2019 Ford F-250 SD

1,164 complaints on file, page 1 of 59.

1. Filed Sep 9, 2026Failure Oct 10, 2025Orange, CAEngine, Fuel/propulsion system

   NHTSA Vehicle Safety Complain To whom it may concern, My Name is [XXX] I am submitting this complaint regarding my 2019 Ford F-250 Super Duty equipped with the 6.7L Power Stroke diesel engine (VIN: [XXX]). At approximately 137,900 miles, my vehicle suddenly lost engine power while driving and stalled without warning, creating a serious safety hazard. After stalling, the truck would not restart and had to be towed to a repair facility. The repair shop diagnosed a catastrophic failure of the diesel high-pressure fuel injection pump. According to the repair invoice, fine metallic flakes were found throughout the entire fuel system, contaminating the fuel lines, fuel tank, injectors, and related components. Because of this contamination, the shop determined that the entire fuel system required replacement, including replacement of all eight fuel injectors, cleaning of the fuel tank and fuel lines, replacement of the fuel filter, and installation of an upgraded diesel injection pump. The estimated repair cost exceeded $11,000, resulting in a significant financial burden. I understand that Ford Safety Recall 24S78 addresses a high-pressure fuel pump issue on certain 2020–2022 Ford Super Duty trucks equipped with the same 6.7L Power Stroke diesel engine. Although my 2019 model is not included in the recall, my vehicle experienced what appears to be a very similar failure that resulted in sudden loss of engine power while driving and complete contamination of the fuel system. I am not asserting that my vehicle is covered by the current recall. Rather, I respectfully request that NHTSA investigate whether the same or a substantially similar defect may also affect certain 2019 Ford F-250 Super Duty vehicles equipped with the 6.7L Power Stroke diesel engine. If the investigation determines that these vehicles are affected by the same safety defect, I ask that the recall be expanded accordingly. I have retained the repair invoice documenting the diagnosis INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA

   NHTSA complaint 11763171
2. Filed Sep 8, 2026Failure Sep 3, 2026144,000 milesDonna, TXFuel system, Fuel filterFire

   The contact owns a 2019 Ford F-250 SD. The contact stated that while driving 70 MPH, there was an abnormal diesel odor on the inside of the vehicle. The contact stated that the vehicle failed to exceed 65 MPH, and there was white to gray smoke coming from under the hood. The contact pulled over with the engine still running and after opening the hood, the contact became aware of diesel fuel squirting out from the secondary fuel filter. The contact stated that the fire consumed the vehicle. The fire was coming from underneath the driver's side hood and driver’s side wheel well. The Fire Department was contacted and extinguished the fire coming from the vehicle. The vehicle was towed to an impound lot, and it was deemed a total loss by the insurance company. The manufacturer was contacted by phone and was made aware of the failure. The failure mileage was approximately 144,000.

   NHTSA complaint 11762856
3. Filed Aug 31, 2026Failure Aug 29, 2026Overland Park, KSSteering, Unknown or other

   I experienced a severe, violent, and uncontrollable front-end suspension and steering wheel oscillation—commonly known as the "Ford Super Duty Death Wobble." While traveling at highway speeds approximately 70mph, I came across a bridge expansion joint (nothing unusual) and immediately upon impacting the joint, the front axle began shaking so violently that it caused a sudden, near-total loss of steering control. The violent shaking made it nearly impossible to maintain a straight lane of travel, risking a catastrophic multi-vehicle collision. The steering wheel jerked violently side-to-side, forcing me to rapidly and dangerously decelerate in active highway traffic to regain control of the vehicle. This defect created an extreme, unpredictable safety hazard. I immediately let-off the accelerator with some braking to stop the oscillation and regain control. A local specialty alignment shop previously attempted an adjustment, as I had experienced this a couple of months before (although not as severe as this most recent incident) on [XXX] in eastern [XXX]. The adjustment temporarily masked the underlying issue for approximately 2.5 months before the violent oscillation returned as I am reporting now. The local Ford dealership (Victory Ford) has confirmed that the vehicle qualifies for Customer Satisfaction Program 20B02 (Steering Linkage Damper Replacement), demonstrating the manufacturer's awareness of this dangerous defect. However, no formal safety recall has been issued. Aside from Fords damper replacement online research and an independent alignment shop recommends replacement of track bars, bushings, steering damper, etc. with heavy duty parts. Fords damper replacement is reported to only mask the real problem. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

   NHTSA complaint 11761034
4. Filed Aug 17, 2026Failure Aug 8, 2026Parrish, FLElectrical system, Power train, Steering

   I am filing a complaint against Capital Auto Mall Premier regarding the sale of a 2019 Ford F\-250 Lariat \(VIN [XXX]\) that I purchased on XXX. The vehicle was represented as being in good working condition at the time of sale. However, almost immediately after taking possession of the vehicle, I began discovering numerous mechanical, electrical, and safety\-related defects. Due to the number of concerns, I had the vehicle independently inspected shortly after purchase. The inspection identified multiple significant issues, including transmission hard shifting, transfer case clunking during shifting, battery failure requiring replacement, steering and suspension concerns, excessive play in front suspension components, and numerous diagnostic trouble codes stored in the vehicle's systems. In addition to these findings, I discovered issues involving vehicle lighting, winch operation, and other features and equipment that were not functioning properly despite being expected to be operational at the time of sale. These issues became apparent within days of purchasing the vehicle. The quantity and severity of the defects lead me to believe that the vehicle was not in the condition represented during the sale and that material defects may not have been properly disclosed before the transaction occurred. As a result of these issues, I have incurred costs associated with inspections and diagnostics and am obtaining additional repair estimates to determine the full cost of necessary repairs. The defects significantly impact the vehicle's safety, reliability, usability, and value. I have supporting documentation, including the purchase agreement, financing documents, independent inspection reports, diagnostic findings, photographs, repair estimates, and records of communications regarding the vehicle. This documentation demonstrates that the concerns were identified almost immediately after purchase and were not the result of normal wear occurring INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA)

   NHTSA complaint 11757517
5. Filed Jul 5, 2026Failure Jul 5, 2026Newnan, GASteering, Suspension, Wheels

   Experienced the oft reported death wobble while driving home from TN and had to limp my vehicle home while experiencing the constant, extreme and dangerous wobbling.

   NHTSA complaint 11748379
6. Filed Jun 29, 2026Failure Apr 26, 202680,000 milesCastle Rock, COVisibility

   The contact owns a 2019 Ford F-250. The contact stated that while driving approximately 65 MPH on a cross-country move, the rear windshield was loose and was shaking inside the frame. The contact stated the rear glass remained attached and hanging within the frame. The vehicle was taken to a dealer to be diagnosed. The dealer replaced the rear window frame and window bracket, and the vehicle was repaired. The manufacturer was notified of the failure but offered no assistance. The failure mileage was approximately 80,000.

   NHTSA complaint 11747261
7. Filed Jun 25, 2026Failure Sep 20, 2024Falls City, TXFuel/propulsion system

   While driving the truck completely just shutdown and then would not start.

   NHTSA complaint 11746368
8. Filed Jun 20, 2026Failure Jun 5, 2026Fair Grove, MOPower train

   At around 139,000 miles i started to noticed some intermittent noise coming from the drivetrain. I took it to two different repair shops and was told it was tire noise. over time the grinding noise increased to the point of shuddering and jerking while shifting with no warning lamps showing. At 144,500 miles I contacted my aftermarket warranty and they said to take it to a certified shop to get it checked out. They did not have any preferred shops in my area so I took it to US Automotive. At 145,000 miles the shop contacted the warranty company and proceeded with investigation of the issue. After inspection and tear down they confirmed the transmission had the typical failure for the 10R80 10-speed automatic transmissions. They turned over there findings and the warranty company which has agreed to the findings and has offered a replacement used transmission with 125,000 miles on it and will also not cover the full cost to install the used unit. I feel that this is fraud and outside of the warranty agreement. I am now paying the expense to put the original transmission back into the truck to try to take it the 2.5 hours back to the dealership which sold me the truck along with the warranty to see what they will do in the matter. I hope it doesn't fail on the highway on the way.

   NHTSA complaint 11745407
9. Filed May 24, 2026Failure Jan 21, 2026Fort Collins, COPower train

   My truck transmission changes gears randomly while in motion. It is terrifying when it happens in traffic and the truck stalls and looses power then kicks back in with a loud noise. I stopped driving it since March of 2026.

   NHTSA complaint 11739763
10. Filed May 12, 2026Failure Jan 1, 2022Albuquerque, NMFuel/propulsion system

    Original Fuel pump stated intermittent long cracks about 35,000 miles. And continues to do so. It seems like FORD uses the all time favorite “ we cannot recreate the issue” in order to send the customer on their way and not take ANY responsibility whatsoever ,WOW! Its rediculous that they don’t want to acknowledge the issue after thousands of customers complain. Our whole family has been riding in this vehicle when the truck experienced the truck lag and turn off at highway speeds. Does someone have to be hurt or killed by this for this company to finally own up? I hope none does!!! Make it right FORD!!! Yet they changes and updated the newer trucks pumps after this, why? REDICULOUS

    NHTSA complaint 11737324
11. Filed Apr 4, 2026Failure Jan 10, 2026Wayne, NJSuspension

    While driving at highway speeds, I drove over an expansion joint on a bridge and experienced violent shaking of the vehicle. This included violent shaking of the steering wheel and interior of the truck. I also slowed down to under 30 mph on the highway to stop the shaking. This occurred several other times and, upon researching, found it to be called a "death wobble". I brought my truck to a Ford dealership service center and mentioned the death wobble, which was immediately acknowledged. This cost $1758 out of pocket to fix. From research I have done, it seems all suspension components should not need any type of repair or replacement prior to reaching 50,000 miles, with some components lasting as much as 100,000 miles.

    NHTSA complaint 11729149
12. Filed Mar 31, 2026Failure Mar 4, 2026La Grange, TXFuel/propulsion system

    My husband was driving our 2019 F250 on the highway at over 75 mph and the truck totally shut down/stalled without warning, could have killed him or another person, lucky he was able to coast to the shoulder and stop, we took to the Ford dealership and was caused by the faulty CP4 fuel pump the truck was made with that has had class action lawsuits and recalls, we are out of pocket over $14,000 to rebuild entire fuel system due to the fact that fuel pump is NOT compatible with our diesel fuel leading to metal shavings build up in fuel system. Our truck still has no recall on this and it should and we should be reimbursed for the extremely expensive and lengthy repair, this is a very dangerous issue. The mechanic also stated he "duplicated" the stall when he go on the highway and hit speeds over 60 mph, thank goodness he is ok as well.

    NHTSA complaint 11728201
13. Filed Mar 25, 2026Failure Mar 22, 202652,000 milesGold Hill, ORTires

    The contact owns a 2019 Ford F-250 equipped with Cooper Tires, Tire Line: Discoverer AT3, Tire Size: 295/60/R20, DOT Number: (N/A). The contact stated that while driving 60 MPH and hauling a trailer, the vehicle jolted into oncoming traffic and started wobbling. The contact regained control of the vehicle and eventually steered to the side of the road and parked the vehicle. The contact became aware of a flat spot on the tire, and the spare tire was placed on the driver’s side front. The contact continued driving, and the wobbling became controllable at speeds under 50 MPH. The vehicle was taken to the residence, where the contact observed that the driver's side front tire had tire separation in the middle of the tire. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The tire failure mileage was 37,000. The vehicle failure mileage was 52,000.

    NHTSA complaint 11726974
14. Filed Mar 23, 2026Failure Mar 5, 2026Lagrange, TXFuel/propulsion system

    Without warning while I was driving at ~70 mph on the highway the engine in my truck died and left me with no power brakes or power steering in busy traffic. This is a very scary situation to be in. I pulled over and checked the truck best I could. Started it back up and carefully pulled back out onto the highway when it died again. I took it to the closest Ford service center and after diagnosis, they told me the CP4 pump is failing and will need to be replaced at a cost of ~$14,000. My research shows this is a common issue for Ford for a certain year range which my truck is in and they have recently paused the recall addressing the issue so the recall is not showing up when searching my VIN. I would appreciate Ford claiming that this is a safety issue and reimburse me for my out of pocket costs.

    NHTSA complaint 11726431
15. Filed Mar 17, 2026Failure Mar 16, 2026Seligman, AZ 86337, AZBlind spot detection

    Ford Motor Company Has Decided to Cancel/Pause Customer Satisfaction Campaign 22M03 without Reason or Notice Given to Customers at this Time after being Told By Service Advisor Ron Fultz #3689 at Anderson Ford 3601 Stockton Hill Rd Kingman, AZ 86409....That the effected Cameras as well as the Recall for the Rear Tailgate camera 22S51 would be Preformed....To no Avail as was told at the end of the Service Visit Could not Preform the Needed Side and Front Face Camera upgrade as Per Canceled/Paused with no Timeframe Given and Lied to as the Scope of Service to be done upon Scheduled Appointment for all to Addressed

    NHTSA complaint 11724935
16. Filed Mar 11, 2026Failure May 1, 2025Albuquerque, NMFuel/propulsion system

    2019 Ford F-250 original fuel pump or related part connected cause hard and prolonged starting in vehicle. Prolonged starts can damage other parts if left unfixed. This is a Ford manufacturing issue and could cause a person possible harm from an unknown development from the pump and related affected parts. Dont wait until humans are injured to address this problem especially when dealing with potential combustible explosive materials. [XXX] , [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

    NHTSA complaint 11723532
17. Filed Mar 7, 2026Failure Nov 20, 2025Arma, KSFuel/propulsion system

    2019 F-250 6.2 84k miles fuel pump check valve has gone back no a new issue it’s all over the web with problems most are seeing it with even 40k when you put a new one in you get less then that or equal amount and it goes out.

    NHTSA complaint 11722708
18. Filed Feb 8, 2026Failure Feb 7, 2026San Miguel, CARearview system braking, Unknown or other

    The rear view backup camera will get scrambled or become blurry from time to time . It is happening more frequently causing the inability to know what is behind you when backing up.

    NHTSA complaint 11716525
19. Filed Feb 3, 2026Failure Jan 24, 2026Florence, AZRim

    The contact owns a 2019 Ford F-250. The contact purchased four aftermarket steel rims for the vehicle. The vehicle was taken to have the rims balanced, and the contact was advised by the technician that the steel rims were not rated for a 3/4-ton vehicle. The contact stated that the seller's website had listed the rims as compatible for a 3/4-ton vehicle. The contact returned the rims to the seller; however, the contact felt that the seller should have correctly identified the wheels for the correct vehicle weight, because the vehicle was used to haul trailers.

    NHTSA complaint 11715321
20. Filed Jan 9, 2026Failure Dec 11, 2025127,000 milesQuitman, MSColumn

    The contact owns a 2019 Ford F-250. The contact stated that while cleaning the steering wheel, the steering column became loose. No warning light was illuminated. An Independent mechanic was contacted. The vehicle was not taken to the dealer or an independent mechanic to be diagnosed. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 127,000.

    NHTSA complaint 11709912