2021 Chevrolet Blazer

136 complaints on file, page 1 of 7.

1. Filed Oct 1, 2026Failure Jun 17, 2026Holland patent, NYElectrical system

   The main instrument cluster where the speedometer and fuel gauge etc etc reside went blank during operation of the vehicle. I wasn't able to pull over safely until my destination was reached. Restarting the car seemed to "solve" the issue.

   NHTSA complaint 11768271
2. Filed Sep 30, 2026Failure Sep 28, 2026120,000 milesLawrenceville, GAService brakes, Hydraulic

   The contact owns a 2021 Chevrolet Blazer. The contact stated that while driving at an undisclosed speed and making a turn, the vehicle lost braking functionality. The brake pedal was depressed to the floorboard. After exiting the vehicle, the contact became aware of a fluid leak underneath the vehicle. The "BRAKE Failure" warning light was illuminated. The manufacturer was notified of the failure. The vehicle was taken to a local dealer, where technicians diagnosed a fluid leak from the vacuum pump, causing the brake failure. The contact referenced NHTSA Campaign Number: 19V645000 (Service Brakes, Hydraulic) as a possible cause for the failure. However, the VIN was not included in the recall. The dealer replaced the vacuum pump, and the vehicle was repaired. The failure mileage was 120,000.

   NHTSA complaint 11768040
3. Filed Sep 26, 2026Failure Sep 25, 2026Fontana, CAEngine

   My 2021 Chevy blazer is leaking oil at 70,000 miles Chevy only recalled under special warranty for camshaft carrier it appears Chevy put in a glue for them seals that comes off unfortunately they don’t recall all blazers just some but I am having the same issue as that special warranty. It’s a safety concern because no oil in the car can blow up the engine .6500 to repair

   NHTSA complaint 11767069
4. Filed Sep 17, 2026Failure Sep 13, 2026Hubertus, WIEngine, Service brakes

   Vehicle Information: 2021 Chevrolet Blazer 2.5L engine, VIN [XXX]. Odometer 118000 miles.Description of Incident: While operating the vehicle, the mechanical brake vacuum pump experienced a catastrophic internal failure. The drive gear housing shattered violently without warning, shearing off the end of the connecting engine camshaft. Because this was an instantaneous mechanical failure, the vehicles computer did not trigger any dashboard warning lights, check engine lights, or safe mode protocols prior to the failure.Safety Hazards and Component Damage: First, the total destruction of the vacuum pump caused an immediate compromise to the brake booster vacuum lines, resulting in a sudden, dangerous loss of power braking assistance. Second, the sheared camshaft breached the engine valve cover or head, causing the engines pressurized oil system to instantly dump all engine oil externally onto the ground. Third, shrapnel or violent structural torque from the instant engine seizure punctured or severed the adjacent transmission cooler fluid lines and compromised brake fluid lines, causing total loss of transmission fluid and brake fluid simultaneously.Request for Action: This failure mirrors the exact mechanical defects documented in GM Technical Service Bulletin 21-NA-268 and previous GM vacuum pump recalls like NHTSA Recall 19V-645, which excluded the 2021 Blazer. I am filing this report because the lack of an electronic warning indicator before a catastrophic mechanical brake and engine failure poses an extreme, immediate threat to highway safety. GM must expand recall coverage or issue a Special Coverage Adjustment for this model year. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

   NHTSA complaint 11764895
5. Filed Sep 16, 2026Failure Sep 16, 2026West Bloomfield, MIEngine, Wheels

   My 2021 Chevrolet Blazer has experienced repeated problems involving the cooling system and is now exhibiting recurring symptoms that concern me about the vehicle’s reliability and safety. In 2023, the vehicle required a radiator/cooling-system repair. In 2024, it again required radiator/cooling-system repair, which was performed under warranty. The vehicle is now experiencing an abnormal humming/clicking noise from under the hood. The problem initially occurred primarily after rain but has become increasingly frequent. When the noise occurs, the air-conditioning system stops cooling properly and blows warm air. The check-engine light has also illuminated intermittently. The exact component currently malfunctioning is unknown. The vehicle remains available for inspection. Because the symptoms involve the engine compartment and follow multiple previous cooling-system repairs, I am concerned about the possibility of overheating, loss of proper cooling-system operation, an unexpected breakdown while driving, or another mechanical failure that could place the occupants or other motorists at risk. Authorized Chevrolet dealerships previously inspected and repaired the vehicle’s cooling system in 2023 and again in 2024. Despite those repairs, significant symptoms have returned. The current problem has not yet been definitively diagnosed, so I cannot state that the present failure is the same component previously repaired. The warning symptoms include the abnormal under-hood humming/clicking, loss of cold air from the air-conditioning system when the condition occurs, and an intermittent check-engine light. The symptoms have become more frequent over time. I am reporting this because of the recurring nature of the problem and the vehicle’s history of multiple cooling-system repairs. I request that NHTSA document and evaluate this complaint together with any similar complaints involving this model and model year.

   NHTSA complaint 11764652
6. Filed Sep 9, 2026Failure Aug 1, 202646,860 milesEtters, PAEngine and engine cooling

   The contact owns a 2021 Chevrolet Blazer. The contact stated that a technician identified a radiator leak during an emissions test after smelling an abnormal coolant odor. The technician confirmed that the coolant had leaked from the vehicle. Prior to the discovery by the technician, the contact’s husband observed white smoke coming from the engine. The fluid levels were checked and were normal at that time despite the smoke. Additionally, the contact stated that the message "Steering Assist Reduced" was displayed on the instrument panel prior to the failure. The vehicle was not repaired. The dealer provided an estimate for the repair with 15% goodwill assistance towards the cost. The manufacturer was notified of the failure. The vehicle was not repaired. The failure mileage was 46,860.

   NHTSA complaint 11763020
7. Filed Sep 2, 2026Failure Aug 19, 202668,400 milesGoose Creek, SCElectrical system

   The contact owns a 2021 Chevrolet Blazer. The contact stated that while driving 40 MPH, the vehicle stalled and was unable to be restarted. The vehicle was towed to the residence. The husband was a mechanic and discovered the 350-amp fuse failure. The fuse was replaced, and the vehicle was repaired. The dealer was not contacted. The manufacturer was made aware of the failure by phone. The failure mileage was approximately 68,400.

   NHTSA complaint 11761571
8. Filed Aug 24, 2026Failure Aug 5, 2026Monroe, MIEngine

   My 2021 Chevrolet Blazer RS equipped with the 3.6L LGX V6 experienced catastrophic engine failure at approximately 90,200 miles. The vehicle had no prior warning. The dealer diagnosed the timing chain / lift/ cam damage. I am requesting investigation into whether this represents a safety or durability defect affecting other vehicles

   NHTSA complaint 11759058
9. Filed Aug 23, 2026Failure Aug 15, 2026Selmer, TNEngine, Fuel/propulsion system

   Car will not crank, stalled while cranked, throws code P023F

   NHTSA complaint 11758918
10. Filed Aug 21, 2026Failure Feb 2, 2026Shelby Township, MIEngine

    While idling in my driveway, the engine started to shake and the check engine light came on. Got it diagnosed and was told by a private repair center that we had lost compression in cylinder 4 and that it was not worth the repair and we needed to replace the engine. Got it towed to the dealership, Bill Fox Chevrolet, for a 2nd opinion and they confirmed what the private shop had said. Because the vehicle was well maintained with regular preventative maintenance, it was deemed the failure was not the fault of the owner. GM extended a goodwill warranty to help cover the cost of the engine replacement (70% coverage. We were 1 month and 2,000 miles past our warranty). They never told us root cause, only that it would have cost more money to repair it than it would be to get a new engine. The Blazer had been running fine up to that point and was my wife's main mode of transportation. The Blazer only had 62,000 miles on it when the failure occured.

    NHTSA complaint 11758482
11. Filed Aug 20, 2026Failure Aug 20, 2026Imlay City, MITires

    All 4 tires exhibit signs of dry rot impacting the inner sidewalls of each tire. The outer layer is showing significant signs of sidewall separation. There is no sign of damage visible on the exterior side walls, if an inspection was not done on this date 08/20/26 the driver and others would have been at significant risk of injury or death due to catastrophic failure. The worst separation occurred in the front drive / steering tires. While lesser damage was visible on the rear tire the damage was also significant. The driver side rear showed the least damage with only a 2 inch separation. The other 3 tires showed 12 inches or greater separation. Images are available for review.

    NHTSA complaint 11758374
12. Filed Jul 30, 2026Failure Jul 29, 202652,661 milesFrederick, MDAir bagsCrash1 injured

    The contact owns a 2021 Chevrolet Blazer. The contact stated that while driving at approximately 50 MPH, the vehicle struck a deer, causing severe damage to the vehicle's front end. The contact stated that smoke was coming from the center of the steering wheel; however, the vehicle's air bags had not deployed. The contact was transported to the local hospital and treated for chest injuries. The vehicle was towed to a local collision center. No further information was available. A Police report was filed at the scene. The cause of the failure was not yet determined. The local dealer and manufacturer were not yet contacted. The failure mileage was 52,661.

    NHTSA complaint 11753752
13. Filed Jul 21, 2026Failure Jul 16, 2026100,000 milesHolyoke, MAPower train

    The contact owns a 2021 Chevrolet Blazer. The contact stated that while driving at an undisclosed speed, the accelerator pedal was depressed, and the transmission was slipping gears before the vehicle lost motive power. The contact stated that the vehicle failed to drive forward or move while in reverse. The check engine warning light was illuminated. The vehicle was towed to the residence. The contact, who was an independent mechanic, diagnosed the failure as a clutch solenoid failure. The contact stated that the transmission needed to be replaced. The vehicle was not repaired. The contact referenced an unknown recall; however, the VIN was not associated with a recall related to the failure. The dealer was made aware of the failure but provided no assistance. The manufacturer was made aware of the failure but provided no assistance. The failure mileage was approximately 100,000.

    NHTSA complaint 11751752
14. Filed Jul 9, 2026Failure Jul 4, 2026Syosset, NYFuel/propulsion system

    fuel pump control module failed at 26000. recall number N252516900. This is a recall that other 2021 blazers have ben part of. Over 300000 recalls so far. GM says my car isn't. Ridiculous. They dont want to acknowledge their fault. I need a formal statement that this module should be recalled for my car.

    NHTSA complaint 11749371
15. Filed Jul 9, 2026Failure Jul 4, 2026syosset, NYFuel/propulsion system

    XXX the car had gas, turned over, but would not start. I had it towed to a repair center who towed, did diagnostics and came up with the codes for a bad fuel pump control module. It was replaced and the car starts. There was no warning. Problem was confirmed by an independent service center. All documentation is available. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

    NHTSA complaint 11749347
16. Filed Jun 23, 2026Failure May 27, 2026Walker, MIEngine, Power train

    The thermostat malfunctioned causing an error message regarding “steering assist is reduced”. When I parked and turned off, the engine fan continued to run. When car was restarted, the temp gauge inside was stuck at C. Took to dealership and they assessed. They repaired the thermostat under power train warranty, however there was a crack in the radiator (top) resulting in the need for a new radiator. This vehicle had 35,000 miles on it. Upon research online, it seems there are MANY people who have had this same issue and worse. It appears cars produced during COVID era are most affected. Chevy refused to warranty the issue. The dealership offered a small cost reduction (due to our loyalty). The thermostat and the radiator issues seem to be well known by Chevy, they just refuse to accept responsibility. Now we are out thousands of dollars on a basically “new” vehicle.

    NHTSA complaint 11745926
17. Filed Jun 22, 2026Failure Jun 21, 2026Lebanon, INElectrical system, Engine, Assist

    The thermometer and thermometer sensor are glitching . The engine temp needle will not rise at all, the engine fan will run the whole time driving and then when it is turned off will run for 10 min . Right before this happens a notice shows the guided steering is being limited. I disconnected the battery and it reset , I drove and there were no issues , next time I started my car the engine temp needle stayed down and the van started again. This car has 36k miles on it. I just bought it 2 days before it started happening

    NHTSA complaint 11745573
18. Filed Jun 6, 2026Failure May 6, 2026Graham, WAElectrical system

    Lost coolant temp so replaced sensor with one from auto zone and worked for one then pegged to cold again fan runs 100% so went and bought another coolant temp sensor from Chevrolet installed that worked two pegged back to cold again fan 100% now going to pay $700.00 dollars to remove the two sensor wires for the harness all the two the Ecm heard with it being wrapped in the coil wires it gets electromagnetic static due to degradation of wires. Also Radiator started leaking after couple years but they want $3100.00 dollars for that.Was told extended warranty ran out three days before they discovered radiator leak.

    NHTSA complaint 11742425
19. Filed May 19, 2026Failure May 4, 2026Fairfield Twp, OHSteering

    The vehicle showed an error on the dash which stated "Action Required Steering Assist is Reduced Drive with Care" I tool the vehicle to the dealer I purchased it from McClusky Chevy at Kings Auto Mall in Mason Ohio. They informed me that the error code is C0460:58 and GM has a service bulletin 20-NA-215 which advises to replace the Steering Gear due to internal component interference. No one explained to me that this could cause catastrophic failure and lead to a crash before I left the dealership. They could not replace it as they said they do not have the part and it is on national backorder. Additionally they told me the repair would cost me $3,400. The vehicle has 42k miles on it and this repair is not under warranty as the warranty that would have covered it expired in March of 2026. I have taken the vehicle to a different GM dealer - Tom Gill GMC in Fairfield Ohio - they are waiting on the part and I have a case opened with GM regarding the costs. You would think that if there is a risk of a catastrophic failure which could cause harm to my self or someone else - the dealer would have an obligation to tell me so before i drive off. If not legally, certainly morally.

    NHTSA complaint 11738765
20. Filed May 12, 2026Failure May 11, 2026Crosby, TXSuspensionCrash3 injured

    Driving on straight road going speed limit. Heard a pop behind me like a tire pop. Car fish tailed uncontrollably and ended up crashing into a Ranch Fence on the right side of the road. 2 of my kids and myself had injuries. When we got off the vehicle witnesses and I saw A rear link broken which keeps the tires straight.

    NHTSA complaint 11737304