SUV, gasoline, 4WD/4-Wheel Drive/4x4, built in United States. Owner complaints on file from Jan 27, 2016 to Sep 20, 2026.
Owner complaints about this model year, by the year they were filed with NHTSA.
Owner complaints by component. Hover or focus a bar for the crash, fire, injury or death count.
Check a specific vehicle by VIN on NHTSA's site: a campaign may cover only part of a model year's production.
| Campaign | Filed | Subject | Component | Vehicles | Remedy |
|---|---|---|---|---|---|
| 19V-761 | Oct 24, 2019 | If a wheel-speed sensor fails, while the vehicle is traveling between 41 and 60 mph in four-wheel or automatic mode, the Electronic-Brake Control… | Stability and traction control | 652,967 | Software update |
| 19V-645 | Sep 6, 2019 | Amount of vacuum created by the vacuum pump may decrease over time | Brakes | 3,456,719 | Software update |
| 17V-437 | Jul 10, 2017 | While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy… | Airbags | 40,683 | Software update |
| 17V-033 | Jan 12, 2017 | These vehicles were assembled with a convex right-hand outside mirror, instead of with a non-convex (flat) right-hand outside mirror | Visibility and wipers | 214 | Part replacement |
| 16V-651 | Sep 8, 2016 | In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test | Airbags | 3,640,162 | Software update |
| 16V-256 | Apr 28, 2016 | Front upper control arms may have inadequate welds near the control arm bushingDo not drive | Suspension | 3,738 | Part replacement |
The full text of every complaint filed with NHTSA about this model year, newest first. Complaints are filed by owners and are not verified by NHTSA; NHTSA removes personal details before publishing.
220 complaints on file, page 1 of 11.
There is a defective paint on my 2016 ltz suburban
NHTSA complaint 11765614The contact owns a 2016 Chevrolet Suburban. The contact stated that while driving approximately 70 MPH, there was a loud booming sound coming from the vehicle, and the sunroof glass exploded. During the failure, the sunroof cover was closed. Upon inspection, the contact discovered shards of glass inside the sunroof location. The cause of the failure was not yet determined. The local dealer and manufacturer were not yet contacted. The failure mileage was 202,000.
NHTSA complaint 11759630The transmission failed suddenly and without warning. When I Went to pull out from a stop sign with cross traffic doing 55 mph, the vehicle shuddered and stopped pulling. We barely had enough momentum to get out of the way of oncoming traffic at the last second. The oncoming traffic had to brake and honked. After reading online, this is a common issue with the 6l80 transmission torque converters being a failure point and the fluid temperature being too high. Gm has a service bulletin for a lower temp bypass valve but there is no recall and these units are failing by the tens of thousands.
NHTSA complaint 11758109While in the parking lot or stopping at the stop light the brakes will get hard and won’t brake .
NHTSA complaint 11754919Hood and roof of Suburban has discolored and lost its shine coat. The door and panels are fine
NHTSA complaint 11746400As I was driving 75 mph down the highway my collision alert flashed all my lights turned off, including my headlights and all interior lights as it was dark time and they flashed back on a couple of times until they finally stayed on. I pulled over and as I came to zero, speed, the vehicle completely shut down. It did start back up, but this is not the first time I get a light on my dash that says stability track and then everything resets and I don’t have any lights on at all after that this has been happening off and on I also have three coworkers that have the same make, and year that experienced the same problems ! My situation on the highway was very dangerous. It was pitched dark outside and I lost vision due to my lights going off at 75 mph and my steering wheel also locking up. The next time the vehicle does it I will take a video for proof. I have heard that this problem is very common in these vehicles and believe something should be done because that is a dangerous situation if I was going around a corner and my steering wheel locked up, I could easily flip my car. I have small children that’s why I have the big space but we need safety for our family.
NHTSA complaint 11743382The contact owned a 2016 Chevrolet Suburban. The contact stated that while driving 30-35 MPH, the vehicle crashed into a concrete pole, and the front end of the vehicle was significantly damaged. The contact stated that the pole was 12-18 inches into the hood, and 1.5 ft. up into the engine bay. The concrete pole was damaged. The air bags and the seat belt pretensioners failed to deploy. Several warning lights, including the check engine, the ABS, the TPMS, the air bag, the StabiliTrak, and the traction control warning lights, were illuminated after the crash. The contact noticed he had sustained bumps on the head and neck from hitting the steering wheel, but did not feel sore at the time. The contact woke up dizzy the next day and sought medical assistance. The contact underwent X-rays and was informed that he had also sustained torn chest muscles. A police report was filed. The vehicle was towed to a tow lot. The insurance company towed the vehicle to another lot the following day, and the vehicle was totaled. The contact related the failure to NHTSA Campaign Number: 16V651000(Air Bags, Seat Belts), which was previously performed on the vehicle. Additionally, the contact stated that the manufacturer had also issued NHTSA Campaign Number: 17V437000(Air Bags, Seat Belts) for vehicles repaired under the previous recall, and the recall information stated that the affected vehicles may not have received the complete software update necessary to remedy the recall condition. However, the second recall had not been performed on the vehicle. The dealer was not contacted. The manufacturer was notified of the failure, and a case was filed, but the case manager was unreachable. The failure mileage was 192,252.
NHTSA complaint 11731042Per AAA—Front Airbag/Seatbelt and Increase break pedal
NHTSA complaint 11729162While driving home vehicle slid on black ice and spun out. While spinning curtain airbags and driver seat deployed and battery died. Sis not hit anything
NHTSA complaint 11721229I have read reports online of the two thousand sixteen chevy suburban turning off completely while driving.I have experienced this not once not twice.But three times now, with my chevy, suburban. This is a severe safety issue and can lead to death or major financial loss
NHTSA complaint 11719978Just purchased this vehicle used from a business in Moyock, NC. The mileage at purchase was 92,860. We checked Carfax and it showed two previous owners and had a steady maintenance history. On the way home (2 hour drive) and after the vehicle had warmed up it started showing signs of transmission problems. This was not noticeable on the test drive. The RPMs skyrocketed, the car went into neutral, once we got it back into gear it would hardly accelerate. It was a long long drive home! We took it to our local mechanic and must replace the transmission at a cost of $7,000. We will not use the manufacturer's transmission product as a replacement after reading all the complaints that are so similar to ours. Definitely not what we were expecting to have to do within a week of the purchase. There could have been injuries if my wife had not been following me and knew something was wrong when the vehicle slowed down significantly. No one was injured, except for our pride and wallet.
NHTSA complaint 11719948My 2016 transmission was jerking, shuddering, vibrating, ruff shifting and stopped moving in traffic. My safety was at risk, I turned off a major boulevard onto a neighborhood street, my SUV stopped shifting and stopped, I had to contact my son to come to help to push by hands out of traffic.
NHTSA complaint 11718392I AM REPORTING A SEVERE AND RECURRING SAFETY DEFECT WHERE MY VEHICLE SUFFERS A COMPLETE LOSS OF ELECTRICAL AND ENGINE POWER WHILE IN MOTION. THIS HAPPENS WITHOUT WARNING AT VARIOUS SPEEDS AND DURING VARIOUS MANEUVERS, INCLUDING MAKING TURNS AND DRIVING STRAIGHT. THIS HAS HAPPENED OVER 500 TIMES SINCE THE 3 YEARS I HAVE HAD IT. I HAVE NOT FELT SAFE IN THE VEHICLE FOR A LONG TIME AND WHEN I HAVE TAKEN IT TO HAVE IT CHECKED NO ONE COULD TELL ME ANYTHING BECAUSE IT WAS NOT HAPPENING AT THE MOMENT. WHEN THE VEHICLE DIES IT COMES BACK TO LIFE ON IT'S OWN BUT THE TIMING IS NOT PRECISE AS TO WHEN IT HAPPENS. THE UNPREDICTABILITY OF THESE POWER FAILURES CREATES AN IMMINENT RISK OF A HIGH SPEED COLLISION OR BEING STRANDED IN A DANGEROUS INTERSECTION. I CAN'T EVEN SELL IT TO SOMEONE IN GOOD CONSCIOUS KNOWING IT HAS THESE SERIOUS ISSUES. NOT SURE I AM DOING EVERYTHING OR CONTACTING WHO ALL I NEED TO ABOUT THIS SITUATION BUT THIS IS A START
NHTSA complaint 11712643Increased brake pedal effort to the point of difficulty to stop or control brake pressure at low speeds. This seems like the same issue reported in Safety Recall #N192268499-01, but my VIN is outside the covered range. Is the effected range in the recall correct? This has happened intermittently since we purchased the vehicle private party in 2022 with 115.5k miles on it, but is getting worse.
NHTSA complaint 11712617There are 2 components of the vehicle that I believe are malfunctioning. The first component would be the brake system. At first the problem presented itself when going down a parking garage it was approximately 5 miles an hour while applying the brake and the brake suddenly got stuck and really sticky, I had to apply extreme pressure to the brake to get the vehicle to stop completely. It was only after I put the vehicle in park, turned it off, removed the keys from the ignition, open the doors, and then restarted the car afterwards where the brakes would become unstuck. Since that first incident in summer of 2024, there has been other similar incidents when I am breaking in a parking lot at lower speeds, on side streets at lower speeds, or any other circumstance where I would be applying the brake at lower speeds. The brakes would get very sticky hard to press and would not come to a complete stop unless using extreme force. This is a very scary incident because if there was a vehicle a pedestrian and we weren't able to stop the vehicle then we would have crashed and potentially hurt someone. We brought this up to our mechanic and he was not able to reproduce the issue. The engine light does not turn on for this issue and we are not able to produce any engine light codes for the braking issue. This issue continues to happen until this day and it is scary when it does happen. The second component that we believe is malfunctioning has to do with the suspension system, the air ride system. We have taken this problem to our mechanic since 2019, 2020. They've been able to temporarily repair the issue but after some time the part breaks down and we believe that this is a manufacturing issue. There is a warning lamp that appears. What happens is there is air constantly being pumped into the suspension and is drawing electricity from the battery and ultimately affecting other parts of the electronic components.
NHTSA complaint 11712068When driving at low speeds the brakes do not work. The vehicle will stop, but it is very hard to get it to stop. You must push the brake pedal all the way to the floor to get the brakes to work. This does not happen all time it will just happen out of no were, this can be scaring. I looked up to see if our vehicle has any current recalls, which it does not. But on 9/19/2019 we had our vehicle in the shop and they did do a recall at this time. It was Increased Brake Pedal Effort. NHTSA Campaign # 19V645000 and this sounds like exactly what was happening. This was done when our vehicle had 60,000 miles on it and at the time it was having no symptoms. We had never had any brake issues at this time. Now our vehicle is having these issues and I feel that this safety issue should be another recall on our vehicle and should be covered and fixed as it sounds like the same issue. Please let me know what can be done about this.
NHTSA complaint 11700004The contact owns a 2016 Chevrolet Suburban. The contact stated that while driving at an undisclosed speed, there was a rattling sound coming from the rear of the driver’s door. Upon inspecting the vehicle, the contact discovered that the exterior trim on the front driver’s door had started to detach and was loose. The vehicle was taken to the dealer, where it was determined that the exterior trim on the front driver’s door had failed and needed to be replaced. The vehicle was repaired. The manufacturer was made aware of the failure and referred the contact to the NHTSA for assistance. The approximate failure mileage was 121,000.
NHTSA complaint 11696832Transmission and Engine Failed. Please inspect. I've had several shops and mechanics inspect. I was towing both times and could have been seriously injured when my transmission went out. Then after that was resolved my engine went out. No symptoms or warnings before incidents occurred.
NHTSA complaint 11694557Gas leak on top of tank from fuel line strong gas odor in vehicle
NHTSA complaint 11681086The contact owns a 2016 Chevrolet Suburban. The contact stated while driving at approximately 70 MPH, the vehicle brakes independently activated. The contact stated there were no warning lights illuminated. The contact pulled off the highway and stopped the vehicle. The vehicle was turned off and restarted and regained braking functionality. The failure was intermittent but occurred at various speeds. The failure occurred mostly while driving up an incline and depressing the accelerator pedal and the independent braking failure would occur. The contact had not taken the vehicle to a dealer or independent mechanic to be diagnosed. The vehicle was not repaired. The contact stated that prior to the failures the vehicle had been taken to a dealer to be repaired under NHTSA Campaign Number: 19V645000 (Service Brakes, Hydraulic). The manufacturer was not informed of the failure. The failure mileage was approximately 175,000.
NHTSA complaint 11679020Technical service bulletins and other notices the manufacturer sent to dealers. A bulletin is not a recall; the 60 most recent are listed.