SUV, gasoline, built in United States. Owner complaints on file from Jul 26, 2021 to Nov 24, 2025.
Owner complaints about this model year, by the year they were filed with NHTSA.
Owner complaints by component. Hover or focus a bar for the crash, fire, injury or death count.
Check a specific vehicle by VIN on NHTSA's site: a campaign may cover only part of a model year's production.
| Campaign | Filed | Subject | Component | Vehicles | Remedy |
|---|---|---|---|---|---|
| 24V-207 | Mar 15, 2024 | 48-Volt ground connection under the passenger seat may not be secured properly, resulting in the ground connection overheating | Electrical system | 116,020 | Repair or modification |
| 24V-118 | Feb 16, 2024 | Transmission may not fully downshift in certain conditions, causing the engine to stall | Powertrain | 105,071 | Software update |
| 23V-445 | Jun 26, 2023 | Fuel pump may shutdown, which can result in a loss of drive power | Fuel system | 143,551 | Part replacement |
| 23V-177 | Mar 17, 2023 | Air conditioner drain hoses may have been incorrectly installed, causing water to drain into the passenger compartment | Visibility and wipers | 61,450 | Repair or modification |
| 22V-732 | Sep 30, 2022 | Due to a manufacturing error, the locks on the third-row seatbacks may fail in the event of a crash | Seats | 59,574 | Part replacement |
| 22V-680 | Sep 12, 2022 | Due to a manufacturing error, the rear door window trim bars may detach | Structure | 161,000 | Repair or modification |
| 22V-365 | May 20, 2022 | Error in the communication module's SIM card software can cause a mobile network connection failure, disabling the emergency call (eCall) system | Communication | 242,722 | Software update |
| 22V-231 | Apr 8, 2022 | Ground cable bolt for the 48V ground connection under the front passenger seat may not be secured properly, which can cause the electrical cable… | Electrical system | 21,306 | Repair or modification |
| 21V-832 | Oct 22, 2021 | Rear window may be insufficiently bonded to the tailgate, which could allow the rear glass to detach | Visibility and wipers | 23 | Part replacement |
| 21V-354 | May 14, 2021 | MBUX multimedia system software may cause the display to remain black, or reboot after startup | Back-over prevention | 343,191 | Software update |
| 21V-058 | Feb 5, 2021 | Software design of the communication module may fail to communicate the correct vehicle location for the emergency call system (eCall) in the… | Communication | 1,292,258 | Software update |
| 20V-089 | Feb 14, 2020 | Instrument cluster software may deactivate the illumination of certain interior switches (switch bar, overhead control unit, steering wheel) if… | Electrical system | 2,101 | Software update |
The full text of every complaint filed with NHTSA about this model year, newest first. Complaints are filed by owners and are not verified by NHTSA; NHTSA removes personal details before publishing.
30 complaints on file, page 1 of 2.
Both rear wheels on this vehicle have developed cracks which leads to tire pressure loss. Apparently, this is a common issue with Mercedes' heavier vehicles like the GLS and S series sedans. To be clear, I did not hit anything. I did not do any unusual driving. Both rear tires are fine. While you expect that certain components on a vehicle will have problems, it is also reasonable to expect that wheels will not crack prematuraly. Mercedes is aware of the problems. They were named in a class action lawsuit that was dismissed because cars were out of warranty. Warranty or no warranty, this is a major safety issue as a loss in tire pressure can be catastrophic.
NHTSA complaint 11701188On [XXX], I was heading home from work traveling [XXX] on [XXX] through Atlanta's usual heavy traffic. I smelled smoke inside my car and saw fire flames coming from under my passenger seat. My initial reaction was to try to put the fire out with my hat without burning myself. Also, I had to try to navigate across multiple lanes of traffic without hitting anyone and avoiding anyone hitting me. Safely, i reached the side of the interstate and exited the vehicle. As I stood from afar watching my vehicle burn; the reality sat it that a few minutes earlier that could have been me trapped burning inside, injured or even death because something had failed in my vehicle. Later, when I finally arrived home, I started researching on the internet to see if anyone else had experienced problems with their MB 450 GLS catching fire. Surprisingly, I found that recalls had been issued in April 2022 and March 2024 for a possible fire risk from a 48volt loose ground wire issue under the passenger seat. At that time supposedly there were no reported injuries or crashes related to this issue until now. If I am the first to witness this issue, then so be it because I saw the fire burning from inside under my passenger seat before it FULLY torched my vehicle I reported this issue first to Progressive Insurance and Mercedes-Benz Corporate. Progressive has provided my transportation according to policy for my first 30 days. As I approached the end of my rental period, I spoke with MB Corporate to see if there was anything that they could do as far as providing me transportation. I was told that there was nothing that they could do because they were not a dealership with cars to loan. The joint vehicle fire investigation was schelduled for 29 April 2025. On 25 April 2025, Progressive informed me that MB Corporate had moved the fire investigation date to 29 May 2025. NOW, what am I suppose to do? It has been almost two months that I have been without a vehicle. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMAT
NHTSA complaint 11661377System malfunctioned detail: 48v battery malfunction, 12v battery malfunction. Safety concern: I was driving on [XXX] , the battery malfunction warning suddenly pop up, and I couldn't accelerate my car beyond 30 MPH, my whole family were on the car during that time. it's life threatening issue needs to be addressed. Luckily we managed to pull over to a safe border way. It's first time I encountered this issue, but on [XXX] , seems like many people encountered it. Dealer is inspecting the issue currently. orange warning msg pop up first says "48v battery malfunction", few minutes later become red warning msg, while I pulled my car to the sideway, it became red "12v battery malfunction". INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint 11634240Vehicle has just over 31k miles. ON multiple occasions, the vehicle randomly shuts off and displays a 48 volt battery error on the screen followed by a check engine light. This has happened in the middle of a busy intersection and at 75mph on the interstate. Each time it does this, I have taken it to a Mercedes dealer for repair/troubleshooting. THey perform the Mercedes required steps to repair the known issue and each time the issue persists. The car has been at a dealership for almost a combined 30 days now with no end in sight. I do not feel safe knowing that Mercedes cant seem to solve the problem and instead puts me back on the road knowing the car is not right and risks injury to my family as the issue has happened at low speed and high speed resulting in extremely dangerous situations for my family. I have 2 open PTSS cases with Mercedes USA (246121906 and 246113294). Researching this issue has revealed this is a known issue with their "mild hybrid" SUVS and many consumers have the same or similar experience to mine.
NHTSA complaint 11624928I was driving only 30mph through my suburban neighborhood bringing my kids to school in the morning when a loud shotgun sound hit my car causing me to be distracted and distraught. My entire sunroof had exploded on me for no reason. Mercedes is currently undergoing a class action lawsuit for this. But since it is not completely yet, I’m being told I need to pay $3700 out of pocket for the default damages and servals days without a vehicle.
NHTSA complaint 11616529Vehicle was purchased pre-owned. Mercedes Me is still associated with previous owner. Mercedes unable to remove association at dealership or on the phone. I can provide bill of sale and identification. Previous owner can remote start, track and control the vehicle I own. This presents a clear and obvious security and safety issue. I am not prepared to drive to *another* dealership and ask *again* to get this done. I own the car and the previous owner can do whatever they like with it. Unacceptable.
NHTSA complaint 11613731Vehicle was purchased pre-owned. Mercedes Me is still associated with previous owner. Mercedes unable to remove association at dealership or on the phone. I can provide bill of sale and identification. Previous owner can remote start, track and control the vehicle I own. This presents a clear and obvious security and safety issue. I am not prepared to drive to *another* dealership and ask *again* to get this done. I own the car and the previous owner can do whatever they like with it. Unacceptable.
NHTSA complaint 116137291. Unknown, smoke started coming from under the passenger side seat, car is a complete loss. 2. Smoke damaged my lungs, there was a large amount of exploding glass, and it could have led to a structure fire. 3. Not applicable 4. In process, but it was recalled for this issue 5. No
NHTSA complaint 11610699Cluster Information Display Black out on and off. Cannot see speedometer and headup display also turns off. Problem occured 5/13/22, 6/17/22, and 6/13/23. Problem is still not fixed after going to mechanic 3 times. 7/16/24 went in to mechanic again for the same problem but mechanic concluded that there are no further solution possible to fix this problem. When the problem occurs, the cluster information display is blacked out for about 3 to 4 hours, and only fixed when 1 or 2 days are fixed. It is dangerous to drive without the cluster display which includes speedometer, remaining gas, engine warning light, and many more important information that is needed and required to drive safely without crash.
NHTSA complaint 11602715I was driving and all of a sudden. The car felt like it was swirling left and right and I was trying my best to straighten the steering wheel, but it felt like I had no control of the car. I eventually hit the median on the road and while all this was happen my dashboard was flashing with all the lights, but my eyes were on the road trying to fix the steering wheel so I don’t know exactly what light was on. When I hit the median, I was finally able to regain full control of the car. It kind of felt like my car was accelerating and swerving at the same time and I was not even stepping on the pedal. I am not sure what caused this, but my car was recently in the shop for some battery issue.
NHTSA complaint 11584224We accepted delivery of our brand new vehicle in May 2021 from the dealer. In July 2021, the vehicle became completely disabled due to failure of the 48 volt battery. In October 2021, the dealer replaced 48 volt battery failed again causing the vehicle to become completely disabled. In December 2023, our 3rd replacement 48 volt battery failed. Each time the vehicle is out of service for a week or longer. The dealer is not providing any information about what may be causing the failures. Vehicle has become completely unreliable and dangerous. Mercedes Benz USA has offered us a 200 service credit and 3,000 off a new vehicle and advised they are not aware of any defects.
NHTSA complaint 11561635The contact owns a 2021 Mercedes-Benz GLS450. The contact received notification of 23V445000 (Fuel System, Gasoline) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time to for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool showed no open recall.
NHTSA complaint 11548412Wipers - I have had repeated issues with the windshield wipers on this vehicle. I have taken it to the dealership 3 times and I have not gotten a satisfactory solution to the issue. The wipers skip across the windshield making intermittent wipers distracting. The dealer's service manager said this is a known issue caused by the OEM wiper blades. I've also been told they can't recommend a solution. AC - The AC in my 2021 GLS 450 smells like moldy socks which makes me suspect there is some build up on the coils or in the vent. I had the vehicle serviced 2 times at the dealership for this issue where the tech informed me the issue was not likely to be resolved by the $500 service I had paid for. The service was discounted down to $307.
NHTSA complaint 11544975The contact owns a 2021 Mercedes-Benz GLS450. The contact stated while driving 40 MPH, the vehicle in front made a sudden stop, causing the contact to make a sudden stop, causing the contact’s children to fall out the seats. The contact notice that the third-row buckle latch had malfunctioned. The vehicle was taken to the dealer and the third-row driver’s side latch was replaced. On another occasion while driving 40 MPH, the contact heard squeaking noise coming from the rear of the vehicle. The vehicle was taken to the dealer for diagnostic test, and the mechanic stated that no failure was found. The manufacturer was contacted, and a case was filed. The failure mileage was 25,000.
NHTSA complaint 11503432My Mercedes has the automatic doors that close. I was closing the driver door with my back to the door and felt my thumb get caught in the drivers door. I attempted to remove it but, could not remove it. I had to watch the door slowly close and seal/crush with my finger smashed within the door. My wife helped me open the door and the top of my finger was smashed, as my wife said, like [XXX]. I went to the emergency room in St Petersburg Florida and as diagnosed with an acute non-displaced fracture through the distal phalanx of the first digit. The door just slowly closed on the finger. if it was a child's hand. wow INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
NHTSA complaint 11503181Mercedes has launch a Campaign Nr 2022010001 Campaign Desc: 21P0699002 in which will retrofit augmented reality camera in 1147 vehicle model year 2021-2022 . My car came without this camera due to the chip shortage during the COVID . I contacted Mercedes Benc USA and the rep told me to contact NHTSA in order to add my car as a part of this Campaign in order to repair this safety future on my car. This camera affect Lane keeping assistance and Lane Departure warning.
NHTSA complaint 11501987On four occasions my car has stalled while in traffic very early in my ownership and then it happened again today with my family in the car and nearly caused an accident. The entire dash lights up with every warning when it happens. Sometimes the check engine light comes on after I shut the car off and restart it. My Mercedes dealer has had it in multiple times for this reason. The last time it was in for this (May of 2022) they "reprogrammed" the entire car. It happening again today has really made me lose a lot of faith in the vehicle, especially since we purchased it for the safety factors. I read online that there are many others who have experienced this. Some say it is related to the 48V battery. I don't care what Make or Model or how expensive it is, a new car should NOT stall in traffic and should be looked into. Thank You.
NHTSA complaint 11500946Repeated failures of 48 volt battery system has shut vehicle totally off while under highspeed and in traffic
NHTSA complaint 11500122Incident 1: May 2022 Vehicle was sitting in driveway overnight and would not start in the morning. Had a 48V battery warning on. Towed to dealership. Said it was a delay software update. Incident 2: August 2022 Was driving 35mpg down the road where a warning sign comes up. Then shortly after the car slows down to around 15mph and would not speed up anymore. Towed to dealership. Dealership did not find anything "wrong" with vehicle Incident 3: November 2022 Car was parked in parking lot for 2 hours. When trying to start car, there was an error message saying stop vehicle. Towed to dealership. Dealership stating they might exchange a new 48V battery.
NHTSA complaint 11492640Car turned on by itself, then 2 days later would not start. 48v battery system needed software update
NHTSA complaint 11490035Technical service bulletins and other notices the manufacturer sent to dealers. A bulletin is not a recall; the 60 most recent are listed.