2020 Toyota RAV4

635 complaints on file, page 1 of 32.

1. Filed Sep 25, 2026Failure May 18, 2026Beverly, WVSuspension, Unknown or other

   Its the sway bar stabilizer bar in the front end of my 2020 rav4 i bought it brand new in 2020. After just 24k miles i had to replace the sway bar now just a few months later ima gonna have to get it back in the shop because its making the same noise as before

   NHTSA complaint 11766886
2. Filed Sep 14, 2026Failure Aug 19, 2026Tucson, AZFuel/propulsion system

   While driving on the highway, the vehicle suffered a sudden loss of engine power and went into a low-power/vapor lock state due to severe fuel starvation. This created a major safety hazard by stranding the vehicle on the highway shoulder and exposing occupants to high-speed traffic. Prior to the power loss, there were no advance warning lights until the engine stalled. A diagnostic scan performed immediately following the incident confirmed code P0087 (Fuel Rail/System Pressure - Too Low), along with cylinder misfire codes P030027 and P030100. To allow the vehicle to safely limp home from a remote location, an independent technician cleared the diagnostic trouble codes. An independent scan tool report clearly documented and confirmed the low fuel pressure fault prior to code clearance. The dealership subsequently declined to perform a warranty or recall fuel pump replacement citing the absence of active codes upon arrival, despite receiving the timestamped diagnostic report of the failure. The component has not been inspected by the manufacturer beyond the dealership's initial turn-away, but the vehicle and diagnostic documentation remain available for inspection upon request.

   NHTSA complaint 11764071
3. Filed Sep 7, 2026Failure Jun 1, 2023Lebanon, ILHinge and attachments

   cracking, bending, and failing liftgate hinges and struts.

   NHTSA complaint 11762621
4. Filed Sep 4, 2026Failure Aug 31, 2026Lexington, KYPower train

   During summer 2026 i began to notice a noise/whine above 30mph that would only occur when foot is on accelerator. my vehicle has 83k miles on it (me being only owner with routine maintenance). as a responsible owner, i had my dealer do an inspection. after a drive and a listen, they claimed it was a transmission bearing failure and only solution is a $11k transmission replacement, with the commentary "we had a camry in last week with same issue". Being responsible owner, i got a second opinion from an independent shop who also verified "transmission bearing failure, you will need a new transmission. currently the part is on backorder because so many are needing to be replaced and no one should do a replacement with a used transmission". This is not the quality i expected out of toyota -- transmissions should not be needing to be replaced at 83k miles.

   NHTSA complaint 11762165
5. Filed Sep 4, 2026Failure Sep 4, 2026Oak Ridge, TNHinge and attachments

   The rear liftgate is no longer aligned and does not sit evenly when closed. After noticing the uneven fit, I inspected the liftgate hinges and found that both metal hinge brackets appear to be cracking and splitting at their mounting points. There were no warning lights or messages before the problem appeared. I am concerned that the hinges could fail completely, causing the liftgate to fall unexpectedly, detach from the vehicle, or create a road hazard while driving.

   NHTSA complaint 11762068
6. Filed Aug 28, 2026Failure Aug 27, 2026Aberdeen, NCUnknown or other

   Vehicle was parked in my garage and it was 80° outside. I was standing at the door and heard an explosion. I found out that the rear glass on my RAV4 SUV exploded. Just glad the wife or kids were not standing around the vehicle. I have filed on my insurance and it will be taken care of in a few days by my insurance company.

   NHTSA complaint 11760387
7. Filed Aug 26, 2026Failure Jun 4, 2026Altoona, IAEngine

   "Engine Coolant Bypass Valve failed suddenly on highway (Code P2681-15), risking engine overheat and stall. Toyota acknowledged this defect under CSP 24TE04 but refused assistance due to vehicle having 103,660 miles (just past 100k miles). Failure causes immediate safety and overheating hazard."

   NHTSA complaint 11759760
8. Filed Aug 18, 2026Failure Aug 10, 2026Cranberry TWP, PAPower train

   **VEHICLE:** 2020 Toyota RAV4 LE **VIN:** [XXX] **CURRENT MILEAGE:** 126,776 miles **PURCHASE DATE:** October 2020 **COMPONENT:** Automatic Transmission (Power Train) **PROBLEM DESCRIPTION:** On XXX, I took my 2020 Toyota RAV4 LE to a transmission specialty shop (TJ'S Transmission Service Inc., Bedford, PA) because the automatic transmission was slipping while driving. The professional diagnosis (Invoice #XXX) confirmed the following stored fault codes: P2681, P2816, P08BA, P2713 The technician also confirmed that the transmission fluid was black and contained metal debris, indicating significant internal wear of clutch/band components. While researching these codes, I found that Toyota previously issued Technical Service Bulletin (TSB) T-SB-0160-18, titled "Transaxle Whine Noise, Harsh Shift, MIL ON, or Reduced Power," which acknowledges these SAME fault codes (P2816, P08BA, P2713, among others) as a known problem in the 8-speed automatic transmission (UA80/UB80 family, manufactured by Aisin). This TSB was officially issued only for the 2017-2018 Highlander and Sienna models, but the 2019 and later RAV4 uses the same transmission family (UB80E/UB80F) for the 2.5L engine, suggesting this is the same design or manufacturing defect that has not been officially acknowledged for this model. This issue represents a safety risk, as unexpected loss of power or transmission slippage while driving (for example, when merging onto a highway or passing) can create a dangerous situation for the driver and other vehicles on the road. I am requesting that NHTSA investigate whether a similar failure pattern exists in other 2019-2021 RAV4 vehicles equipped with this transmission, and that consideration be given to whether Toyota should extend coverage of TSB T-SB-0160-18 (or issue a specific one) to include the RAV4. No repair was performed at this time due to the high estimated cost without warranty coverage. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

   NHTSA complaint 11757837
9. Filed Jul 22, 2026Failure Jun 1, 2026Philadelphia, PALock

   Front driver side door is not locking remotely or with manual door lock button. Door lock is open when driving. And need to be locked with finger.

   NHTSA complaint 11752052
10. Filed Jul 18, 2026Failure Jul 15, 2026Parker, COUnknown or other

    I ordered a plastic underbody cover (about 12×20 inches) through Toyota Arapahoe and paid $70 for the part. I was given an appointment for installation. When I arrived, I was told that the installation would take an hour and a half, even though the work consisted of fastening nine screws, while the old cover had been factory‑attached with only five simple self‑tapping fasteners, and this work was supposed to be free. After about an hour, I found my vehicle in the general parking lot, with no notification, no status update, and no explanation from the employees. When I asked why the work had not been completed, I was told: “There is not a single screw in the station,” “The screws may arrive in a week,” “The installation will cost about $100.” I asked the manager: “You want one hundred dollars just to fasten nine screws?” At that moment, the situation escalated. A man appeared who claimed to be “the boss of the entire station.” His behavior was aggressive and unprofessional. He refused to give his name or provide a business card. Because I speak English poorly, I asked him to say his name again. I tried to say “last name,” but due to stress I mistakenly said “famaly.” Instead of offering an electronic translator, this person began acting in a disturbing and irrational manner: shouting “family, family!”, rolling his eyes, moving around the room in an agitated way, and repeating the word loudly. I was confused and repeated the word after him, not understanding what was happening. Two other employees approached and began repeating “Go, go,” pressuring me to leave. Their behavior was clearly aimed at intimidation and forcing me out of the premises. After returning home, I measured my blood pressure: 170/90, which is significantly higher than my usual level of 140/80 and is considered a pre‑heart‑attack indicator. This dangerous spike in blood pressure was a direct result of the aggressive and humiliating treatment by the employees of Toyota Arapahoe.

    NHTSA complaint 11751302
11. Filed Jul 14, 2026Failure May 1, 202625,000 milesAtlanta, GAService brakes, Hydraulic, Accelerator pedalCrash1 injured

    The contact owned a 2020 Toyota Rav4. The contact stated that while pulling into a vertical spot and making a right turn, the vehicle suddenly accelerated, jumped the curb, the sidewalk, and continued driving down the sidewalk and crashed into a building. The brake pedal was depressed but was stuck. The vehicle failed to turn off, and the parking brake failed to engage. There were no warning lights illuminated. The air bags deployed as needed. A Police report was filed. The EMS workers were unable to depress the brake pedal. The undercarriage of the dashboard ripped the skin off both shins. The contact was transported to the trauma hospital, where medical attention was provided for four weeks to close the wounds. A skin graft was performed on both legs. The vehicle was towed to a tow lot. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The vehicle was deemed a total loss by the insurance company. The black box data was retrieved, which showed the acceleration, but no information if the brake pedal was depressed. The approximate failure mileage was 25,000.

    NHTSA complaint 11750253
12. Filed Jun 23, 2026Failure Mar 1, 2025Dousman, WIElectronic lock/latch actuator

    In March 2025 the driver door lock stopped working electronically and would only work manually. In August 2025 the passenger door lock stopped working noisy of the time. In Dec 2025 the rear passenger side does lock stopped working most of the time.

    NHTSA complaint 11745836
13. Filed Jun 19, 2026Failure Jun 17, 2026chilhowie, VAService brakes

    The front brakes wear out too quickly. In the past 3 years, the front brakes and rotors have had to be replaced 5 times while the rear brakes only once. this is not normal. i have complained to the dealership but they have no answers.

    NHTSA complaint 11745179
14. Filed Jun 17, 2026Failure Jun 17, 202674,000 milesKeyser, WVSteering

    The contact owns a 2020 Toyota Rav4. The contact stated that while driving 20 MPH and making a turn, the vehicle felt like it was going to flip over. There was no warning light illuminated. The contact stated that the dealer was made aware of the failure, but the vehicle was not repaired. The manufacturer was made aware of the issue. The contact stated that the VIN was not included in NHTSA Campaign Number: 20V373000 (Steering). The contact associated the failure with the recall. The failure mileage was approximately 74,000.

    NHTSA complaint 11744881
15. Filed Jun 9, 2026Failure May 22, 202660,000 milesCockeysville, MDDoor

    The contact owns a 2020 Toyota RAV4. The contact stated that while driving at an undisclosed speed, the contact noticed that there was an unusual sound coming from the rear of the vehicle. The contact parked and inspected the vehicle. The contact stated that upon opening the rear passenger's side door, the contact noticed water leaking from the bottom of the door panel onto the ground. The contact stated about a gallon of water leaked from the rear passenger's side door panel. The vehicle was taken to the dealer, where the contact was informed that the repair was not covered under a recall. The vehicle was not repaired. The contact referenced an unknown recall; however, the VIN was not associated with the recall. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure, and a case was filed. The contact was advised to take the vehicle to the dealer for inspection. The failure mileage was approximately 60,000.

    NHTSA complaint 11743023
16. Filed May 30, 2026Failure May 26, 2026Winnetka, CAElectrical system

    If I don't drive the car for 1 to 2 weeks, the car's 12v is completely drained of power and the care needs to be jumped, otherwise, it will not start. This is consistent. I've taken this to several Toyota dealerships and they all have reported my 12v battery is healthy. However, Toyota is aware and is charging for the fix, labelled as T-SB-0089-21. The known issue is a piece of electronics in the car that continually drains power because it does not properly shut off. This should not be a paid fix. This should be a recall. When the car is jumped and the car finally starts, it reports a message saying something about some safety features not available. The car needs to be moved every 2 weeks due to mandatory city street cleaning so at least once every month the car needs to be jumped if not used the week prior.

    NHTSA complaint 11741051
17. Filed May 28, 2026Failure May 26, 2026176,009 milesParamus, NJSpeedometer/odometer

    Odometer Fraud. The contact purchased a 2020 Toyota Rav4. The contact stated that it was discovered that there was a mileage discrepancy. The vehicle was a dealer sale. At the time of purchase, the vehicle mileage was 59,475. The contact stated that while his father was driving the vehicle, the vehicle stalled several times. The contact's father was a mechanic and was able to repair the vehicle. It was later discovered that Carfax reported the vehicle mileage as 176,009.

    NHTSA complaint 11740650
18. Filed May 28, 2026Failure Jan 15, 202687,000 milesWare Shoals, SCDoor

    The contact owns a 2020 Toyota RAV4. The contact stated that while driving, the contact observed a swishing noise coming from the rear passenger door. Upon inspecting the vehicle, the contact noticed the swishing noise when moving the door. The vehicle was taken to a dealer, where it was diagnosed that water had collected in the rear passenger door and all door seals needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 87,000.

    NHTSA complaint 11740599
19. Filed May 26, 2026Failure Feb 1, 2026O Fallon, MOHinge and attachments

    Hinges on the trunk wore out abnormally fast causing the struts to fail and trunk to misalign causing further lift gate damage. Caused a roughly one inch gap in the trunk there light was visible and wind can be felt through. If not addressed the hinge will rip off and the trunk will go with it.

    NHTSA complaint 11740174
20. Filed May 23, 2026Failure May 9, 2026Lorton, VAEngine

    Coolant bypass valve leak. An known issue however dealership will not pay for repairs due to vehicle having 106000 mile. 6000 over what the bulletin 24TE04 states it will cover.

    NHTSA complaint 11739682