot detection, Unknown or other

   While driving a phantom auto trailer light will come on and I am not tow anything. While towing phantom check brake wiring and trailer brake disconnected warning lights appear.

   NHTSA complaint 11766269
2. Filed Sep 11, 2026Failure Sep 4, 2026Harlem, GAService brakes

   While driving, the vehicle suffered a sudden, complete, and catastrophic loss of braking power due to a total failure of the brake fluid line. The vehicle had to be immediately pulled off the road to avoid a serious collision.The vehicle was transported to a certified Ram dealership service center (Southern Motors CDJR in Savannah, GA). Upon inspection, the certified factory technician discovered and documented a severe manufacturing assembly defect: the primary brake fluid line was routed incorrectly at the factory. Due to this improper routing, the line was resting in direct, constant physical contact with the hot exhaust pipe. Over time, the extreme heat from the exhaust melted completely through the brake line and the protective heat sleeve, causing an immediate drop in hydraulic pressure and total brake system failure.This is a critical manufacturing assembly error that poses an imminent life-safety risk and fire hazard to myself and other drivers of this model year. If this incorrect routing is widespread on the assembly line, it will lead to sudden brake failures at highway speeds. I am requesting a formal safety investigation into the factory routing of the brake lines relative to the exhaust system on the 2024 Ram 2500.

   NHTSA complaint 11763719
3. Filed Sep 4, 2026Failure Aug 24, 2026Maryville, TNSidewall

   LT275/70R18 Firestone E Transforce HT2 Upon seeing warning lamp for low air second time, tire was taken to independent shop for inspection and repair. Tech stated tire (23000 miles) could not be repaired because of a safety issue due to sidewall seperation defect with no sign of impact or run flat damage. The rubber was soft and thin. Could have been catastrophic had it blown out on highway. I purchased a replacement. When I took the tire to a Firestone retail store, the manager said "It's hard to tell what happened to it" obviously denying a defect and refered Me to "corporate" to try and get credit. I told him I was concerned about the other three tires because they have the same batch number. DOT VN15 TH7 5123. He stated They would do a visual inspection nothing else. I have the tire if needed for inspection. I do not feel safe driving on the other tires. This lot should be recalled.

   NHTSA complaint 11762234
4. Filed Sep 2, 2026Failure Oct 6, 2025Royse City, TXEngine

   I had a sent the vehicle in for warranty repairs for what i was told faulty lifters. the paper work shows lifters and cam was replaced and some rocker and some rods but not all. no photos provided. after my first oil change after the repair the noise is back and they state its normal and it has been noted.

   NHTSA complaint 11761636
5. Filed Aug 24, 2026Failure Nov 24, 202515,000 milesLexington, KYService brakes, Hydraulic

   The contact owns a 2024 Ram 2500. The contact stated that while depressing the brake pedal, the brake pedal went to the floorboard. The contact had to pump the brake pedal several times to stop the vehicle. The vehicle was taken to the dealer for an oil change, and the contact informed the dealer of the failure; however, the vehicle was not diagnosed or repaired. The manufacturer was not informed of the issue. The failure mileage was approximately 15,000.

   NHTSA complaint 11759006
6. Filed Jun 29, 2026Failure Mar 31, 202612,000 milesRapid City, SDElectrical system, Exterior lighting

   The contact owns a 2024 Ram 2500. The contact stated that while driving at an undisclosed speed, the trailer braking system failed to operate, slow the vehicle, or stop the trailer while the brake pedal was depressed. The contact stated that the trailer brake disconnected warning light was illuminated. The contact researched and was made aware of NHTSA Campaign Number: 26V059000 (Exterior Lighting, Electrical System); however, the VIN was not included. The vehicle was taken to a dealer, where it was diagnosed, and it was determined that the trailer brake controller needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 12,000.

   NHTSA complaint 11747148
7. Filed Jun 22, 2026Failure Jun 20, 2026Pueblo, COEngine

   This is a brand new truck with 22,000 miles, a rod came loose in the engine when i was driving it, and blew a hole in the engine at 65 MPH, the rod then shot through my oil pan, I lost all drivability, no steering, no gas and I could not see due to black smoke. I almost died! I was able to pull over all the way to the left by the grace of God, not being able to see and having cars driving by at top speeds this is a catastrophic failure and the service Tech Ethan where the truck is says this happens 1 in every 1,000 trucks! The truck is at castle rock co dodge jeep ram

   NHTSA complaint 11745646
8. Filed Jun 9, 2026Failure Nov 1, 2025Texarkana, TXService brakes

   Brakes always collapse to the Floor. You cannot stick your toe in between the brake and the floorboard. But if you pump up the brakes like you used in the 1970''s the brake will rise and you can put a full foot underneath between the brake and the floorboard. Those making the brakes stop the truck 80%better. But if you put it in 4x4 mode there is almost no stopping power at all. You only have 10% of your brakes. Both issues can cause death and or injuries! If 4x4 is used on the road for rain or snow it will cause death and if your lucky just a major injury!!!!!!

   NHTSA complaint 11743011
9. Filed May 6, 2026Failure May 6, 2026Akron, OHElectrical system, Exterior lighting, Adaptive cruise control

   The vehicle experienced repeated electrical and no-start issues believed to be related to the RF/electrical communication system. The truck has been returned to the dealership repeatedly for this issue and recently spent approximately two months at the dealership for diagnosis and repair. After finally being returned, the vehicle was completely dead the very next morning and would not start. The vehicle has also experienced dangerous electrical failures while being driven. During one incident at night, the headlights and interior electrical system became extremely dim and began flickering while an employee was operating the truck. Visibility was significantly reduced to the point the driver could barely see the roadway. During the same event, the brake pedal became abnormally hard to press intermittently, creating a serious safety concern while driving. The failure also occurred on our business lot where the truck was blocking multiple trailers needed for scheduled customer deliveries, creating operational disruption and safety concerns related to moving equipment and trailers around an inoperable heavy-duty truck. The dealership reportedly replaced or repaired an RF-related component/module during the repair process. However, the problem appears unresolved because the truck failed again immediately after being returned from service. Symptoms have included: * Complete battery drain/no-start condition * Flickering and dimming headlights/electrical systems * Intermittent hard brake pedal condition * Repeated electrical-related issues * Extended dealer downtime * Ongoing unresolved repair attempts The vehicle is available for inspection upon request. This truck is used daily for commercial/business operations. Reliability concerns are significant because unexpected electrical failure or no-start conditions can leave the vehicle stranded or create hazardous driving conditions. The issue has been reproduced after dealer repair attempts. Based on the symptoms and

   NHTSA complaint 11735965
10. Filed May 2, 2026Failure Apr 19, 2026Baytown, TXWarnings, Rearview system brakingCrash

    I was in my yard backing my truck up and the camera froze in the location that I was in and the sensors did not beep. The distance that I was backing up was not very far. It wasn't until I backed into a post in the front of my house, that I realized the camera and sensors had temporarily failed.

    NHTSA complaint 11735275
11. Filed Apr 29, 2026Failure Dec 1, 2025Hopkins, MIVisibility/wiper

    Description of the Issue: When full windshield defrost is selected—using either the infotainment system or physical HVAC controls—the system does not direct full airflow to the windshield. Instead, heated air is split between the windshield and floor vents, reducing airflow and heat at the windshield edges. As a result, ice forms and remains on the driver’s side windshield edge, beginning around the 11–12 o’clock steering wheel position and extending to the windshield edge. This occurs during cold conditions and restricts driver visibility, creating a safety hazard while driving. Safety Impact: The driver is unable to clear ice from the windshield edges, limiting visibility of adjacent lanes, pedestrians, and roadway conditions. When defrost is needed most, the system does not perform as required, preventing the driver from maintaining safe visibility. Inconsistent Operation: The HVAC/defrost system operates inconsistently under similar conditions. I have video evidence showing the system working correctly at times and failing at other times. In multiple cases, the only change was shutting the vehicle off and letting it sit. In one instance, the defrost later worked correctly the same day when ambient temperatures were warmer, suggesting a possible temperature-related or control issue. Videos documenting this behavior are available, including videos posted on YouTube. Additional HVAC Control Issue: The HVAC system will randomly set the temperature to 76°F and become unresponsive for approximately one minute. During this time, the driver cannot change any HVAC settings, creating distraction and preventing timely adjustment to address fogging or icing. This behavior is also documented on video. Repair Attempts: The vehicle has been taken to two RAM dealerships, and multiple parts have been replaced under warranty. The issue remains unresolved. A customer service case was also opened with RAM, but the HVAC and defrost issues have not been corrected.

    NHTSA complaint 11734573
12. Filed Apr 25, 2026Failure Apr 1, 2026Yukon, OKService brakes

    When coming to a stop the truck has a very spongey pedal, in order to stop the vehicle you must allow for the stop by applying brake way in advance to be able to stop. When you applying pressure to the brake pedal the pedal is soft and goes almost to the carpet floor. When towing you feel extremely concerned if you can stop especially in an emergency braking situation. This is a problem that is ongoing and is happening every time you brake. The truck has 27k miles

    NHTSA complaint 11733741
13. Filed Apr 20, 2026Failure Jan 1, 2025Winfield, KSSeat belts

    The drivers side front seat belt stopped retracting. It was fixed when the warranty was good. I also reported the passenger side, later wasn't retracting. It retracted fine when the dealer had it so they didn't do anything with it. Now the warranty is up and it's hardly ever retracting but they want me to pay for it even thought I reported it when the warranty was good. Also, the driver's side seat belt doesn't always latch. You have to shove it in several times sometimes before it clicks. Sometimes you think it's in and it will unhook later while you're driving down the road.

    NHTSA complaint 11732315
14. Filed Apr 17, 2026Failure Dec 20, 202530,000 milesMt. Vernon, KYService brakes, Hydraulic

    The contact owns a 2024 Ram 2500. The contact stated that while driving at an undisclosed speed, the brake pedal was depressed, but the vehicle failed to respond. The brake pedal was depressed to the floorboard. The brake pedal was soft, but after pumping it, the brake pedal became firm. The contact was unable to haul a trailer because the braking system was not operating properly. The contact stated that the ABS unintendedly engaged when not needed, but failed to function properly when needed. An independent mechanic bled the brake lines. The local dealer was contacted, but stated that the vehicle operated as designed. The vehicle was taken on two occasions to Don Franklin Somerset Chrysler Dodge Jeep RAM Service Center (1147 S. Hwy 27, Somerset, KY 42501), where the mechanic was able to duplicate the failure, but the vehicle was not repaired. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 30,000. The VIN was not available.

    NHTSA complaint 11731824
15. Filed Mar 13, 2026Failure Mar 5, 2026Pompano Beach, FLPower train

    At approximately 1750 miles the truck transmission began to shift in lower gears extremely violently. Every time that truck would shift in this manner, it would cause a startle effect and divert my attention away from driving to trying to determine what was going on. I immediately took the truck to my local Ram repair shop where they found metal shavings in the transmission oil pan. They told me I would need a completely new transmission. This is unacceptable with a truck with only 1750 miles on it. The dealership said they would need authorization to replace the transmission and not sure if one would be readily available. This is the fourth time this vehicle will have been at this repair facility. The first three times were for a fault code called Turbo under boost. Way too much downtime for a truck with only 1750 miles. We had to postpone our vacation since this is the only vehicle I own that’s capable of towing our boat and trailer. Because of all these issues, we have not been able to tow the trailer one time with our new truck!!!!!! When I asked the dealership what they thought the problem was they said quality control at the factory and a subpar designed for the product. If Ram doesn’t change the design of this transmission, even with a new transmission installed, I am scared this may happen again and then cause an accident.

    NHTSA complaint 11724094
16. Filed Mar 10, 2026Failure Mar 9, 2026Powhatan, VAService brakesCrash

    i WAS TRAVELING ABOUT 50MPH ON A HIGHWAY AS I WAS APPROACHING VEHICLES STOPPED FOR A TRAFFIC LIGHT I APPLIED MY BRAKES NORMALLY AND THE TRUCK WOULD NOT SLOW DOWN SO I PRESSED ON THE BRAKES AS HARD AS I COULD AND THE CAR JUST CONTINUED FORWARD TILL FINALLY I PLOWED INTO THE REAR OF ANOTHER VEHICLE. I HAD NO BRAKES, THE ABS NEVER KICKED ON OR THE VSC.

    NHTSA complaint 11723316
17. Filed Mar 3, 2026Failure Mar 2, 2026Lander, WYSeat belts

    The seatbelt retraction system on my truck has been replaced twice on the drivers side and once on the passenger side. The truck only has 40,000miles. The seatbelt retractors don't keep the shoulder strap tight when you move or get the belt first buckled. This can cause an issue if you are to get in an accident when the belt is not tight against your shoulder.

    NHTSA complaint 11721807
18. Filed Feb 24, 2026Failure Feb 20, 2026Syracuse, NYAir bags, Automatic emergency braking, WarningsCrash1 injured

    Airbags did not deploy during a significant accident where (self) Dodge Ram 2500 Laramie 2024 truck was involved in 2 front on collisions hitting 2 different vehicles at approx 65 mph (about 5 mins apart) including a 3rd part to the accident with a rear collision by a full speed tractor trailer moving the (dodge) truck about 200 ft. into the 2nd parked vehicle (blue sedan). Dodge truck (self) was not drivable after the initial accident into the chevy truck. No auto breaking and no frontal collision warning (uncertain if they are standard for the trucks or an option) occurred. The vehicle was towed and in a tow lot (is available for inspection). There is a police report and followed up with an ER visit same day. At least 3 vehicles were totaled due to this accident. The initially hit vehicle (white chevy truck) was the cause of the accident.

    NHTSA complaint 11720176
19. Filed Feb 20, 2026Failure Feb 15, 2026Texarkana, TXService brakes

    Spongy brakes, constant pumping of brakes to aid in stoping but check this out! In 4x4 mode Low 4x4 brake failure is almost 90%! I must mash the brakes as the brake peddle falls to the floor, then wait, brace and pray truck comes to come to a stop!!!!

    NHTSA complaint 11719283
20. Filed Feb 7, 2026Failure Apr 28, 2025Beech Island, SCElectrical systemFire

    On 4/28/25 our 2024 Dodge Ram 2500 truck caught fire, It had 25,880 miles on it. we bought it brand new in 9/24. Flames were coming from the engine. The fire had to be extinguished with a fire extinguisher. The truck was towed to the local Dodge dealership. Miracle Chrysler After they looked at the truck we were told that fired was caused by a faulty heater grid. The truck has been sitting at the Dodge dealership since 4/28/25 to current. Originally we were told Stellantis would buy it back then they changed their minds and said no we will repair it. As of today they still have not started the repairs. I have invoice dated 1/8/26 that sates it will cost $55,277.23 just in parts to repair the damage that does not include the labor fees and they are not sure that is all the parts they will actually need. We have been making the payment on this truck the entire time is has been sitting there $1369.87 plus renting another truck for $641 a week from Enterprise. They are going to spend more money to repair the truck than the payoff. Current pay is $62,235.41. Makes no sense. Then this week I saw on the news that RAM just issued a recall for the same truck but years 2019-2023 with 6 fires recorded for same issue faulty heater grid. I think my truck is one of the first of 2024 to catch fire from the same issue.

    NHTSA complaint 11716459