2019 Toyota Corolla

203 complaints on file, page 1 of 11.

1. Filed Sep 24, 2026Failure Sep 22, 2026104,000 milesCottonwood, CAClutch assembly

   The contact owns a 2019 Toyota Corolla. The contact stated that while driving at an undisclosed speed, the clutch was depressed; however, the clutch system failed to operate as intended. The contact stated that the clutch was stuck to the floorboard. The contact stated that due to the failure, there was an excessive amount of clutch fluid leaking onto the ground. The vehicle was towed to the residence. The contact stated that the failure was a known failure. The manufacturer was contacted by phone and a case was filed. The failure mileage was approximately 104,000.

   NHTSA complaint 11766729
2. Filed Sep 16, 2026Failure Sep 16, 2026Bella Vista, ARPower train

   Component that failed was the CSC Concentric Slave Cylinder. I went to press the clutch and it stuck to the floor. I checked for leaks in the cabin beneath the clutch and it was dry. I then proceeded to check the reservoir and saw that it needed fluid. I managed to get it to a nearby convenience center to purchase and fill the reservoir when that did not work I called a tow truck to move it to an auto repair shop. This put others at risk, should the clutch have remained in neutral I would have, and or all the break fluid would have leaked and i would have been without brakes since the clutch and break share a reservoir. This issue could have caused serious life threatening injuries not only to myself but others had there been an accident. Thankfully this took place at 4 am before other drives were out and about for the morning commute. The component has since been looked at by an independent service center. There were no warning lamps or messages prior to the issue. the vehicle currently has roughlty 84,000 miles.

   NHTSA complaint 11764719
3. Filed Sep 10, 2026Failure Sep 3, 2026Shelton, WAPower train

   Slave cylinder on clutch failed and leaked fluid in to clutch and flywheel. Clutch pedal would not rebound after being pressed in to shift gear, stuck in middle of road trying to get vehicle in first gear. Had vehicle towed to dealership, estimate of $5800 to repair. Apparently this is a known problem with this manual transmission, many others have experienced similar failure at around 60,000 miles.

   NHTSA complaint 11763432
4. Filed Aug 4, 2026Failure Apr 4, 202346,091 milesArlington, TXSpeedometer/odometer

   Odometer Fraud. The contact purchased a 2019 Toyota Corolla. The contact stated that while attempting to register the vehicle, it was discovered that there was a mileage discrepancy. The vehicle was a dealer sale. At the time of purchase, the vehicle mileage was 45,709, and at the time of registration, it was discovered that the mileage listed on the title was 46,091. Additionally, the contact later became aware that the vehicle was a salvaged vehicle. The seller was contacted several times but blocked all communications.

   NHTSA complaint 11754726
5. Filed Jun 17, 2026Failure Jun 17, 202675,000 milesSanta Ana, CAElectrical system, Pressure monitoring and regulating systems

   The contact owns a 2019 Toyota Corolla. The contact stated that while driving at an undisclosed speed, the low tire pressure warning light illuminated, with several other unknown warning lights illuminated. The vehicle was taken to an independent mechanic to be diagnosed. However, the independent mechanic stated that the tire pressures were not low, and that the cause of the failure was not determined. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 75,000.

   NHTSA complaint 11744710
6. Filed May 4, 2026Failure Mar 20, 2026Deland, FLAir bagsCrash

   I was driving on a two lane state road. Two vehicles we traveling in front of me in the left lane. The further vehicle in left decide to make a sudden stop at a traffic light. The silver sedan behind that vehicle was traveling too close to react appropriately. The sedan avoid the vehicle in front of it and impeded into my lane and collide with my vehicle. My airbags in my 2019 Corolla failed to deploy.

   NHTSA complaint 11735650
7. Filed Apr 11, 2026Failure Mar 27, 2026Warrensburg, MOPower train

   Premature slave cylinder failure at ~70k miles. Suddenly started leaking brake fluid profusely. Inspected and confirmed by Toyota dealership. No symptoms prior to failure. Clutch stopped functioning, unable to shift while driving. Pulled over to inspect and all of the brake fluid had leaked out. Refilled brake fluid and bled system, reservoir leaked to minimum fill line within 24 hours.

   NHTSA complaint 11730580
8. Filed Apr 7, 2026Failure Apr 6, 2026Beaver Falls, PAPower train

   DESCRIPTION OF SAFETY ISSUE: The Concentric Slave Cylinder (CSC) on my 2019 Toyota Corolla Hatchback 6-speed manual failed during normal driving at around 60mph, creating an immediate and uncontrolled safety hazard. The clutch pedal depressed fully to the floor while I was shifting from 5th gear to 6th gear and the vehicle became unable to be shifted out of gear, leaving me unable to properly control vehicle speed or movement. The only way to release the transmission was to physically reach down and lift the clutch pedal up with my foot while attempting to drive. CRITICAL SAFETY CONCERN - SHARED BRAKE AND CLUTCH FLUID RESERVOIR: On this vehicle, the brake fluid reservoir and clutch hydraulic system share a single reservoir. When the CSC fails and leaks fluid, brake fluid is consumed directly from the same reservoir that supplies the braking system. A CSC failure does not only result in loss of clutch function — it results in loss of brake fluid, and with sufficient fluid loss, partial or complete brake failure. This is not a theoretical risk. This vehicle can fail in a way that simultaneously removes the driver's ability to control vehicle speed via the transmission AND reduces or eliminates braking capability — both at the same time, without warning I am requesting that NHTSA investigate this as a safety defect and consider whether a recall or service campaign is warranted given the risk of simultaneous clutch and brake failure on these vehicles.

   NHTSA complaint 11729790
9. Filed Apr 2, 2026Failure Mar 18, 2026Jersey City, NJPower train

   6 speed manual transmission. 79K miles. Vehicle was checked at a dealer due to a sluggish clutch. Dealer found low brake fluid, but no problems with the clutch. The next day the clutch failed completely and car had to be towed off the highway. Slave cylinder for the clutch is a design flaw on these vehicles.

   NHTSA complaint 11728777
10. Filed Mar 28, 2026Failure Mar 22, 2026Bethel Park, PAPower train

    Clutch release bearing/slave cylinder failed at 29,900 miles. Without warning or unusual symptoms, clutch pedal stuck to floor and was unable to shift gears without manually pulling clutch pedal up.

    NHTSA complaint 11727668
11. Filed Mar 27, 2026Failure Mar 20, 2026brush prairie, WAPower train

    The clutch slave cylinder in my 2019 Toyota Corolla Hatchback failed, causing brake fluid to leak out. The leaking fluid contaminated the clutch assembly, resulting in both the slave cylinder and clutch needing replacement. The failed components should be available for inspection from the repair facility upon request. The failure led to a loss of proper clutch operation, which made it difficult to shift gears and control the vehicle. This created a risk of stalling in traffic or being unable to accelerate when needed, increasing the potential for a collision, especially in busy or high-speed driving conditions. Yes, the issue was diagnosed and confirmed by the dealership. They identified the failed slave cylinder and verified that brake fluid leakage caused contamination of the clutch, requiring replacement of both components. The vehicle has been inspected by a service technician/mechanic at the Toyota dealership. Prior to the failure, there were no warning lights or dashboard messages indicating a problem. The issue appeared suddenly when the clutch began to malfunction due to the fluid leak causing me to not be able to shift gears and the clutch pedal not returning.

    NHTSA complaint 11727599
12. Filed Mar 13, 2026Failure Sep 10, 2025Newbury, VTEngine, Fuel/propulsion system, Unknown or other

    Error message that said 'drive start control malfunction. Took 6 mos and numerous attempts to resolve. Replaced numerous parts including the fuel pump because the plastic it's made out of was just disintegrating and and cracking. This has cost thousands of dollars in parts and labor. Also getting a msg on info screen 'connected device not supported' now. Apparently toyota did an update and there was a bug in the program yet I have to pay to fix their error to the dcm.

    NHTSA complaint 11724036
13. Filed Mar 9, 2026Failure Mar 7, 2026Rancho Cucamonga, CAPower train

    2019 Toyota Corolla hatchback. Complete transmission failure.

    NHTSA complaint 11722973
14. Filed Feb 27, 2026Failure Aug 13, 2025bullsgap, TNEngine, Unknown or other

    The slave cylinder failed l3aving me stranded in a parking lot. Luckily I wasnt driving down the highway as the slave cylinder is also part of the brake system they use the shared brake fluid reservoir. This is a very common problem and is a 4k plus cost to fix. Not including the time that has to go into fighting the warranty companies and dealers.

    NHTSA complaint 11721047
15. Filed Jan 29, 2026Failure Dec 15, 20251,488 milesLynn, MASteering

    The contact owns a 2019 Toyota Corolla. The contact stated that while driving at various speeds, the steering wheel became difficult to turn in either direction. The hazard, power steering, and LDA warning lights were illuminated. The message "Lane Departure Alert Malfunction - Visit your Dealer" was displayed. The contact stated that when the LDA was deactivated, a red power steering warning light was intermittently illuminated. The vehicle was taken to a local dealer, where a battery replacement was performed. The vehicle was repaired; however, the failure reoccurred. The vehicle was taken back to the same local dealer; however, the vehicle was not diagnosed or repaired due to the cost. The vehicle was towed to a local independent mechanic, where it remained for further investigation. The manufacturer was not made aware of the failure. The failure mileage was approximately 1,488.

    NHTSA complaint 11714135
16. Filed Jan 2, 2026Failure Dec 16, 2025Palm Springs, FLElectrical system, Seat belts, SeatsFire

    While the vehicle was parked and powered off, a fire originated inside the driver seat area. There was no collision, no aftermarket electrical equipment installed, and no heated seat or accessory usage at the time of the incident. The vehicle was stationary when the fire began. The fire damage was concentrated within the driver seat assembly, consistent with a suspected electrical failure involving seat wiring, seat-mounted components, or associated harnesses. This is not consistent with owner misuse or external ignition sources. The insurer (Allstate Insurance Company) declared the vehicle a total loss but declined further fire-origin or electrical defect investigation. The vehicle is at risk of being sold or dismantled through a salvage auction, which would destroy critical evidence related to a potential manufacturer defect. The vehicle is currently listed on Copart (Lot# 99091095 highlighted as ‘Run and Drive’) I have completed a Power of Attorney (HSMV 82053) per Allstate requirement, along with a limited conditions notification for evidence preservation however Allstate is refusing to accept the conditions stating their intent to sell it as salvage. This incident presents a serious safety concern involving spontaneous ignition within the passenger compartment. Similar failures pose a risk of injury, death, or property damage, particularly if ignition occurs while occupied. I am requesting that NHTSA review this incident for potential electrical system or seat assembly defects and preserve this complaint as part of any pattern or trend analysis involving Toyota vehicles.

    NHTSA complaint 11708439
17. Filed Dec 27, 2025Failure Dec 19, 2025Dallas, TXPower train

    Clutch stopped working while driving. Car has 61,000 miles.

    NHTSA complaint 11707251
18. Filed Nov 25, 2025Failure Dec 19, 2024Rio Rancho, NMPower train, Unknown or other

    My 2019 hatchback clutch failed Clutch Release Bearing and Slave Cylinder Assembly is leaking. Toyota part # 31400-19027

    NHTSA complaint 11701613
19. Filed Nov 20, 2025Failure Sep 1, 2025Akron, OHPower train

    rattle in transmission. Car hesitates to accelerate randomly leading to unpredictable acceleration sometimes. Transmission is failing.

    NHTSA complaint 11700673
20. Filed Nov 10, 2025Failure Nov 1, 2025Elmwood Park, ILPower train

    All 2019-2022 Toyota Corolla 6 Speed Manual Transmission cars are affected. The slave cylinder is a defective part that fails prematurely anywhere between the 20,000-70,000 mile range. The slave cylinder on this car is made out of plastic and is located inside of the transmission, when the slave cylinder fails, it leaks brake fluid all over causing the car to lock into gear and not be able to shift which is a major safety risk when there is no signs of failure. My car locked up in the middle of a busy highway and had to be pushed off the side of the road. Not only is this a safety risk, but since the part is located inside of the transmission, which is not normal, it leaks brake fluid all over the clutch and flywheel, which will all need replacement. The dealership quotes between 4-5 thousand dollars to repair, and is not covered under warranty. Toyota knows that this part is a defective part because the new models received an updated slave cylinder made out of metal, rather than plastic, but no cars have been recalled. The car was towed to my local dealership and it is currently being worked on. The incident was reported to Toyota Corporate and a case was opened to investigate this issue. Every single model made between those years are effected and has caused thousands of people to be left with an expensive repair that is unavoidable.

    NHTSA complaint 11698600