2020 Toyota Corolla

306 complaints on file, page 1 of 16.

1. Filed Sep 18, 2026Failure Sep 18, 2026Aiken, SCPower train, Service brakes

   The concentric slave cylinder in my vehicle is a big issue with these cars. There has been so many reports of issues happening with these cars manual transmission Corolla's. This can cause fluid to spew, brakes to stop working, and no longer able to drive the vehicle safely. This part should be recalled and covered by Toyota.

   NHTSA complaint 11765259
2. Filed Sep 15, 2026Failure Jun 2, 2026West Columbia, SCPower train

   The CV joint, there is a clicking sound when sharp turns are make to include U-turns. Spoke with a mechanic and was instructed to reach out to the dealership and check for recall on it. I did see any but I see a Technical Service Bulletin ( TSB-0106-20) for 2015- 2021 Corolla models regarding a potential clinking noise during sharp turns and u turns. This may have started three months ago. It is more noticeable now that I am driving more.

   NHTSA complaint 11764378
3. Filed Aug 6, 2026Failure Aug 6, 2026Temecula, CAElectrical system

   DESIGN FLAW & SAFETY RISK: Toyota critically mismatched the standard battery to the vehicle's electrical charging profile; an AGM battery should be specified from the factory. Engine programming drops alternator voltage during cruising, deeply discharging the battery, and forces high-voltage surges (15V+) into it during deceleration. Because standard batteries cannot handle these rapid recharge loads during deceleration, the internal thermal load routinely overheats and boils the liquid electrolyte, even when brand new. This continuous boiling vents volatile hydrogen gas and discharges corrosive battery acid inside the engine bay. This structural flaw culminated in an immediate safety hazard when the battery physically exploded under the hood, creating a severe risk of engine compartment fire, chemical acid burns, and complete vehicle electrical blackout in active traffic. COLLATERAL DAMAGE & HISTORY: The chronic discharge and boiling of highly corrosive battery electrolyte severely damaged and corroded surrounding critical vehicle components. The acid completely corroded the transmission mount, the metal battery holder restraint, and the body paint. Furthermore, the corrosive boil-over burned off and destroyed several electrical connectors, plastic shrouds, plumbing hoses, and sections of the primary engine wiring cable harness. Since owning this 2020 Toyota Corolla, the vehicle has suffered systematic electrical degradation, requiring a full battery replacement at least once every single year. The exploded battery could not be safely retained due to its hazardous, ruptured state. WARNINGS & INSPECTIONS: No dashboard warning lamps, battery alerts, or diagnostic codes were triggered on the display prior to the physical battery failure. The rupture and electrical blackout occurred instantaneously. The vehicle has not been inspected by police or insurance representatives as no crash resulted directly from the blast.

   NHTSA complaint 11755366
4. Filed Aug 6, 2026Failure Aug 6, 2026Temecula, CAPower train

   FAILED COMPONENT & AVAILABILITY: The manual transmission Concentric Slave Cylinder (CSC) failed internally. Due to caustic hydraulic fluid contamination and severe system pressure loss, I had to replace the internal CSC unit, the clutch disc, the pressure plate, the flywheel, the master clutch cylinder, and the hydraulic clutch lines. The failed components have been retained and are available for inspection upon request. SAFETY RISK: The plastic housing of the OEM slave cylinder cracked internally, spraying caustic hydraulic brake fluid inside the transmission bell housing and completely coating the flywheel, pressure plate, and clutch friction disc. This caused an immediate, sudden loss of hydraulic pressure, forcing the clutch pedal to drop and stick flat to the floorboard. This put my safety and the safety of others at extreme risk, as it suddenly prevented me from disengaging the clutch, shifting gears, or safely dropping the vehicle into neutral while driving in active traffic.CONFIRMATION & REPAIR: A certified Toyota dealership diagnosed the issue and issued an unaffordable repair estimate of $4,800 to fix this recurring manufacturer defect. Because of this extreme cost, I was forced to drop the transmission and perform the entire rebuild myself. The total out-of-pocket cost just for replacement parts was $3,200. The vehicle has not been inspected by police or insurance representatives as no crash resulted. WARNINGS & MILEAGE SYMPTOMS: There were no prior dashboard warning lamps, error messages, or clear physical indicators before either failure occurred. The loss of clutch pedal pressure happened instantaneously. This vehicle has suffered this catastrophic internal failure twice: the original factory-installed unit (part number 31400-19025) failed prematurely at 59,000 miles. The updated replacement part (superseded part number 31400-19027), which suffers from the exact same defective plastic composition, failed again just 40,000 miles later.

   NHTSA complaint 11755364
5. Filed Aug 6, 2026Failure Jul 31, 2026Vallejo, CAEngine

   Part is the coolant bypass valve. Toyota has been taken to court but dealership claims now that I’m over 100k miles I can’t do it. There was also a second part about 10 years but I wasn’t clear on the details of the outcome. Toyota has acknowledged this issue in court but failed to do so at the customer level in my case. engine light came on at 97k and now I’m at 104k which is over that 100k mark. Issue is I’ve only take my car to Toyota for repairs. They have known about this but failed to repair or notify me of it. I would have immediately brought my car in at 97k if. I had known. This puts not only me but my 3 kids and entire family at risk every time i drive. This is known to the dealership and they been taken to court for failures to notify customers of this known defect. It’s been inspected by Toyota the last time I took it in about a week ago at 104k miles.

   NHTSA complaint 11755244
6. Filed Jul 31, 2026Failure Jul 30, 2026Doylestown, PAPower train

   Design issue: The 12th-generation (E210) Corolla manual transmission utilizes a CSC unit containing plastic/ABS components that owners and forum communities frequently cite as a weak point prone to premature leakage and mechanical failure. This occured to my corolla on a roadway and presented a severe safety hazard.

   NHTSA complaint 11754045
7. Filed Jun 29, 2026Failure May 29, 202690,330 milesDecatur, GAClutch assembly

   The contact owns a 2020 Toyota Corolla. The contact stated that while driving at an undisclosed speed, the clutch failed to operate as intended. The contact stated that the clutch seized, and the RPM increased. No warning lights were illuminated. The vehicle was taken to the dealer; however, the failure was not duplicated. The contact stated that the failure reoccurred. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 90,330.

   NHTSA complaint 11747193
8. Filed Jun 7, 2026Failure Jun 6, 2026Tujunga, CAEngine

   A message came on the screen saying “engine maintenance required” and it’s not going away. Upon doing a google search, there is a common failure in the cooling system for these cars reported by a lot of owners.

   NHTSA complaint 11742614
9. Filed May 21, 2026Failure May 20, 2026132,483 milesOakland, CASpeedometer/odometer

   The contact purchased a 2020 Toyota Corolla. The contact stated that they discovered a mileage discrepancy after the purchase. The vehicle was a private sale on Facebook market. At the time of purchase, the vehicle mileage was 52,000. It was later discovered that the vehicle’s title mileage was 132,000. The contact stated went the DMV, and he discovered the mileage 132,483.

   NHTSA complaint 11739330
10. Filed May 20, 2026Failure May 19, 2026Herndon, VAUnknown or other

    Replace Heater Control Valve - Diagnostic code P2681 indicates an internal electrical failure within the heater control valve assembly, a condition commonly seen on Toyota vehicles. Testing showed the electrical portion of the valve is open and no longer maintaining proper circuit continuity, requiring replacement of the heater control valve assembly.

    NHTSA complaint 11739095
11. Filed May 13, 2026Failure May 3, 2026West New York Nj, NJPower train

    "On 04/09/26, I took my vehicle for regular maintenance and an oil change; no potential issues were reported. I operated the vehicle in good faith, trusting its safety. However, on Sunday, 05/03/2026, while driving at highway speeds, the clutch pedal failed and [stuck to the floor / slipped severely]. This caused an immediate loss of power to the wheels in high-speed traffic, creating a life-threatening situation and a high risk of a rear-end collision. No warning lights appeared prior to this failure."

    NHTSA complaint 11737720
12. Filed May 6, 2026Failure May 6, 2026Woodbridge, VAVisibility/wiper

    Windshield Wiper Intermittent setting stopped working, and wipers no long return to their home position. This appears to be a common issue with Toyota. When driving in the rain, the wipers will freeze in the up setting, which is very dangerous for it to occur during heavy rain on the highway causing visibility issues. No warnings of any kind given, the wiper switch appears to just go bad, or wear out over time.

    NHTSA complaint 11736152
13. Filed Apr 24, 2026Failure Apr 1, 202659,000 milesEaston, PAEngine, Fuel system, Gasoline

    The contact owns a 2020 Toyota Corolla. The contact stated that while at a red light, the vehicle shut off with the check engine and several other unknown warning lights illuminated. The vehicle restarted after several attempts. The vehicle was taken to an independent mechanic and the failure was duplicated. The mechanic retrieved DTC: P1603; "Engine Stall History" (ECM recording an unexpected engine shutdown or a communication error with the Transmission Control Module (TCM). The mechanic associated the failure with NHTSA Campaign Number: 20V682000 (Fuel System, Gasoline) and referred the contact to the dealer for assistance. Several dealers were contacted, and the contact was informed that the VIN was not included in the recall. The manufacturer was not notified of the failure. The vehicle was not repaired. The failure mileage was approximately 59,000.

    NHTSA complaint 11733489
14. Filed Apr 11, 2026Failure Mar 16, 2026Henderson, TNUnknown or other

    Coolant water control valve short circuit. Causes dealer message that won't clear and dealer wants $600 to replace a $30 part. Part is extremely difficult to get to and should not be a wear item.

    NHTSA complaint 11730593
15. Filed Apr 8, 2026Failure Apr 7, 2026Harvest, ALEngine, Unknown or other

    Car shows the below message when A/C is turned on: Engine Maintenance Required Visit Your Dealer

    NHTSA complaint 11729914
16. Filed Mar 15, 2026Failure Mar 18, 2021Bellville, TXUnknown or other

    Message on dashboard that says, "Engine Maintenance Required. Visit Dealer." This message came on at around 31,000 miles and I was told it was three different things all different prices at my dealer. So, I looked into it and found out it was the Coolant Bypass Valve, and asked the dealership about it and they said 700 dollars to replace. I did not want to pay that much especially since I saw online others were having the same problem. Message still pops up to this day when I turn on my A/C. Car now has around 205,000 miles on it and is six years old.

    NHTSA complaint 11724474
17. Filed Feb 26, 2026Failure Nov 1, 2025Tampa, FLVisibility/wiper

    The wipers are turning on randomly by themselves, even when the control switch is set to the “off” position. This has occurred multiple times and happens without any input or activation from me. The issue appears to be intermittent but persistent, and it raises concerns about a potential electrical or control system malfunction.

    NHTSA complaint 11720827
18. Filed Feb 23, 2026Failure Jan 5, 2026Minneapolis, MNService brakes

    I am having a problem with my 2020 Toyota Corolla's brakes. I live in [XXX] . In the winter when the car is cold the brakes work normally. When the car has been driven for a while, the car has warmed up, and the brake fluid has thinned, the brakes behave abnormally. When I stop at a red light, after 20 to 40 seconds, the brake pedal slowly drops towards the floor. My understanding is that this could indicate a problem with the master brake cylinder. My fear is that there could be a sudden failure of the cylinder causing an accident. I brought the car to Rudy Luther Toyota in Golden Valley. When I brought the car in, it was warm and the brakes were malfunctioning. Unfortunately, they let the car sit for several hours, the brake fluid cooled, and the mechanic was unable to duplicate the problem. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

    NHTSA complaint 11719920
19. Filed Feb 23, 2026Failure Feb 22, 2026San Jose, CAPower train

    The clutch slave cylinder failed at 48,000 miles. On the freeway, I had difficulty shifting into gear and I had cars passing me at high speeds, putting my life and others' lives at risk. This part defect is due to the plastic clutch slave cylinder failing. This common issue is well-documented by numerous other owners, with the part failing before the routine clutch maintenance cycle. My car was inspected by an independent mechanic, who said the lack of clutch pressure is due to the clutch slave cylinder failing. The worst part is that there were no warning lamps or messages before this happened. Toyota is claiming there is no recalls for this part, whic his astounding because the clutch is essential for the 6speed transmission.

    NHTSA complaint 11719864
20. Filed Jan 30, 2026Failure Jul 1, 2025Mobile, ALElectrical system, Unknown or other, Visibility/wiper

    when I use blinker windshield wipers turn on and sometimes when I call or somebody calls my cell phone I can hear them, but they cannot hear me. does not happen all the time, but I was concerned since there was a recall on certain toyota corolla that says a short circuit may develop in the OCS sensor, preventing front passenger air bag from deploying and my son who is a mechanic said both of these could be a problem with the wiring in the column and I thought it may be connected to the same recall as the air bags? the wipers coming on is happening more often these days and that is why I mentioned it to my son who is a mechanic. he will not touch it since it is still under my extended protection but he is concerned about it getting worse since the blinker is attached to the column. as far as using not being heard by callers or when I call I am concerned if I need to call in an emergency the ones I call cannot hear me. as far as when this started I do not remember but I know it's been at least 6 months if not longer, it just seems to be doing it more often lately

    NHTSA complaint 11714511