2017 Volvo XC90

79 complaints on file, page 1 of 4.

1. Filed Sep 23, 2026Failure Apr 2, 2026Ambler, PAElectrical system, Fuel/propulsion system, Power train

   Vehicle has exhibited lagging and stalling while driving in "Pure" (electric-only) mode since approximately April 2026, at approximately 85,000 miles, accompanied by an illuminated check engine light. This has occurred repeatedly at red lights, intersections, stop signs, and in stop-and-go traffic, creating a risk of sudden loss of propulsion in live traffic situations, including at intersections where an unexpected stall could result in a collision. The dealership (Volvo Cars of Fort Washington) has diagnosed this as originating from multiple hybrid drivetrain components over several repair visits: the High Voltage Coolant Heater (replaced per a referenced Volvo Technical Service Bulletin), the Inverter Electric Rear Axle Drive Module (IEM) — diagnostic data showed one internal transistor (phase W) reaching 135°C, a severe outlier compared to the other two phases reading approximately 25°C — the A/C refrigerant shutoff valve, and most recently the Electronic Rear Axle Drive (ERAD) transmission, where diagnostic monitoring showed the ERAD clutch slipping during test drives. Volvo's own internal case management system has classified this case as a "Repeat Repair." Despite multiple repair attempts, the underlying drivability defect (lagging/stalling) has recurred each time, including almost immediately after the vehicle was returned following the initial repair, with minimal intervening use. This pattern indicates a persistent, unresolved defect in the vehicle's hybrid drive system that presents a safety risk due to unpredictable loss of power while driving.

   NHTSA complaint 11766534
2. Filed Sep 22, 2026Failure Jul 6, 2026Glen Ellyn, ILElectrical system, Warnings, Unknown or other2 injured

   2017 Volvo XC90 manufacturing defect where panoramic sunroof drainage network fails under normal rain, pooling water directly in the floorboard channels over safety module networks and wire harnesses.Water infiltration caused a catastrophic short-circuit of the floorboard-mounted amplifier while driving. This forced the audio system to emit an un-modulated, maximum-volume electronic blast through the cabin, causing severe driver distraction and documented temporary acute acoustic trauma/ear injuries to myself and my young child.Progressive electronic oxidation from ongoing water intrusion has since caused systemic failures of critical safety electronics. This includes spontaneous, unprompted activations of the automated emergency SOS calling network and dangerous operational delays in the backup camera engaging.Dealership service personnel inspected the vehicle and explicitly warned that the water-logged electrical networks are heavily compromised and at imminent risk of a complete blackout while in motion, posing a severe threat of sudden loss of power steering, braking, and propulsion on the highway. Rain is currently actively dripping from the interior ceiling onto passenger cabin components. This platform-wide engineering flaw creates an active fire, electrical, and crash hazard.

   NHTSA complaint 11766225
3. Filed Sep 20, 2026Failure Aug 29, 2026Everett, WAUnknown or otherFire

   I was driving my 2017 Volvo XC90 T6 Inscription when a ‘coolant low’ warning appeared. I immediately pulled over and the car began to smoke. I was unaware what to do so I called my husband and he told me to pop my hood. With 1.5 minutes of pulling over I open my door to find the lack to pop the hood and someone started yelling at me to get out. I looked up and the smoke had changed from white to brown- I exited the vehicle and called 911- Within approximately 5 minutes, the vehicle became fully engulfed in flames and was a total loss. The vehicle had been regularly maintained and to my knowledge, had no open recalls applicable at the time. After the fire, I became aware of a prior XC90 recall involving a coolant hose leak and fire risk. I understand that recall may not list my exact model year. I’m not claiming a specific cause, but due to the coolant warning preceding the fire, believe the circumstances warrant investigation. I was able to exit safely and no one was injured, but given how rapidly the fire developed, I’m concerned about the potential risk to others.

   NHTSA complaint 11765624
4. Filed Sep 1, 2026Failure Aug 22, 2026Charlotte, NCFuel/propulsion system, Power train, Vehicle speed control

   2017 Volvo XC90 T8 plug-in hybrid, approximately 81,000 miles, experienced intermittent hesitation/loss of propulsion when accelerating. When acceleration is requested, the vehicle can hesitate before power is delivered, creating a serious safety concern when entering, merging into, or crossing traffic because expected acceleration is not immediately available. Diagnostic testing identified faults in the IEM/ERAD system, including P286D00, Clutch A Engagement Time Performance/Too Slow, and P0A1B62, Drive Motor A Control Module, Algorithm Based Failure. The vehicle is currently being evaluated by an authorized Volvo dealer. I was advised that the high-voltage battery cells appear to be functioning properly and that the dealer is consulting Volvo technical support regarding the loss-of-acceleration condition. Volvo has issued Technical Journal guidance addressing ERAD clutch DTCs, including P286D00, on this generation of XC90. I am concerned that delayed or failed engagement of the ERAD clutch can cause an unexpected delay or loss of propulsion during acceleration. I am also aware of another NHTSA complaint involving a 2017 Volvo XC90 ERAD clutch failure, NHTSA Complaint No. 11673211, describing a delay in propulsion followed by sudden power delivery. I am requesting that NHTSA review this condition as a potential safety defect involving ERAD clutch engagement and intermittent loss or delay of propulsion in Volvo XC90 T8 vehicles.

   NHTSA complaint 11761290
5. Filed Aug 10, 2026Failure Aug 3, 202694,000 milesChandler, TXElectrical system

   The contact owns a 2017 Volvo XC90. The contact stated that while driving at an undisclosed speed, the window power switch was enabled; however, the window switch failed to function as intended. The contact stated that the rear-view camera, the door switch, and the air conditioner failed to function as intended. In addition, the contact became aware of water on the front passenger’s side floorboard. The vehicle was taken to the dealer. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The contact referenced an unknown recall; however, the VIN was not associated with a recall related to the failure. The manufacturer was not made aware of the failure. The failure mileage was approximately 94,000.

   NHTSA complaint 11756005
6. Filed Jul 11, 2026Failure Jul 4, 2026Desert Hot Springs, CAEngine, Fuel/propulsion system, Vehicle speed control

   Spark plugs, fuel injectors, cylinders and cylinder walls, pistons, oxygen sensor. Our safety was put at risk because the vehicles "reduced performance" was triggered and it affected the acceleration of the vehicle. The Volvo dealership was able to reproduce the issue because of the engine misfires.The only alert we received was the day prior our engine needed a liter of oil. We topped off the oil and that alert went away. The day we had the reduced performance we were alerted of that at the time on the highway. It's a little turtle icon. We were not able to accelerate efficiently and it was definitely unsafe to be driving but we had to get home.

   NHTSA complaint 11749713
7. Filed Jun 4, 2026Failure Jun 2, 202685,000 milesAlexandria, VAService brakes, Hydraulic

   The contact's daughter owns a 2017 Volvo XC90. The contact stated that while her son-in-law was driving at an undisclosed speed, the brake pedal was firmly depressed, but the vehicle failed to stop immediately. No warning light was illuminated. The vehicle was towed to the dealer, who determined that the vacuum hose had detached and needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 85,000.

   NHTSA complaint 11742110
8. Filed Apr 27, 2026Failure Apr 19, 2026Galena, OHElectrical system, EngineFire

   To whom it may concern. Our 2017 XC90 unexpectedly, spantaneously, and catastrophically caught fire under the hood and was a total loss 5 minutes after parking it on April 19, 2026. There were no leaks or other signs of mechanical issues. The vehicle had all regular maintenance completed at the Byers Volvo Service Department in Columbus, OH. It had no open recalls. It was always parked overnight in a garage. The Fire Inspector noted a possible vehicle manufacturing defect as the cause of the fire, however the vehicle was too heavily damaged to be definitive. We do have video of the entire incident as the Volvo was parked on Federal Government Property at the time. We are happy to share any and all information if this helps future vehicles to be safer. It should be noted that there is an active recall for the 2016 XC90 for a coolant hose leak that can cause a fire. Given that the 2017 XC90 is of the same design. Upon checking the internet and Reddit, it appears that our situation is not unique and there are other instances and reports of similar fires.

   NHTSA complaint 11734076
9. Filed Apr 6, 2026Failure Mar 16, 2026Little Ferry, NJCamera

   VCM and Rearview camera glitching not working, can cause crashes. Everything was checked for voltage and works properly. It seems like it is a system infotainment issue for 2017 Volvo xc90

   NHTSA complaint 11729350
10. Filed Apr 2, 2026Failure Mar 18, 2026Lenoir City, TNElectrical system

    The rear door on the driver side will not open. The child lock will not deactivate. No accident. I took my son to school and when I returned to open the door for my [XXX] old the door would not open. No warnings. A regular maintenance appeared days later. I do not understand why this is not being recalled based on online research showing the same thing happening with other Volvos. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

    NHTSA complaint 11728812
11. Filed Mar 31, 2026Failure Mar 10, 2026Little Ferry, NJUnknown or other

    ON CALL SERVICE/ VCM MODULE STOPPED WORKING PREVIOUS RECALLS ON THESE TYPES OF VEHICLES

    NHTSA complaint 11728383
12. Filed Mar 31, 2026Failure Mar 31, 2025130,000 milesCle Elum, WALatch

    The contact owns a 2017 Volvo XC90. The contact stated that while driving 70 MPH, the rear passenger’s side door suddenly unlocked and opened. The vehicle was pulled over to the side of the road, and the door was forcefully closed. The failure had occurred more than once while diving at various speeds. There were no warning lights illuminated. The contact stated that the failure had occurred while there was a passenger seated in the rear passenger’s side seat. The door was only securely closed by force. The vehicle was taken to the dealer, but the dealer had not inspected or diagnosed the vehicle. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 130,000.

    NHTSA complaint 11728212
13. Filed Mar 20, 2026Failure Jan 24, 2026Seaside, CAElectrical system

    The failure involves the instrument cluster (driver information display) on my 2017 Volvo XC90. This component is responsible for displaying speed, warning indicators, and all critical driving information. The failed component remains installed and is available for inspection. The issue began while driving on public roads. The display intermittently showed distorted, “barcode-like” patterns that would appear suddenly, disappear, and then return. The condition progressively worsened over time. The failure is now consistent and reproducible. When starting the vehicle, the cluster may appear normal for a few seconds before becoming severely distorted or completely unreadable. Now it is nonfunctional from the moment of ignition. This creates a significant safety hazard because I cannot view speed, warning lights, gear position, or any system alerts. The initial failures occurred while the vehicle was in motion, which increased the risk at the time of occurrence. The vehicle is not safely operable in this condition. The vehicle has approximately 24,000 miles, has never been in an accident, and has been properly maintained. There were no external factors that could explain the failure. The only prior symptoms were the intermittent display distortions described above. An authorized Volvo retailer inspected the vehicle and diagnosed the instrument cluster as failed, recommending replacement. No repair has been completed. Volvo Car USA declined goodwill assistance despite the extremely low mileage and safety‑critical nature of the failure. I am aware of similar instrument cluster failures reported by other 2016–2017 Volvo XC90 owners, suggesting this may be part of a broader pattern.

    NHTSA complaint 11725921
14. Filed Mar 20, 2026Failure Mar 10, 2026Suffolk, VAElectrical system, Exterior lighting, Visibility/wiper

    The vehicle experienced a major electrical system malfunction involving multiple critical components. The issue began with the Volvo On Call system light remaining illuminated continuously, which suggested a possible communication or battery-related fault. Shortly after, additional systems failed, including the turn signal system, windshield wipers, and high beam headlights. These components are currently non-functional and can be made available for inspection upon request. The failure significantly impacted vehicle safety. The loss of turn signals made it impossible to properly indicate lane changes or turns to other drivers, increasing the risk of collisions. The failure of the windshield wipers created a serious hazard in adverse weather conditions, reducing visibility. Additionally, the loss of high beam headlights limited nighttime driving visibility. While daytime running lights and hazard lights remain functional, they are not sufficient substitutes for the failed systems. The problem has been consistent and reproducible. Each time the vehicle is operated, the same warning messages appear, including “Turn Indicator System Malfunction” and “Wiper Failure – Service Required,” and the affected systems do not respond. At this time, the issue has not yet been formally confirmed by a dealer or independent service center, but diagnostics codes (including communication-related fault codes) have been observed. The vehicle has not yet been inspected by the manufacturer, law enforcement, or insurance representatives. However, based on the symptoms, the issue appears to involve a failure in the vehicle’s central electronic or communication control systems. Prior to the complete failure, warning signs were present. The Volvo On Call light remained on persistently, indicating a potential underlying electrical or module communication issue. This warning appeared before the loss of the turn signals, wipers, and high beams, suggesting a progressive system failure.

    NHTSA complaint 11725903
15. Filed Feb 14, 2026Failure Jan 6, 2026Monroe, WAUnknown or other

    Vehicle: 2017 Volvo XC-90 Component: Door latch / door lock mechanism Both passenger-side door latches failed within approximately three weeks of each other due to internal corrosion/rust, as confirmed by Volvo diagnostics. The affected doors cannot be opened from inside or outside, including by key fob or interior door controls. This condition presents a serious safety risk, including potential occupant entrapment in the event of an accident, fire, or emergency evacuation. The vehicle has been well maintained, garage kept, and has not been exposed to flooding. Volvo Cars USA and an authorized dealership acknowledged the failures; however, Volvo declined assistance. The dealership offered partial labor coverage while the owner paid for parts to restore vehicle safety. Because this involves a critical safety component and occurred on multiple doors in close succession, I believe this represents a design or material defect, not normal wear, and warrants formal investigation.

    NHTSA complaint 11718017
16. Filed Jan 21, 2026Failure Jan 21, 2026Saint Johnsbury, VTUnknown or other

    The rear door latch/lock actuators on my 2017 Volvo XC90 fail to latch in cold temperatures, making the vehicle undrivable and unsafe. The doors may appear closed but are not secure, creating a serious risk to the driver, passengers, and others on the road; I rely on this vehicle daily to transport my children. The issue has worsened over multiple winters, and on one occasion the doors remained frozen for about four hours, preventing safe travel to work and school. A local independent garage has confirmed this is a known issue affecting XC90 models in cold-weather climates and identified the likely cause as failing or frozen actuators. This can be confirmed online with a simple google issue that it is a sever and prevalent safety issue. Especially with children riding int he back seats. The vehicle has been run with remote start and for extended periods in attempts to resolve the issue, and temporary measures like sprays or lubricants have not helped. The car had to run for 4 hours to be operable and it was only 10 degrees out. The problem has no warning lamps or messages and occurs only in cold weather. The system is available for inspection upon request.

    NHTSA complaint 11712394
17. Filed Dec 15, 2025Failure Dec 14, 2025150,000 milesRidgeland, SCEngine, Fuel system, GasolineFire3 injured

    The contact owned a 2017 Volvo XC90. The contact stated that after driving 35 miles at 70 MPH on I-95 South in South Carolina, the contact started smelling an abnormally gasoline odor inside the vehicle entering through the AC vents. There was no warning light illuminated. The contact and her husband continued driving, believing that the odor was coming from the outside because the air recirculation switch was set to recirculate the air inside the vehicle. The contact stated that after driving an additional 5 miles, the gasoline odor grew stronger, and the contact suggested to her husband to pull over so that they could exit the vehicle. The contact stated that her husband pulled over and they both exited with a child. The contact stated that while running away from the vehicle she could see flames underneath the vehicle coming from the engine before the vehicle exploded and was engulfed in flames. The contact and her husband ran away from the vehicle and there was grayish white smoke coming from the vehicle. The Fire Department arrived at the scene and extinguished the fire. The contact stated that Fire Department and Police Department filed incident reports, but the contact had not yet received the documents. The contact stated that the entire front of the vehicle including the engine compartment had melted down to the wheels. The contact sustained soreness to the neck and left shoulder, as well as a headache from the fuel odor. The contact, her child, and her husband were emotionally distressed from the fire. The vehicle was towed to a tow yard and was deemed a total loss. The Insurance Provider and a claims adjuster was notified of the fire and the contact was informed that further investigation was needed to determine the cause of the fire. The dealer nor the manufacturer was not notified of the failure. The failure mileage was approximately 150,000.

    NHTSA complaint 11705066
18. Filed Nov 28, 2025Failure Nov 27, 2025Maplewood, NJEngine, Fuel/propulsion system, Service brakes

    On thanksgiving day i drove to train station in the morning, and had no issue. After work i got in the car started to drive, i was going 25-35 miles per hour in the maplewood township, and i wanted to slow down just in case i dont see any kid or person at dark. I almost had no brake! I was so scared and i pushed th brake pedal so hard, i was very dangerous for the society at this moment. I just wish i was not on the highway going higher speed, or there were no people around! I really cannot trust this car anymore, i could have hit something!!!

    NHTSA complaint 11701873
19. Filed Nov 18, 2025Failure Nov 15, 2025Cumming, GAEngine, Unknown or other

    As I was driving, the coolant low warning came on. Luckily I was able to pull over safely at a nearby gas station. I found that the coolant expansion tank was empty. The coolant was leaking from the plastic connector on the bleeder hose and was pooling on the top of the engine. There is a recall on 2016 vehicles for this (Volvo campaign R29936) and looks like many are having same issue on 2017 models also. My problem was exactly as described, the part broke, coolant squirts out all over hot engine parts, system coolant level rapidly depletes. Fortunately, this happened in place that allowed safe stopping.

    NHTSA complaint 11700036
20. Filed Nov 14, 2025Failure Nov 5, 2025Severna Park, MDService brakes, Unknown or other

    On November 5, 2025, while driving my 2017 Volvo XC90, I experienced a sudden and dangerous loss of braking assist. When I pressed the brake pedal, I heard a loud hissing noise coming from under the dashboard, and the car would not stop. The brake would not work and the vehicle would not slow or stop unless I stood up and used my full body weight to press it. A licensed mechanic inspected the vehicle and confirmed this is consistent with loss of vacuum pressure from the brake booster/failure of the vacuum brake booster, the component that provides power assist to the braking system. The booster, brake pump, hose from booster to pump and brake pedal clip were replaced, with an estimated cost of $2,858. The mechanic also advised that this failure is not uncommon in Volvo XC90 models. After the incident, I researched similar complaints and found numerous reports on NHTSA and [XXX] describing **identical symptoms—hard brake pedal and hissing sound due to vacuum booster failure—**in the 2016–2019 XC90. For example, one owner reported “hard pedal, no assist, hissing sound behind dash” [XXX] , Volvo XC90 2017 Brakes section, accessed Nov 2025). No warning lights or error messages appeared before or during the event. The problem occurred suddenly and without prior symptoms. This defect posed a serious safety risk to me, my passengers, and other drivers, as it severely reduced braking ability and required excessive force to stop the vehicle. Under other conditions, this issue could easily have resulted in a crash. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

    NHTSA complaint 11699448