2022 Hyundai Palisade

309 complaints on file, page 1 of 16.

1. Filed Oct 1, 2026Failure Sep 2, 2026Carlisle, PAEngine, Fuel/propulsion system, Power train

   Component Affected: FUEL SYSTEM, GASOLINE: DELIVERY: HIGH PRESSURE PUMP Description of the Safety Hazard: My 2022 Hyundai Palisade has developed a catastrophic failure of the engine-mounted High-Pressure Fuel Pump (HPFP). The insulating foam cover is completely saturated and leaking raw, liquid gasoline directly on top of the engine block. The fuel system is unable to maintain rail pressure, causing severe pre-detonation engine knock ("pinging") and mechanical stumbling during acceleration. Furthermore, there are visible electrical flashes/short-circuit arcs occurring in the engine bay directly adjacent to the high-pressure liquid fuel leak, presenting an imminent vehicle fire hazard. Active dark fluid puddles contaminated with fuel are dripping past the splash shields onto the ground. Dealer/Manufacturer Actions: Despite clear photographic evidence of a pressurized fuel leak on a powertrain-covered component, multiple authorized Hyundai dealerships (Fred Beans, Harrisburg, and Chambersburg) have refused service or grossly misdiagnosed the life-threatening safety issue as a 'gas cap' or 'water hose.' Hyundai Motor America Corporate Consumer Assistance has failed to intervene or provide emergency towing remediation for this severe fire risk.

   NHTSA complaint 11768421
2. Filed Oct 1, 2026Failure Jun 1, 2024Cumming, GABody, Unknown or other

   Door handle peeling or chipping. The metal is sharp and have warn every person that works on my vehicle. I have spoke to dealership while back they stated that it would not be fixed. On my previous vehicle same thing had happen and the dealership replace even though I was a secondary owner. This vehicle in question I have been primary care owner. Before someone cuts them self with sharp metal or coating that is off on a door handle where you open the door is concerning.

   NHTSA complaint 11768386
3. Filed Sep 30, 2026Failure Sep 30, 2026Bellaire, MISteering

   Was driving down our road and when we came to turn onto the main road the vehicle would not turn. Backed up to avoid traffic then tried proceeding forward again and would not turn or was only turning very little that it did not make a difference. After a few attempts, powered the vehicle off then back on and all of a sudden could turn the wheel again l.

   NHTSA complaint 11768149
4. Filed Sep 20, 2026Failure Sep 20, 2026Dumas, TXAdaptive cruise control, Service brakesCrash

   I was driving to work, at a rate of 75 mph (permitted speed limit). As I approached an intersection, I tapped the brakes to turn off the cruise control. It did not turn off. I then pressed the brake pedal and it went further down than normal. The vehicle did not appear to even try and slow down or brake. I tried again, standing on the brakes with both feet. At this point, I knew I would not be stopping, as the pedal continued to feel strange, and not catching for lack of better terms. I did my best to steer around two sign poles directly in my path. Unfortunately due to not being able to control speed, I did hit one. I then continued on for approximately and 1/8 of a mile before my car finally came to a stop in the middle of a dirt field. I do not know if this was a software or mechanical issue with the brakes. I only know they did not work when needed, under normal circumstances.

   NHTSA complaint 11765683
5. Filed Sep 17, 2026Failure Sep 17, 2026Topeka, KSVisibility/wiper

   The sunroof spontaneously broke while driving on the interstate at an estimated speed of 70 mph. There was no severe weather issues or traffic issues. Glass did make it into the car, in both the drivers and passenger seat. Unsure if it made it to the back seat where a [XXX] baby was in a car seat. Called McCarthy Hyundai and they told us to take it somewhere else that it was not under warranty. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

   NHTSA complaint 11764940
6. Filed Sep 16, 2026Failure Aug 28, 2026Aztec, NMSeat belts

   This vehicle has had an open recall for seat belts for over a year. We have had issues with the seat belts and stated that to our local hyundai shop in Farmington, NM multiple times. Even when the car has been in for other things. The only thing they can tell us is that the seatbelts are on backorder and they do not know when they will be in. Then they give us a print out stating the vehicle has an open recall. Like really, we know that you can't seem to fix it. My daughter who should still be in a booster seat is unable to use a booster due to the seat belts coming undone sometimes when buckling them if we use a booster. I feel like with a safety recall like this, if you can't get the seat belts in the cars that are already on the road, mabe the manufacturer does not need to be producing new cars as they too require seat belts. I put in the most recent date we were told the belts were on order in the date occurred.

   NHTSA complaint 11764840
7. Filed Sep 16, 2026Failure Sep 5, 2026Spring, TXAutomatic emergency braking, Service brakes

   Labor Day weekend I was two hours away from home. Before leaving town my automatic collision breaking system decided to go off and start breaking. There was absolutely no one in front of me. The entire weekend about seven or eight times my vehicle put me in extreme danger going at all speeds putting myself in my Assistan danger of dying and flying through the windshield. When I got back to town and made an appointment at North Freeway, Hyundai in Spring they lied and claimed there was front and damage and that the bracket was loose. I have absolutely no front end damage I have included pictures for some reason if they don’t work your system is having issues. Their pictures they took are completely blown out and white and look like it needs an exorcism. I have clear photos of my vehicle there was absolutely no incident or damaged to have any issues with my vehicle . I have been an extreme danger and had to turn it off in order to drive home. I have made several attempts to contact the service manager and he cannot be bothered to contact me it is apparently above him and his Pay grade. I have contacted Hyundai personally and they are working on it on their end but overall it’s up to the dealership

   NHTSA complaint 11764836
8. Filed Aug 19, 2026Failure May 23, 202680,000 milesGlen Burnie, MD12v/24v/48v battery, Engine

   The contact owns a 2022 Hyundai Palisade. The contact stated that while driving at an undisclosed speed, the vehicle stalled and shifted into park independently. The contact stated that there was smoke coming from the engine compartment. The check engine, battery, oil, and another unknown warning light were illuminated. The failure had occurred on several occasions. The vehicle was taken to a dealer to be diagnosed; however, the cause of the failure was not yet determined. The dealer stated that an oil leak was found; however, there was no oil in the engine. The vehicle was not repaired. The vehicle was taken to another dealer, Antwerpen Hyundai Clarksville (12440 Auto Dr Clarksville, MD 21029) to be diagnosed; however, the cause of the failure was not yet determined. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 80,000.

   NHTSA complaint 11758085
9. Filed Aug 19, 2026Failure Jul 9, 202670,000 milesEast Orange, NJEngine

   The contact owns a 2022 Hyundai Palisade. The contact stated that while driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. The contact stated that several unknown warning lights were illuminated, and the engine seized. The contact stated that while attempting to start the vehicle, the vehicle started. The vehicle was taken to the dealer. In addition, the unknown warning lights were off. The failure was not duplicated. The contact stated that the vehicle was taken to the dealer three times within a month. The failure was intermittent. The manufacturer was made aware of the failure. The failure mileage was approximately 70,000.

   NHTSA complaint 11758043
10. Filed Aug 18, 2026Failure Jun 1, 2026Ooltewah, TNUnknown or other, Vehicle speed control

    I was driving the 2022 Palisade at 65 miles an hour on busy interstate when it suddenly shifted down to 5 miles per hour. I was almost back ended and sideswiped as I tried to get from middle lane to side of interstate. I had 3 grandchildren in car at the time. I had this vehicle in for repair at Hyundai dealership twice before this incident and was told just bad gas and keep driving it. Another incident before was at 4 way stop in GA where I started after stop and car completely stopped and a gentleman also broadsided me. Again told bad gas. After taking car in for repair again, I was told total transmission failure at 108000 miles.

    NHTSA complaint 11757792
11. Filed Aug 18, 2026Failure Sep 11, 2025Round Lake Beach, ILAir bags, Seat belts

    The contact owns a 2022 Hyundai Palisade. The contact received notifications of NHTSA Campaign Numbers: 25V607000 (Seat Belts) and 26V034000 (Air Bags); however, the parts to do the recall repairs were unavailable. The contact stated the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was contacted; however, the parts for the recall repairs were not available. The manufacturer was made aware of the issue. The contact had not experienced a failure.

    NHTSA complaint 11757691
12. Filed Aug 13, 2026Failure Aug 13, 2026Fredericksburg, VAEngine

    Vehicle: 2022 Hyundai Palisade, approximately 78,000 miles. The vehicle has experienced a recurring engine/powertrain malfunction involving engine stalling, hesitation/rough operation, startup rattling, cylinder air/fuel imbalance, and misfires. The exact failed component is currently UNKNOWN. The vehicle is available for inspection upon request. The vehicle has stalled at low speeds, creating a safety concern because the engine can unexpectedly shut off or lose power while the vehicle is being operated in traffic. Unexpected stalling could leave the vehicle without normal acceleration when entering or crossing traffic and creates a risk of a collision involving the occupants or other motorists.The vehicle has been evaluated and serviced by a Hyundai dealership for engine-related concerns. Diagnostic trouble codes associated with these problems have included P000C, P219D, P219F, P21A0, and P0302. Of particular concern, P219D, indicating a Cylinder 2 air/fuel ratio imbalance, has occurred repeatedly, and the vehicle subsequently generated P0302, indicating a Cylinder 2 misfire. This suggests a recurring problem involving the same cylinder, although the underlying cause remains UNKNOWN.Previous repair efforts have included work involving the vehicle's VVT system, but the engine-related problems and diagnostic codes have continued/recurred. The vehicle/component has been inspected by a Hyundai dealership. To my knowledge, it has not been separately inspected by police, insurance representatives, or NHTSA. Whether Hyundai corporate/manufacturer representatives have directly inspected the vehicle is UNKNOWN.Prior to and during these incidents, symptoms included the check-engine warning light, startup rattling/noise, engine hesitation/rough operation, and stalling at low speeds. Diagnostic codes were stored when the check-engine light appeared. The problems have occurred on more than 100 occasion rather than being a single isolated incident.

    NHTSA complaint 11756824
13. Filed Aug 4, 2026Failure Dec 28, 202228,000 milesBowie, MDSpeedometer/odometer, Engine, Seats

    The contact owns a 2022 Hyundai Palisade. The contact stated that while driving 70 MPH, the vehicle unexpectedly decelerated. The contact stated that there was an abnormal sound coming from the engine compartment. No warning lights were illuminated. The contact stated that the vehicle was consuming engine oil. The contact stated that 2–3 quarts of oil needed to be added in between scheduled oil changes. The instrument cluster independently blanked and turned on and off. Additionally, the front driver's side seat belt failed to latch as intended, and the second-row seats failed to adjust as intended. The contact stated that when the seat adjustment switch was pushed to move the seat forward, the seat was stuck in the middle. The failures occurred intermittently since the vehicle was purchased. The vehicle was taken to the dealer where the vehicle was purchased; however, the vehicle was not diagnosed or repaired. The vehicle was taken to several alternate dealers; however, the vehicle was not diagnosed or repaired. The vehicle was taken to another dealer where it was diagnosed with radiator failure. The contact was informed that the radiator needed to be replaced. The vehicle was repaired. The contact was informed that no other failures were found. The contact received notifications of NHTSA Campaign Number: 26V034000 (Air Bags) and 25V607000 (Seat Belts). The manufacturer was made aware of the failure, and several cases were filed. The contact requested a vehicle buyback; however, the request was denied. The failure mileage was approximately 28,000.

    NHTSA complaint 11754745
14. Filed Jul 29, 2026Failure Jul 10, 2026Phoenix, AZUnknown or other

    We purchased this used 2022 Hyundai Palisade SLE vehicle on XXX at a Nissan dealership with 95,492 miles. While my spouse was driving the vehicle on the highway on XXX the failed child safety lock alarm notification displayed on the screen and the 2nd row actuators began flicking on and off, like it was exorcist. My [XXX] toddler with special needs rides in the back so we were concerned the doors might pop open if they were not locking properly. We took picture of the alarm display. The next day XXX, before we signed the sales contract , we informed the dealership of the safety hazard. They proceeded to take vehicle back and we hav a loaner vehicle in the meantime. After a week, we were informed that the Hyundai dealership did not find anything wrong with the door locks. When we proceeded to pick up the Palisade on XXX, we were able to recreate the problem right away before even driving the vehicle. All we did was unlock the suv, and when we attempted to open the back doors, the actuators kept clicking on and off on both doors on the 2nd row of the suv. We again told the dealership that it was re-occurring. I emailed and texted pictures and video to the sales representative Carlos Cortez, the finance rep Ruben Mendoza and the service manager Mike Moore. Mike contacted me next day early morning via telephone, they could not recreate the problem and would consult with a Mastertech. I explained that all we did was unlock the suv with the fab and tried opening the 2nd row door manually and the exorcist possession of the actuators reocurred. I also emailed him the Palisade Forum weblink: [XXX] that shows that shows that this is occurring to many other Palisade and Santa Fe owners and they have been some repairs done such as replacing wiring harness , actuators and windows to fix the problem. SUV is still at the dealership. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

    NHTSA complaint 11753586
15. Filed Jul 23, 2026Failure Jul 22, 2026Valrico, FLAutomatic emergency braking, Service brakesCrash

    On 7/22/26 at about 5:15pm, I was operating my vehicle, a 2022 Hyundai Palisade in the Parking lot of Publix Supermarket at Valrico Commons and was attempting to enter a parking space. I made a right from the parking thruway to enter a right parking space. I felt one of the right wheels graze the pedestrian sidewalk as I was driving about 5 miles per hour, next thing the vehicle lunged forward out of control and though I tried applying the brakes, the brakes would not respond. As a result, my vehicle ending up hitting a parking pole, which resulted in two vehicles parked opposite to me being hit by the pole. There was no one in the parked vehicles.

    NHTSA complaint 11752389
16. Filed Jul 22, 2026Failure Jul 22, 2026Chesapeake, VASeat belts

    SUMMARY Filing complaint under 49 U.S.C. § 30120 against Hyundai Motor America & Checkered Flag Hyundai for failure to remedy a seatbelt defect in reasonable time, misallocating parts, and refusing escalation. Seatbelts randomly unlatch while driving with my family, posing fatality risk in a collision. CHRONOLOGY • Dec 2025: Requested repair; dealer cited backorder. • Apr 2026: Opened Hyundai Corporate case due to delay. • Mid-June 2026: Corporate stated parts arrived at dealer. • July 3, 2026: Left car all day for appointment. At pickup, dealer stated parts were NOT in stock; no repair done. • July 13, 2026: Emailed Rep Nasim demanding supervisor escalation, timeline, and giving NHTSA notice. • July 22, 2026: - Nasim called stating parts arrived; agreed to hold parts at dealer. - Joy (Parts) confirmed parts in stock; agreed to label box with my name. - <1 Min Later: Crystal (Service) stated parts were NOT available, revealing 3 arrived but were given away. Stated Parts Mgr Brian would call back. Called Joy back; sent to unreachable voicemail. - Nasim refused supervisor escalation, claiming no way exists to escalate the recall issue itself, but offered to re-escalate parts. Refused compensation claiming car is "drivable" despite unlatching. Denied call logs. VIOLATIONS 1. Exceeded 8 months without remedy for restraint failure. 2. Verified parts in stock with Parts (Joy), contradicted <1 min later by Service (Crystal) stating parts were given away. 3. Rep Nasim refused supervisor escalation on recall handling, claiming no way exists to escalate recall issues. 4. Misclassified active unlatching failure as "drivable." REQUESTED NHTSA ACTION 1. ODI Investigation into recall parts handling & escalation refusals. 2. Direct Hyundai to execute immediate repairs AND provide financial compensation for 8+ months of hazard exposure.

    NHTSA complaint 11752076
17. Filed Jul 21, 2026Failure Jul 20, 2026Moreno Valley, CAEngine, Power train

    My wife was driving the vehicle to work this morning XXX around 730am on the [XXX] near [XXX] and the vehicle just cut off while driving at high speed. All the lights were activated on the dashboard. The steering wheel locked, the brakes stopped working, and the car would not accelerate. The vehicle died mid drive placing her in a dangerous life threatening predicament within this heavily trucked corridor. She was left to block traffic until help arrived. The vehicle was towed to the Hyundai dealership on Eucalyptus in Moreno Valley. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

    NHTSA complaint 11751710
18. Filed Jul 16, 2026Failure Jul 11, 2026Troy, MOVisibility/wiper

    We were driving down the road and heard a loud pop and then heard glass falling onto the sunroof sunshade. My sunroom exploded out of nowhere, nobody in front of me, no trees or structures above us. Just spontaneously shattered.

    NHTSA complaint 11750967
19. Filed Jul 16, 2026Failure Apr 17, 2026Slidell, LAEngine, Power train

    On April 17, 2026, while driving my 2022 Hyundai Palisade with approximately 167,000 miles, the vehicle suddenly lost engine power and was unable to maintain normal driving speed. The sudden loss of propulsion created a safety risk because the vehicle could no longer operate normally in traffic. I was able to move the vehicle out of traffic, but it would not restart. I also observed white smoke coming from the engine compartment. The vehicle was towed to Matt Bowers Hyundai Slidell, an authorized Hyundai dealership, where it remains and is available for inspection upon request. The dealership has inspected the vehicle and advised that the engine needs to be replaced. The exact internal component that failed and the final cause of the engine failure remain under review by Hyundai. I do not recall any warning lamps or messages before the sudden failure. The timing of any prior symptoms is UNKNOWN. The vehicle had been maintained through authorized Hyundai dealerships. On December 29, 2025, a Hyundai dealership replaced the oil filter housing because of an oil leak and performed a synthetic oil and oil filter change. On March 11, 2026, approximately five weeks before the failure, the dealership performed another oil and oil-filter change and a multipoint inspection. I am reporting this incident because the sudden loss of engine power while driving, the inability to restart, and the smoke from the engine compartment created a serious safety concern. The vehicle remains disabled and available for further inspection.

    NHTSA complaint 11750892
20. Filed Jul 15, 2026Failure Feb 15, 2026shawboro, NCEngine

    My car is consuming too much oil. I am going through almost 2 qts per 1,000 miles. Combustion cleaning and consumption test have been completed with no fix to the problem.

    NHTSA complaint 11750527