2022 Audi E-Tron

31 complaints on file, page 1 of 2.

1. Filed Sep 5, 2026Failure Sep 4, 2026Mill Valley, CAElectrical system

   While driving, the vehicle displayed three simultaneous warnings — “Drive system malfunction, safely stop vehicle,” “Electrical system malfunction, restart not possible, contact service,” and “All-wheel drive malfunction, limited stability” — and lost propulsion completely. This occurred on at least two separate occasions while driving. After each event, the vehicle would not restart for approximately 15 minutes, after which it began working again temporarily. The vehicle was taken to an authorized Audi dealer, which found no coolant in the front drive motor and diagnosed a fault in the SX6 high-voltage battery switching module, which controls connection of the high-voltage battery. The SX6 module was replaced. This followed a separate repair approximately three months earlier for a failure of the J1050 high-voltage battery charger control module, which had to be replaced twice due to communication failures with the vehicle’s electrical system. I am concerned this represents a recurring high-voltage electrical system defect that creates a risk of sudden loss of vehicle control/propulsion while driving.

   NHTSA complaint 11762328
2. Filed Sep 2, 2026Failure Jul 29, 2026Philadelphia, PAElectrical system, Service brakes

   The vehicle is experiencing an intermittent but active 'Electrical system: malfunction!' safety alert on the dashboard and myAudi app, caused by an internal high-voltage battery cell circuit fault (Diagnostic Trouble Code P0DB400 / U04A300) and a failure in the battery thermal runaway detection system. When the fault occurs, the vehicle suffers a complete loss of regenerative braking, severely affecting stopping predictability and vehicle handling. An authorized Audi dealership (Audi West Chester) confirmed the internal module failure under TAC Case NF-1675032 and directed a full battery module replacement. Diagnostic scans have confirmed two highly critical manufacturer trouble codes: P0DB400 (Hybrid/EV Battery Cell Balancing Circuit "C") and U04A300 (Invalid Data Received From Hybrid/EV Battery Interface Control Module "C"). However, a second dealership (Audi Cherry Hill) is refusing to honor the High-Voltage Battery Warranty or perform the necessary repairs because the safety code is currently showing as 'static' during their stationary test. Leaving an active high-voltage balancing and thermal tracking defect unaddressed poses an immediate risk of a sudden vehicle shutdown while driving or a potential thermal event.

   NHTSA complaint 11761584
3. Filed May 6, 2026Failure Jan 5, 2026Orleans, MAUnknown or other

   From time to time the driver's door does not latch completely so the door is only partially closing. Dealer was able to duplicate the problem but will not replace (estimated cost for new door latch is just under $800.) at their expense. It appears that others have had the same problem. When driving the car air rushes into the vehicle as the door is not fully shut. I worry that this problem could be very serious should I be in an accident with a partially closed door rather than a fully closed door. The problem first appeared early in the winter and seems to be getting worse.

   NHTSA complaint 11736149
4. Filed May 4, 2026Failure Apr 1, 2026Atlanta, GAService brakes

   Brakes were replaced by Audi with genuine Audi parts and within 2 months, the brake rotors became warped, requiring a resurfacing. After driving another 2 months, they once again became warped, making the entire car lurch and shake during braking.

   NHTSA complaint 11735621
5. Filed Mar 31, 2026Failure Mar 1, 2024Crown Point, INAutomatic emergency braking, Power train, Service brakes

   My drive motors keep failing (so far 3 times) and my emergency braking abruptly stops my vehicle when no true danger is present and I’m in complete control of my vehicle. Currently my vehicle has a constant shuddering while braking which doesn’t feel safe because it’s not braking properly. Audi regional and the dealership refuses to take ownership of the issue. Dealer has confirmed issue and replaced drive motors three times. Each time my braking system has gotten worse. The part was replaced each time under warranty but Audi has not confirmed that a fix has been found and corrected. This means it can occur again and abruptly which can absolutely be a safety hazard as it was each time it failed on me.

   NHTSA complaint 11728417
6. Filed Feb 23, 2026Failure Jul 23, 202516,000 milesMiami, FLElectrical system

   The contact owns a 2022 Audi E-Tron. The contact stated that while driving at various speeds, the vehicle independently switched to SAFE Mode and failed to properly accelerate while depressing the accelerator pedal. Additionally, the mileage range was reduced, and the battery recharging time increased. The failure started after the vehicle was repaired under the NHTSA Campaign Number: 23V867000 (ELECTRICAL SYSTEM). The vehicle was taken to the local dealer, but no failure was found with the vehicle. The vehicle was later taken to an independent mechanic who reported that the amperage of the battery had been reduced from 400 amps to 130 amps. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was 16,000.

   NHTSA complaint 11719794
7. Filed Feb 9, 2026Failure Nov 25, 2025St Paul, MNElectrical systemFire

   CATASTROPHIC ELECTRICAL FAILURE - SMOKE IN CABIN While driving with passengers, dashboard displayed "ELECTRICAL FAILURE - PULL OVER WHEN SAFE" followed by loud explosive POP and cabin filled with SMOKE. ROOT CAUSE: Prior undisclosed collision damage. Dealer (Morrie's Golden Valley Cadillac) removed front bumper in June 2025 (Repair Order #78683), then sold vehicle as "no accidents" in August 2025. Subsequent inspection revealed cut wiring and improper repairs (Invoice #94609). CURRENT STATUS: Vehicle inoperable 3+ months. Audi corporate technicians have repaired major problem however vehicle still has charging issues that happened right before the catastrophic failure unable to repair. SAFETY CONCERN: Smoke-filled cabin endangered occupants. Potential fire hazard.

   NHTSA complaint 11716739
8. Filed Nov 24, 2025Failure Aug 13, 2025Burnsville, MNRearview system braking, Electrical system, Blind spot detection

   The vehicles software system regularly crashes and/or does not load leaving all camera functionality and safety alerts inoperable. I have had the vehicle in to address these concerns 5 times with no resolve from the manufacturer. Even with video evidence they claim the vehicle is functioning as intended. This is in direct violation of FMVSS 111 as the rearview camera is regularly not available. Sometimes the system reboots within seconds and sometimes it takes 10 minutes or more.

   NHTSA complaint 11701360
9. Filed Sep 9, 2025Failure Sep 9, 2025Bolingbrook, ILElectrical system, Engine

   The car occasionally does not respond to pushing the pedal to accelerate. The first time it happened, I though it was user error after sitting at a light. Well within the same 30 minutes it happened again entering a carwash. Today I was sitting at a light waiting for it to turn green. Once green, I pushed the accelerator to go and the car would not accelerate. This is the second time in two weeks and approximately fifth time since I purchased the car in October 2023. No dashboard warning prior to this.

   NHTSA complaint 11685926
10. Filed May 31, 2025Failure May 30, 2025Danbury, NHService brakes

    Brakes do not work when there is a precipitation. You need to press the brake 3 times before you can feel the brakes engage. This occurs anytime it rains or snows for the entire time we’ve owned the car and Audi refuses to acknowledge the complaint

    NHTSA complaint 11664097
11. Filed Mar 18, 2025Failure Mar 18, 2025Raleigh, NCElectrical system

    The contact owns a 2022 Audi E-Tron. The contact received notification of NHTSA Campaign Number: 23V867000 (Electrical System); however, the part to do the recall repair was not yet available. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

    NHTSA complaint 11649095
12. Filed Mar 16, 2025Failure Mar 16, 2025Winchester, CAElectrical system

    Audi issued a recall notice in December 2023 regarding the high voltage battery possibly causing a fire. In the past 15 months since the recall I have not received any correspondence from Audi on a fix. I have checked with my Audi service manager several times and he stated Audi is monitoring the vehicle high voltage modules. I feel 15 months is excessive time for the manufacturer to provide a fix/repair to close the recall. This also affects the ability to trade or sell the car with a unrepaired recall.

    NHTSA complaint 11648559
13. Filed Feb 21, 2025Failure Feb 16, 2025Belmont, CAElectrical system, Engine, Power train

    I was driving on the interstate freeway in normal conditions when my 2022 Audi E-tron suddenly showed a message "Electrical system malfunction!" and lost all power to the motors. Thankfully I was in the rightmost lane already and I was able to steer and coast over to the shoulder even while pressing the gas pedal had no effect. If I had been in another lane it could have led to a major accident if my car stalled in the middle of a busy freeway. I had the vehicle towed to the local Audi dealer service center, but so far they have not been able to diagnose the problem.

    NHTSA complaint 11644045
14. Filed Feb 10, 2025Failure Feb 10, 202413,000 milesBulverde, TXElectrical system

    The contact owns a 2022 Audi E-Tron. The contact received notification of NHTSA Campaign Number: 23V867000 (Electrical System); however, the part to do the recall repair was not yet available. The contact stated while charging the vehicle, the contact noticed that the charging outlet was burned and melted, and the juice box, the plug, and the charging cable had melted, nearly causing the contact's residence to catch on fire. The vehicle was taken to the dealer, where the onboard diagnostic software was installed on the vehicle and an unknown kit was replaced as an interim repair. The vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure. The failure mileage was approximately 13,000. VIN tool confirms parts not available.

    NHTSA complaint 11641647
15. Filed Jan 5, 2025Failure Jan 4, 2025Anchorage, AKElectrical system

    No incident occurred. However, Audi recalled my EV (2022 Audi E-tron) months ago, stating there exists a fire hazard associated with these vehicles. Audi has not provided any effective remedy. The sole advice offered was to refrain from charging the battery beyond 80%. However, Audi has not substantiated the claim that this measure is protective, and it also restricts the performance and intended range of the affected vehicles. I contacted Audi of America and my local Audi dealer, but both entities have been unhelpful and unable to offer any reassurance or scientific data. Battery monitoring software is allegedly scheduled to be released this quarter (originally promised in the final quarter of 2024). This proposed solution appears insufficient. Thermal runaway could potentially lead to a fire without sufficient warning to protect consumers, even with software in place. Clearly, Audi should be compelled to replace the batteries before a consumer sustains an injury or fatalities occur due to thermal runaway and fire. Several incidents of fires involving these vehicles have been reported in the United States and other jurisdictions. Audi has since discontinued using these specific batteries and has access to safer and more efficient alternatives. I urge the National Highway Traffic Safety Administration (NHTSA) to compel Audi to provide a genuine remedy to this issue as soon as possible to safeguard consumers.

    NHTSA complaint 11634140
16. Filed Dec 18, 2024Failure Sep 22, 202315,000 milesNewton Center, MAElectrical system, Service brakes, Rotor

    The contact owns a 2022 Audi E-Tron. The contact stated while driving at an undisclosed speed, the rotors were pulsating and shaking. The contact stated while driving 65 MPH, unknown sensors engaged without an object or vehicle nearby. The contact had set the system to the lowest sensitivity. There were no warning lights illuminated. The vehicle was taken to the local dealer, where it was diagnosed and determined that the front rotors were worn. The vehicle was repaired, but the failure recurred. The dealer informed the contact that the vehicle had not been driven properly and was a maintenance issue. The manufacturer was contacted and opened a case. The approximate failure mileage was 15,000.

    NHTSA complaint 11631434
17. Filed Dec 12, 2024Failure Dec 9, 2024Lynbrook, NYElectrical system, Unknown or other

    on multiple occasions the automatic locking feature for the doors doesn't work and says to see manual. I'm afraid i will get locked in the vehicle.

    NHTSA complaint 11630345
18. Filed Sep 20, 2024Failure Sep 20, 2024Carmichael, CAElectrical system, Unknown or other

    I'm deeply concerned about the safety risks my family faces due to unresolved Audi recalls. On December 19 and 20, 2023, Audi issued two recalls: one for high-voltage battery modules that may self-discharge, leading to overheating and an increased risk of fire, and another for the 220V/240V charging cable, which can overheat home wiring, posing a serious fire hazard. On September 19, 2024, I took my car to Niello Audi to address these recalls, but they advised me to take the car home despite the significant safety risks. The service representative told me I couldn't receive a replacement charging cable because I did not have the original one; as the second owner, I never received it from the previous owner. He also mentioned that there was no remedy available for the battery issue and to come pick up my car the next day. I'm using an aftermarket charging cable, which the representative warned could increase the risk of fire. But I cannot get the cable required because I do not have the original. I transport my two young children in this car, and the thought of driving an unsafe vehicle is terrifying. On September 20, 2024, I contacted Audi America to file a claim and initiate the buyback process, as there is no safe solution available. I expressed my urgent concerns and requested a loaner car while the buyback is processed, but my request was denied despite stating it clearly was a safety issue. The Audi America representative told me to pick up my car and drive it, even after acknowledging the safety risks. Niello Audi provided a loaner for only one week, which is not long enough to navigate this complex process. This situation has left me feeling incredibly unsafe. My home is at risk of fire due to the unresolved charging cable issue, and I continue to worry about driving a vehicle with these serious problems. The ongoing recalls create an alarming risk for me and my family.

    NHTSA complaint 11615697
19. Filed Jul 19, 2024Failure Jan 18, 2023Franklin Township, NJAir bags, Service brakes, SteeringCrashFire1 injured

    On 1/18/23, I was driving my 2022 E-tron on a roadway that had no center lane markings. I had my seatbelt and cruise control on. I was traveling at 34mph straight on the right side of the roadway. Suddenly, and without warning, my car took control, drove off the road to the right, and crashed into a tree. I suffered severe injuries, including but not limited to, loss of consciousness, concussion with vertigo, vision problems, neck, back, left arm/hand, and left leg injuries. I continue to suffer from my injuries to this day.

    NHTSA complaint 11603401
20. Filed May 4, 2024Failure May 1, 2024Pittsboro, NCElectrical system, Engine, Power train

    First time in November the sign came on that there was an electrical system failure. We took the car to the shop, in Audi Raleigh and they said that they fixed the issue. Although, we had to wait for an available appointment for over a month. This time, after 3 months, the same sign came on, electrical system failure, plus all wheel drive faiture. While driving to the dealership the car stopped abbraptlly on the highway and we had to call a tow truck. This was scary because the car stopped and just would not move,. Audi knows that all 2022 -tron models have this issue and disregards the safety of the customers.

    NHTSA complaint 11586928