2022 Tesla Model 3

765 complaints on file, page 1 of 39.

1. Filed Sep 20, 2026Failure Sep 19, 2026Salinas, CASeats

   When the chair automatically moves to the easy in and out setting it does so without any safety measure to stop it moving when blocked. It is so strong that it crushed my hydroflask water bottle when it was stuck beneath. If that had been a foot or arm of a person, or if they were just unable to move away then it could cause serious injury like broken bones or crushing.

   NHTSA complaint 11765729
2. Filed Sep 4, 2026Failure Aug 23, 2026Charlotte, NCBody, Unknown or other, Visibility/wiper

   At approximately 32,916 miles, the powered trunk lift strut on my 2022 Tesla Model 3 separated from its mounting ball stud during normal use. There was no collision or external impact. When the strut separated, it struck the rear glass and caused the glass to break. Tesla inspected and repaired the vehicle. Tesla’s final service invoice states: “Strut failure was responsible for breaking back glass.” I am concerned that failure of the powered trunk strut attachment on a relatively low-mileage vehicle can cause broken glass and may create a safety risk.

   NHTSA complaint 11762112
3. Filed Aug 31, 2026Failure Aug 4, 2026Denver, COElectrical system, Automatic emergency braking, Adaptive cruise control

   My 2022 Tesla Model 3 Long Range has developed a failure of the Autopilot/ADAS computer. The AP computer remains installed in the vehicle and is available for inspection. The vehicle operated normally before software update 2026.26.6. Following the update, Driving Visualization and Autopilot began going offline, along with automatic headlights, automatic turn signals, emergency braking, collision and traffic warnings. The failures have continued despite software/firmware reinstall, DAS reset, camera calibration, and hard reset. Tesla Service inspected the vehicle and confirmed that the AP computer is defective and recommended replacement at approximately $2,600. I paid $120 for Tesla's diagnostic assessment. Service Mode has recorded repeated AP watchdog/kernel-panic events, including APS_w169_TurboA_SCS_LKUP, APS_w134_appMIA, APS_w135_appCritical, and PM_a041_dasMIA. The vehicle has also recorded simultaneous exits of multiple camera streams, sometimes causing camera feeds to go black while driving. Service Mode has shown the AP ECU in Coreboot/INIT, intermittent loss of communication between the AP ECU and infotainment ECU, missing GNSS Ethernet communication, and unavailable AP temperature telemetry. This creates a safety concern because multiple safety-related driver-assistance and camera-dependent systems can unexpectedly become unavailable while driving. The vehicle remains manually drivable, but the driver must unexpectedly operate without previously available functions. The failure can also affect automatic headlights and turn signals, requiring manual operation. I am reporting this as a potential safety defect because multiple ADAS/camera systems fail simultaneously and the AP computer repeatedly crashes/reboots. The failure began after a software update, although Tesla has stated that some alerts predated the update. Due to the GPS board contacting the autopilot first before the infotainment, precise location is off and navigation is unavailable.

   NHTSA complaint 11760929
4. Filed Aug 30, 2026Failure Aug 1, 2026Hermitage, TNAdaptive cruise control

   With its latest upgrade, 2026.20.6.11 with full self-driving V14 Light, Tesla no longer allows users to set a max speed. This is very dangerous, especially in school zones where the vehicle, with Full Self-Driving, consistently misreads the speed limit. There is no way to revert this "upgrade." Many people have posted about this concern, but Tesla is ignoring it.

   NHTSA complaint 11760774
5. Filed Aug 26, 2026Failure Aug 25, 2026San Antonio, TXWheels

   The Tesla service center in San Antonio Texas installed new tires and a new wheel on my vehicle and one of the tires was installed inside out based on the manufacturer’s specifications. I’ve been driving this vehicle for about 4 months /5k miles with the risk of this tire malfunctioning and causing an accident.

   NHTSA complaint 11759883
6. Filed Aug 25, 2026Failure Aug 25, 2026Boynton Beach, FLUnknown or other

   To Whom It May Concern, I am reporting what I believe is a foreseeable child-safety risk involving Tesla’s Toybox feature. Tesla allows parents to PIN-restrict Arcade, Theater, and the web browser, but Toybox remains accessible. Recently, I briefly went inside my home to use the bathroom, and my child slipped outside and climbed into my parked Tesla specifically to use the touchscreen and Toybox. Fortunately, I discovered him quickly. In hot weather, however, a child remaining unnoticed inside a parked vehicle could face serious injury or death, particularly if climate control were disabled, changed, or failed. Tesla already has the software infrastructure to restrict entertainment features. Adding Toybox to Parental Controls appears to be a straightforward safety improvement. I believe this omission creates an unnecessary and foreseeable risk to children and warrants review as a potential vehicle safety concern. Sincerely, [XXX] Tesla Model 3 Owner INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

   NHTSA complaint 11759469
7. Filed Aug 20, 2026Failure Aug 20, 2026Jackson, NJSteering

   My 2022 Tesla Model 3 has experienced recurring intermittent loss/reduction of power steering assistance. The vehicle displays “Steering assist reduced – Steering may require increased effort.” The problem has occurred multiple times over a period of months and may disappear after the vehicle is power cycled or the alert clears. Tesla previously evaluated the vehicle for this condition. On July 8, 2026, Tesla documented the steering-assist-reduced complaint and recommended replacement of the RWD steering rack/steering gear, with an estimated repair cost of approximately $3,018. On August 20, 2026, the warning occurred again. Tesla Service Mode recorded fault EPAS3S_a005_sent2Mia, described as “Torque Sensor 2 signal not received,” with the potential impact listed as “Steering assist reduced.” The vehicle simultaneously generated UI_a020_SteeringReduced. The warning subsequently cleared again, but this is a recurring intermittent failure involving the vehicle’s electronic power-assisted steering system. I am concerned that the steering assistance could become reduced or unavailable while driving. Tesla has already determined that replacement of the steering rack is required, but the repair is customer-pay. I am reporting this because this appears to be a recurring safety-related steering defect and I am concerned that other vehicles may experience the same failure.

   NHTSA complaint 11758289
8. Filed Aug 14, 2026Failure Aug 9, 2026Saint Petersburg, FLSuspension

   the suspension lower lateral links bushings are wearing down without much usage. my car had 31k miles and the bushings already need to be replaced. this is very dangerous.

   NHTSA complaint 11756922
9. Filed Aug 13, 2026Failure Jul 27, 2026La plata, MDSteering, Suspension

   I am the owner of a 2022 Tesla Model 3. The front control arms on this vehicle are defective as manufactured. From the factory, these components have demonstrated premature failure, abnormal noise, loosening, and/or separation risk that is not consistent with normal wear on a low-mileage vehicle of this age. Symptoms experienced include [describe your exact symptoms clearly and factually — examples: progressive clicking, clunking, popping, or creaking from the front suspension/wheel area; especially noticeable during low-speed turns, reverse, or over bumps; any feeling of looseness, pull, or change in handling; any actual detachment or near-detachment]. These symptoms began at approximately 75000 miles on July 27th 2026. This is not isolated wear. Front control-arm and related suspension-link failures (including lower lateral links that can detach from the subframe) have been the subject of multiple owner complaints, prior Tesla recalls (including NHTSA campaign 21V-835 for improperly torqued lateral-link fasteners on certain Model 3/Y vehicles and the later 23V-235 expansion), technical service bulletins addressing water intrusion and noise in upper control arms, and a current NHTSA preliminary evaluation (opened 2026) into front lower lateral-link detachment on a large population of Model 3 and Model Y vehicles. Owners report that failures can occur with little or no prior dashboard warning, only possible audible cues, and can render the vehicle undrivable or cause sudden changes in alignment and directional control. A sudden separation or failure of a front control arm/lateral link while the vehicle is in motion creates an unreasonable risk of loss of vehicle control, crash, or injury to the driver, passengers, and other road users. Because the condition appears to originate from factory assembly, design, or component durability issues rather than owner abuse or ordinary high-mileage wear, and because similar failures are widely reported across Tesla owners.

   NHTSA complaint 11756842
10. Filed Aug 7, 2026Failure Apr 7, 2026100,000 milesSpringfield, ORElectrical system, Exterior lighting

    The contact owns a 2022 Tesla Model 3. The contact stated that the vehicle experienced a loss of camera and safety feature functionality for eight hours daily. The message "Adaptive Headlights Feature Unavailable" was displayed. The manufacturer was notified of the failure, and a complaint was filed. The contact was referred to a service center that was over an hour away. The vehicle was not diagnosed or repaired due to the cost. The failure mileage was approximately 100,000.

    NHTSA complaint 11755531
11. Filed Aug 7, 2026Failure Aug 7, 2026West Hartford, CTAdaptive cruise control, Unknown or other

    The horn on the steering wheel rarely works UNLESS it is pressed directly in the middle. I have tried to honk the horn when there is a safety event but it rarely works. This is definitely a safety issue. This has been going on since I bought the car June 2022. Full self drive is also unsafe and it will make sudden turns, accelerate too quickly, or have phantom braking. This can be unsafe for other drivers. I heard that this is improved with newer models, but if it is unsafe for older models like my 2022, it should not be available.

    NHTSA complaint 11755527
12. Filed Aug 7, 2026Failure Aug 4, 202633,000 milesBay Point, CAElectrical systemFire2 injured

    The contact owned a 2022 Tesla Model 3. The contact stated that while the vehicle was unoccupied, the vehicle independently started while parked in the driveway and caught on fire. No warning lights were illuminated prior to the failure. The contact stated that the fire spread to the residence and the residence burned down. The contact's daughter and her significant other were able to exit the residence safely. The local Fire Department arrived on the scene to extinguish the fire. The contact stated that the fire had started near the charging port. A Police Report was not filed. In addition, the contact stated that his daughter and her significant other suffered severe mental distress. Medical attention was not sought. A Fire Report was filed. The local dealer was not contacted. The vehicle was deemed a total loss by the insurance company. The manufacturer was not made aware of the failure. The failure mileage was approximately 33,000.

    NHTSA complaint 11755495
13. Filed Aug 7, 2026Failure Aug 1, 2026Austin, TXAutomatic emergency braking, Steering, Suspension

    My car randomly gave me alerts that my steering alignment fault then came the following two days later Automatic Emergency Braking is unavailable Feature may be restored on next drive 20:55 | DI_a246 Automatic vehicle hold disabled Use brake pedal when stopping 20:55 | DI_a223 Traction control disabled Drive with caution 20:55 | APP_W264 Lane Departure Avoidance features unavailable Features may be restored on next drive 20:55 | DI_a222 Stability control disabled. I take my car to a mechanic and they show me that my lower control arms are damaged. Tesla is more than 2 weeks out for something that has caused my car to act completely unsafe and not normal.

    NHTSA complaint 11755384
14. Filed Aug 1, 2026Failure Jun 5, 2026Moorpark, CAAir bags, Electrical system, Seats

    I own a 2022 Tesla Model 3 that is just past the 5-year/60,000-mile warranty. I bought it used from Tesla inventory and picked up my vehicle on June 1st, 2026 with ~32,000 miles on the odometer. The front passenger safety restraint system alert (RCM2_a636) first appeared on June 5, 2026. On June 15 at 64,008 miles, Tesla Service confirmed the airbag alert and front passenger OCS issue. They found the occupant classification system module damaged and exposed, replaced it, and noted the passenger-side module shorting was also causing a driver-side error. Both cleared after the repair and test drive. Cost: $363.23. The same alert came back. On July 30 at 66,475 miles they found an open in the passenger seat cushion self-capacitance trace wire and the driver occupancy sensor voltage out of range. They replaced the front passenger seat cushion trim and the driver seat occupancy sensor. Alerts cleared and the self-driving button now worked from park again which never did prior showing the issue was never fixed the first time. Cost: $930.36. No crash or injury, but this is a real safety risk. The restraint system may not work as designed and airbags could fail to deploy properly. This exact RCM2_a636/OCS fault keeps happening to other Model 3 owners both before and after warranty on forums, and Tesla has service bulletins on the same parts, yet people still end up paying for the repairs who are out of warranty and also have their safety and life at risk. Please investigate this as this is a severe safety defect.

    NHTSA complaint 11754191
15. Filed Jul 31, 2026Failure Jan 29, 2026Chula Vista, CAAdaptive cruise control, Steering, Vehicle speed controlCrash

    U.S. registered Tesla operating in [XXX]. Full Self-Driving engaged. Dark, nighttime conditions. Vehicle was traveling toward low traffic zones near the edge of [XXX] when the system made a severe mistake. The car went off the main road. Driver was forced to take control off-road after the system lost control. Damage to the rims occurred. At the time of this incident, manual speed control was still available. The driver could cap the speed. That capability has since been removed by a software update. The current version is more dangerous. If the same incident happened today, the driver would have no way to limit speed or prevent the system from repeating the error. The defect is the progressive removal of driver control from the Full Self-Driving system. Earlier versions allowed manual speed caps. Current software does not. This vehicle is U.S. registered and runs U.S. software on American roads. The same defect that caused this off-road incident in Mexico now exists without the safety net of manual speed control. The software is dangerous. The removal of driver overrides makes it worse. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

    NHTSA complaint 11754099
16. Filed Jul 31, 2026Failure Jul 31, 2026Chula Vista, CAAdaptive cruise control, Vehicle speed control

    Tesla software update 2026.20.6.11 v14 Lite NA-2025.44 removed manual speed control for Full Self-Driving. The driver can no longer set a maximum speed. The vehicle chooses its own speed and it is frequently wrong and dangerous. Curves are the worst failure. The car enters curves too fast. It accelerates through curves. It does not slow to a safe speed before the curve begins. The driver has no way to cap the speed. The scroll wheel is dead. There is no override. Posted speed limits are ignored. The vehicle uses bad map data instead of reading visible signs. It will do 65 in a 55. It will not slow down when the sign says 55. The driver cannot force it to obey the posted limit. Speed control is gone. The driver is a passenger watching the car make bad decisions. This is not safe. This is not driver assistance. This is loss of control. NHTSA must require Tesla to return manual speed control immediately. A human driver must be able to cap the speed at all times. The current software removes that ability and creates a clear safety hazard.

    NHTSA complaint 11754093
17. Filed Jul 17, 2026Failure Jul 12, 2026Orland, CAAdaptive cruise control, Vehicle speed control

    On XXX, while Full Self-Driving (Supervised) was engaged, my 2022 Tesla Model 3 RWD abruptly decelerated without any visible vehicle, pedestrian, debris, or other obstacle requiring braking. Based on my best recollection, this occurred on approximately five separate occasions in clear daylight with clean cameras. On XXX, the first event occurred near XXX while traveling from [XXX] toward the [XXX]/[XXX] area. I took manual control for about 30 minutes. After I re-engaged FSD, a second event occurred and included approximately three rapid braking pulses. The occupants lunged forward during both episodes. On XXX, the drive from [XXX] to the Ukiah Costco was normal. On the return toward [XXX], FSD suddenly braked hard at approximately 63 mph and reduced the vehicle's speed by about 25 mph, to approximately 38 mph. Family members and friends in the vehicle were startled and moved forward. Later that day, there were two additional unexpected braking episodes while traveling from XXX toward XXX. I used accelerator input to override the unwanted braking. The unexpected highway-speed deceleration created a risk of being struck from behind and made the system unpredictable to supervise. No crash, fire, injury, or property damage occurred. I do not recall a warning message before the braking. The vehicle has not been inspected or diagnosed for this issue and is available for inspection upon request. As of XXX, the vehicle reports Tesla software 2026.20.3 and FSD (Supervised) v12.6.4; it has Hardware 3. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

    NHTSA complaint 11751194
18. Filed Jul 9, 2026Failure Jul 9, 2026Santa Ynez, CAElectrical system

    The center touchscreen/camera display system in my 2021 Tesla Model 3 is malfunctioning. The vehicle’s camera views do not work properly on the center display, including camera visibility needed for reversing and safe operation. The failed system is available for inspection upon request. This creates a safety risk because the vehicle relies heavily on the center screen to display camera views and vehicle information. When the camera display does not work properly, rear and surrounding visibility is reduced, especially while reversing, parking, changing lanes, or maneuvering around pedestrians, vehicles, curbs, and other obstacles. Tesla has refused to repair or cover the repair. The problem has been reported to Tesla. Tesla has not provided a satisfactory safety-related repair solution. It is unknown whether Tesla has fully inspected the failed component or confirmed the exact cause. There were no known warning lamps before the failure. The symptom is that the camera display/center screen camera views do not function properly when needed. The issue appears to involve the center display, camera display system, camera hardware, wiring/harness, vehicle computer, or related software. The exact cause is unknown. I am reporting this as a potential safety defect involving loss or malfunction of the camera display system in a 2021 Tesla Model 3.

    NHTSA complaint 11749349
19. Filed Jul 8, 2026Failure May 1, 202638,200 milesTampa, FLElectrical system

    The contact owns a 2022 Tesla Model 3. The contact stated that while operating the vehicle, abnormal crackling and bubbling sounds were heard coming from underneath the rear seat. While driving later, an electrical arcing sound emanated from the same area. While at a local charging station, the contact discovered that the battery failed to charge when connected to a high-voltage charger; however, the battery could still be charged at the contact's residence using a 110-volt charger. The vehicle was driven to a local dealer, who was unable to identify the problem, and no service was performed. The vehicle was driven back to the charging station, but the high-voltage charging failure persisted. The vehicle was then towed to a local service center, where it was diagnosed and it was determined that the high-voltage battery required replacement. The high-voltage battery was replaced, and the vehicle was repaired. The manufacturer was notified of the failure. The failure mileage was 38,200.

    NHTSA complaint 11749005
20. Filed Jun 29, 2026Failure Jun 25, 2026katy, TXSteering, Body, Vehicle speed controlCrash1 injured

    My wife had a collission on June 25th at 2 30PM CST while she was parking her vehicle in her office parking spot. The car suddenty sped and hit a tree. We suspect it be a misfire in Tesla.

    NHTSA complaint 11747194