2022 Ford F-350 SD

111 complaints on file, page 1 of 6.

1. Filed Sep 25, 2026Failure Sep 20, 202656,000 milesWoodruff, SCElectrical system

   The contact owns a 2022 Ford F-350 SD. The contact stated that while driving 45 MPH, the vehicle lost automotive power. Upon further investigation, the contact became aware that there was water accumulated in the battery junction box. The vehicle was towed to a local dealer to be diagnosed, and the failure was confirmed as water accumulation in the battery junction box. An appointment for the repair was scheduled with the local dealer. The failure mileage was approximately 56,000.

   NHTSA complaint 11766973
2. Filed Sep 7, 2026Failure Sep 2, 2026Seguin, TXElectrical system, Engine, Fuel/propulsion system

   Vehicle lost complete power unexpectedly.

   NHTSA complaint 11762616
3. Filed Sep 4, 2026Failure Sep 4, 2026clawson, MIEngine, Power train

   I have contacted my dealer several times over the past year, and filed a complaint with Ford Motor Company's, Office of General Counsel. To date, NO response from Ford. The dealer relies on Ford for the fix. This is an alarming issue, in that the failure will be mostly unexpected and perhaps catastrophic. I find it unusual and negligent for Ford to take this long for the remedy. My dealer tells me no parts are available. I drive sometimes out of state. I may get stranded and still no one can fix the issue. Ford needs "jacking up" to get this done. Fourteen months have lapsed and its way overdue.

   NHTSA complaint 11762089
4. Filed Aug 15, 2026Failure Aug 15, 2026Egg Harbor Township, NJFuel/propulsion system

   I find it absolutely absurd that the fuel pump recall is still not resolved! When are you going to hold Ford accountable for this egregious delay? This has been over a year now. Everyday I drive my truck and tow my travel trailer wondering if at anytime it may just die on me on the highway.

   NHTSA complaint 11757127
5. Filed Aug 3, 2026Failure Jun 15, 20221,500 milesLake Havasu City, AZBack over prevention

   The contact owns a 2022 Ford F-350 SD. The contact received notification of NHTSA Campaign Number: 25V686000 (Back Over Prevention). The contact stated that while in reverse(R) on several occasions, the rear-view camera was black. The contact stated that on one occasion while his wife was driving the vehicle and shifted into reverse(R), the camera went black, and the vehicle reversed into a cement pole. The vehicle was taken to a dealer where the vehicle was not diagnosed; however, the contact was informed that the part to repair the vehicle was not yet available. The manufacturer was not notified of the failure. The failure mileage was approximately 1,500.

   NHTSA complaint 11754513
6. Filed Jul 11, 2026Failure Jul 11, 2026Rochester, ILElectrical system

   fuse box is allowing moisture in causing horn to not stop and truck to remain running. Ford has updates in their manual that this is a problem but no recall issued.

   NHTSA complaint 11749684
7. Filed Jul 8, 2026Failure Jul 8, 2026Palomar Mountain, CAFuel/propulsion system

   I have been waiting over a year for this low pressure fuel pump recall and it has stopped me from driving long distance to visit my daughter where part of the trip is hoursbthrew the Nevada high desert with extreme heat and NO CELL SERVICE. I AM FED UP AND NEED YHISNISDUE REDOVLED NOW OR A NEW DARN TRUCK. PLEASE ADVISE

   NHTSA complaint 11749092
8. Filed Jul 6, 2026Failure Jul 1, 2026Fallbrook, CARearview system braking, Electrical system, Blind spot detection

   While traveling with my fifth-wheel camper attached, my 2022 Ford F-350 Super Duty (6.7L Power Stroke) suddenly developed a complete no-crank condition. Prior to the failure, the vehicle displayed multiple electrical warnings, including U0100 (Lost Communication with PCM), High Engine Temperature, AdvanceTrac, Blind Spot System Fault, Hill Start Assist, and Pre-Collision Assist warnings. The vehicle ultimately became disabled and would not crank or start, leaving me stranded away from home while towing a trailer. Repair Description After troubleshooting the vehicle, I discovered severe internal corrosion inside the under-hood Battery Junction Box (BJB). The corrosion appeared consistent with Ford Technical Service Bulletin 23-2133 regarding moisture intrusion into the Battery Junction Box on certain 2020–2022 Super Duty trucks. I purchased a genuine Ford replacement Battery Junction Box from a Ford dealership and installed it. Immediately after replacement, the vehicle started normally and all warning messages disappeared. I retained the failed Battery Junction Box and have photographs documenting the internal corrosion. Safety Concern My concern is not simply the repair cost but the safety implications of this failure. The vehicle became completely disabled while towing a fifth-wheel trailer during travel. A sudden electrical failure affecting the Battery Junction Box can leave occupants stranded and may create hazardous situations if it occurs in remote locations or during travel. Because Ford has issued a Technical Service Bulletin addressing moisture intrusion into the Battery Junction Box, I believe this condition should be evaluated to determine whether additional action is warranted.

   NHTSA complaint 11748576
9. Filed Jun 3, 2026Failure Jun 2, 2026Coronado, CAUnknown or other

   When the vehicle is moving forward, and rear camera is selected to visibly confirm the status of anything behind the vehicle, there is a giant black bar/box that states "full view not available" Clearly this is a safety hazard in the sense that I am unable to rapidly assess and determine the status of anything behind my vehicle, be it a trailer, a hitch mounted bike rack, or another vehicle. Ford should be required to remove all of these distractions from their software immediately.

   NHTSA complaint 11741709
10. Filed May 28, 2026Failure May 28, 2026Springfield, KYService brakes

    Trailer Brake Module Failure message at start up. I no longer have any trailer brake function. I was towing when this happened.

    NHTSA complaint 11740749
11. Filed May 22, 2026Failure Mar 17, 2026105,000 milesAlda, NEElectrical system

    The contact owns a 2022 Ford F-350. The contact stated while driving at an undisclosed speed, the trailor lights and the brake lights failed to function as intended. No warning lights were ullimunated. The vehicle was taken to the dealer where it was diagnosed with a malfunction with the trailor brakes and service brakes. The contact was informed that the parts were unavailable. The vehicle was not repaired. The contact received a recall notification, NHTSA Campaign Number 22V193000 Electrical System) however the parts were unavailable.

    NHTSA complaint 11739487
12. Filed May 11, 2026Failure May 6, 2026Stamford, NYElectrical system, Warnings, Vehicle speed control

    Charging System Fault. Caused multiple error messages like Forward camera not available, collision avoidance not available. Then Radio goes black and reboots. Several cycles later the dash board goes DARK. No speed or RPM anything visible for 5-10 secs, and on some reboots this Dark dash lasted 30 seconds. Thankfully while traveling at midnight the head lights and tail lights remain on, just no interior lights during these Reboots. New batteries made no difference.

    NHTSA complaint 11736993
13. Filed May 5, 2026Failure Apr 3, 2026Jacksboro, TNElectrical system, Power train, Unknown or other

    While flat towing my 2022 Ford F‑350 behind a motorhome using Ford’s Neutral Tow Mode procedure, the vehicle suffered a catastrophic transmission failure. The Ford dealer documented this clearly on the service invoice: “HAPPENED WHILE THE VEHICLE WAS FLAT TOWED.” After the tow, the truck had severe slipping, delayed engagement, high RPM with no movement, and a wrench light. The dealer confirmed fault codes P0741, P1744, and P27B4. The dealer found catastrophic internal damage: “fluid is burnt with metal debris… filter is packed with metal debris… torque converter has came apart and filled transmission with metal debris… it is catastrophic failure.” These components are available for inspection. The dealer also documented a low battery condition: “batteries. low state of charge.” Ford’s Neutral Tow Mode relies on electronic control modules that require stable voltage, but Ford provides no warning that low voltage can cause the transfer case to exit Neutral Tow Mode. This creates a safety risk because the transmission can be rotated internally without lubrication while being towed, which can lead to sudden drivetrain lockup or loss of control. The problem was confirmed by the Ford dealer, and the vehicle was fully inspected by them. The only warning symptom occurred after towing: wrench light, slipping, and no movement. There were no warnings during the tow itself. This failure mode is not disclosed by Ford and cannot be detected or prevented by the owner.

    NHTSA complaint 11735855
14. Filed Apr 25, 2026Failure Jun 20, 2024Oceanside, CAWarnings

    The right rear corner parking sensor on the truck has a 3 foot range. I believe these rear back up sensors normally should have a 12-15 foot range. I was backing up at an angle at slow speeds at hit a large brick mailbox. The mailbox is below the height of the closed tailgate. This could have been a adult or child. The sensor triggered but I did not stop in time. At 5mph a 3 foot distance is covered in .4 seconds. I replaced the bumper and the bumper cover as a result of this .

    NHTSA complaint 11733762
15. Filed Apr 19, 2026Failure Apr 18, 2026Zionsville, INService brakes, Vehicle speed control

    This is not a failed component, the issue is a design interaction issue. This truck when it gets stuck as it unfortunately very easily does even on wet grass goes into a traction control mode where the throttle is VERY damped but the issue is not only is the opening very dampened the closing is also VERY damped. This is made significantly worse by the fact that traction control cannot actually be disabled. There is a switch and it indicates it is disabled but the functionality remains the same. This combination means whenever you're working to get the truck unstuck, like yesterday when it was on wet grass you have to expect that the vehicle will suddenly accelerate as soon as it finds traction. normally you can counteract this by expecting to apply significant brakes as soon as it finds traction but if the front wheels are still on a slippery surface the ABS system will lose it's mind and essentially disable brakes as the vehicle accelerates violently backwards with the new found traction. This combination of software decisions makes it so you can very easily replicate an unintended acceleration scenario where the vehicle jumps back a solid 20' when this happens, not respecting any brake input given by the driver and certainly not respecting that the throttle was released long ago. The throttle closing should not be damped when traction control is running and the ABS system should not be behaving the way it does. I understand getting the vehicle unstuck from wet grass is not normal operation but that's what the traction control disable button should be for and Ford makes that button useless also. When taken together, all these engineering decisions make for a very unsafe situation that has zero reason to exist. I've attached pictures that show the overview of the situation as well as the characteristic ABS marks showing that it was disabling brakes.

    NHTSA complaint 11732180
16. Filed Apr 10, 2026Failure Apr 10, 202630,000 milesRochester Hills, MIBack over prevention, Electrical system, Fuel system, Gasoline

    The contact owns a 2022 Ford F-350 SD. The contact stated that while attempting to accelerate from a complete stop, the vehicle lost power. There was no warning light illuminated. The vehicle was able to restart. The contact received notification of NHTSA Campaign Numbers: 25V455000 (Fuel System, Gasoline), 25V686000 (Back Over Prevention), 26V104000 (Electrical System, Exterior Lighting), and 26V204000 (Visibility); however, the parts to do the recall repairs were not yet available. The vehicle was taken to the dealer but was not diagnosed or repaired. The dealer stated that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 30,000.

    NHTSA complaint 11730352
17. Filed Apr 10, 2026Failure Apr 9, 2026Nash, TXSteering

    2022 F350 SRW, King Ranch, Tremor Steering column began making clunking sound when hitting rough patches on highway. I then noticed that I was able to lift the steering wheel an inch or two up and also pull it towards me two to three inches and freely push it back in. I could wobble the steering wheel side to side as well. Felt very unsafe as I was on a 7 hour trip home. No warning lights or incident that contributed to problem

    NHTSA complaint 11730326
18. Filed Apr 9, 2026Failure Apr 2, 2025Austin, TXUnknown or other

    Front facing camera, located in front grill, has inadequate water proofing, which eventually shorts out the camera and causing it to become inoperable. This creates a blind spot when backing up or driving in tight spaces with such a large truck. When the front camera blacks out, you lose visibility in front of the vehicle. This is a safety issue, because the size of the truck, how high it sits from the factory, and no visibility over the hood could cause a collision with low height persons or kids or property. Yes, this issue has been reproduced by the dealer. And there are numerous reports of people on message forums and social media complaining of this issue. There were no warnings of this prior to failure. One day the front facing camera simply stopped working, leaving a black screen for any camera views that include the front camera.

    NHTSA complaint 11730191
19. Filed Apr 8, 2026Failure Apr 7, 2026Granite Falls, NCUnknown or other

    Glass roof panel behind sunroof (over rear seats of crew cab) shattered while driving on the highway at 5:30am with no other vehicles within several hundred yards. No sign of impact, remaining glass seems to be pushed outward.

    NHTSA complaint 11730058
20. Filed Feb 27, 2026Failure Feb 24, 202632,076 milesWhiting, NJVisibility/wiper

    The contact owns a 2022 Ford F-350 SD. The contact stated that while driving approximately 45-50 MPH, in snowy weather, the front driver's side windshield wiper fractured, and the contact pulled over to manually wipe the window. The dealer was notified of the failure and informed the contact that the vehicle could not be repaired under Ford Campaign Number: 22S26 (Both Front Wiper Arm Replacement) because the VIN was not included. The vehicle was not diagnosed or repaired. The manufacturer was contacted and confirmed the dealer's information. The failure mileage was approximately 32,076.

    NHTSA complaint 11721025