2021 Ram Promaster

111 complaints on file, page 1 of 6.

1. Filed Sep 29, 2026Failure Dec 30, 2025Victor, NYEngine, Power train, Steering

   Alternator belt issues. Chassis belt broke 2 times . House, under hood generator alternator belt broke one. First time there was no warning. But resulted in lose of power steering and coolant. Cut into the coolant hose. A clean break break, not shredded. Second time on start there no warning until the engine over heated and smoke poured from the engine compartment. Belt was shredded. Third time the second alternator belt broke . I was on the the thruway. I heard a flapping noice. The RV was not steering right. I exited the thruway . The engine started smoking . Drove to a safe place to park. Dash lights were on . Opened hood and the coolant resivore was empty , coolant all over the engine. The second alternator belt was shredded. It was inspected by the dealership I purchased it from . The company who replaced the first 2 breaks and a Dodge dealership. It is available for inspection at the dodge dealership.

   NHTSA complaint 11767708
2. Filed Sep 24, 2026Failure Sep 21, 2026Hadley, NYPower train

   My 2021 Ram ProMaster experienced transmission failure and became inoperable. It is subject to Safety Recall 44A/NHTSA 23V-301 involving the 62TE transmission. Before going to Ram, an independent repair facility removed the transmission pan and documented burnt fluid and substantial metallic debris/shavings. The van was then TOWED to an authorized Ram dealer specifically because of the transmission failure and recall. Importantly, the PCM software update had NOT been performed before the failure. Ram performed the update only AFTER the transmission had already failed and metal had been documented. FCA originally identified the software update as an INTERIM repair that did not complete the recall. The current remedy includes PCM updating AND inspection and, if necessary, replacement of the transmission/components. I informed the service manager of the documented metal and offered the independent shop's findings. He said he would not accept the finding because he had not personally inspected it, yet refused to further evaluate the transmission under the recall unless I authorized approximately $500 in customer-paid diagnosis. He repeatedly complained that Stellantis only pays approximately 1/2 hour for the recall. After updating the PCM, the dealer drove the van approximately one mile. The manager acknowledged a transmission issue and abnormal noise and suggested it “may be a pump,” but still did not inspect the documented internal debris. He stated that because the van still moves in reverse, transmission replacement is not warranted under the recall. I was instructed to retrieve the vehicle with the transmission issue unresolved. I have also opened a case with Ram/Stellantis. I request NHTSA review whether Recall 44A was properly completed when the transmission had already failed before the software update, metallic debris was documented, and the dealer declined further recall evaluation without customer-paid diagnosis.

   NHTSA complaint 11766627
3. Filed Sep 7, 2026Failure Sep 1, 2026Ruskin, FLFuel/propulsion system

   The fuel tank is leaking where the fuel tube goes into the tank. The seal starts to leak and they do not make a replacement seal, you have to replace the entire fuel tank. This is the 2nd Promaster van that I have had and the 2nd time this has happened. This is dangerous to have fuel leaking from the front of the vehicle. This is a poor design, it’s a very common problem with these vehicles that still hasn’t been addressed. It’s also an expensive problem because the tank costs $1300 without labor, and you just can’t buy the gasket itself you have to buy the whole tank.

   NHTSA complaint 11762540
4. Filed Aug 17, 2026Failure Aug 17, 2026Livermore, CABack over prevention

   The contact owns a 2021 Ram Promaster 3500. The contact received notification of NHTSA Campaign Number: 25V552000 (Back Over Prevention). The vehicle was taken to the dealer; however, the dealer declined to complete the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure.

   NHTSA complaint 11757496
5. Filed Aug 11, 2026Failure Aug 11, 2026Sarasota, FLFuel/propulsion system

   fuel tank leaking gasoline. vapors and liquid gasoline leaking from fuel tank

   NHTSA complaint 11756268
6. Filed Jul 27, 2026Failure May 15, 2026Fredon Township, NJPower train, Service brakes, Suspension

   Vehicle experienced severe, premature component failures posing direct safety hazards while operating a commercial work van: 1. Parking Brake Seizure (01/25/2025 @ 49,197 miles): The parking brake pivot assembly completely seized, causing the rear brake assembly to lock up and rendering the vehicle unsafe to operate on public roads. Replaced under Invoice #CHCS490962. 2. Catastrophic Transmission & Drivetrain Failure (05/15/2026 @ 66,082 miles): The transmission suffered recurring fluid leaks beginning at 49,197 miles (pan leak reseal) and 51,648 miles (complete front pump replacement). At 66,082 miles, the transmission suffered complete internal failure (burnt fluid, clutch metal material), resulting in total loss of reverse power and gear slipping while operating. Both front strut mounts failed on the same visit. Experiencing brake lockup and sudden total loss of transmission control under 66,000 miles on a commercial vehicle presents significant safety risks to vehicle operators and traffic.

   NHTSA complaint 11753014
7. Filed Jul 24, 2026Failure Feb 1, 2026Omaha, NEEngine

   The specific issue you are dealing with is Chrysler Recall 67C (NHTSA Campaign 25V720). This recall impacts nearly 300,000 Ram ProMaster vans (model years 2018–2026) due to an overheating radiator cooling fan circuit that poses a significant vehicle fire risk. More than 200 of these are from the VA. Edwards Auto Group In Council Bluffs, IA is trying to make the Veterans Health Administration pay labor for a safety recall that is stated above. I am reporting them because it is a safety recall and we should not have to pay for extra cost such as a 2x4. Please see below. It is my understanding that the Dealer is in the wrong here. •Absolute Free Labor: Dealerships enter franchise contracts with the manufacturer requiring them to execute recall repairs for free. Chrysler (FCA US LLC) is legally obligated to provide the instructions and billable labor hours to the dealership. •The "2x4" Tool Excuse: If a manufacturer's official technical service bulletin specifies a specific physical manipulation or tool—even a makeshift one like a 2x4—to complete the repair, that labor time is factored into the flat-rate time Chrysler pays the dealer. The dealer cannot pass "difficult labor" or tool costs onto you. •No Deductibles or Add-ons: A dealer cannot apply any separate fees or surcharges to offset their operational challenges while resolving a safety defect.

   NHTSA complaint 11752567
8. Filed Jun 26, 2026Failure May 27, 202680,000 milesVallejo, CABack over prevention

   The contact owns a 2021 Ram Promaster 2500. The contact received notification of NHTSA Campaign Number: 25V552000 (Back Over Prevention); however, the part to do the recall repair was not yet available. The local dealer was contacted; however, the vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact stated that the rearview camera displayed a distorted image. The approximate failure mileage was 80,000.

   NHTSA complaint 11746715
9. Filed Jun 23, 2026Failure Jun 23, 2026Andalusia, ALBack over prevention, Engine and engine cooling

   The contact owns a 2021 Ram Promaster 1500. The contact received notifications of NHTSA Campaign Number: 25V552000 (Back Over Prevention) and 25V720000 (Engine and Engine Cooling); however, the parts for the recall repairs were unavailable. The dealer was contacted, and the contact was informed that parts were not yet available. The manufacturer was contacted, and the contact was informed that parts were not yet available. The contact had not experienced a failure.

   NHTSA complaint 11745891
10. Filed Jun 11, 2026Failure Aug 26, 202537,000 milesCharlotte, NCBack over prevention

    The contact owns a 2021 Ram Promaster 3500. The contact stated that while in reverse(R), the rearview camera was inoperable, with the message "Backup Camera Not Available" displayed. The contact stated that the failure had rendered the back over prevention safety system inoperable, depriving the driver of crucial rear visibility while reversing a large commercial van. The contact received notification of NHTSA Campaign Number: 25V552000(Back Over Prevention); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure. The failure mileage was 37,000.

    NHTSA complaint 11743581
11. Filed May 27, 2026Failure Aug 5, 2025Hurst, TXBack over prevention

    The contact owns a 2021 RAM 1500. The contact received notification of NHTSA Campaign Number: 25V552000 (BACK OVER PREVENTION) however, the part to do the repair was unavailable. The contact mention he has had several issues with the vehicle on the freeway and bridge where the vehicle stalled while driving at any unknown speed. The contact stated that several dealers were contacted and informed him that the parts were no longer available. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue, and they informed him there is currently no remedy. The contact had not experienced a failure.

    NHTSA complaint 11740424
12. Filed May 26, 2026Failure May 16, 2026Mendon, NYIntegrated starter(other than propulsion), Recreational vehicle/trailer, Fuel system, Other

    I had NHTSA recall for this generator done (23E-030) which was to solve the same problem I just had. Apparently, they just moved to a smaller diameter fuel line to fit the fuel pump better. However, this hose also came off my Cummins generator fuel pump and was spewing gas all over the generator and the ground when we ran it. This is a very unsafe condition and I'm surprised, after the recall was performed by a certified Cummins dealer (verified by Cummins) that this "new" fuel line has also come off the fuel pump.

    NHTSA complaint 11740172
13. Filed May 21, 2026Failure Dec 9, 2025San Antonio, FLPower train, Suspension, Wheels

    While driving, the vehicle experienced a sudden and complete loss of motive power without warning. The driver coasted off the road into a swale and required a tow to an authorized RAM dealer, December 9 2025 to CDJR of Tampa Bay, Tampa FL. The dealer initially indicated the failure was covered under Recall 44A, then changed their position and characterized it as a powertrain warranty repair. Following that repair the vehicle was returned immediately in January 2026 when it would not engage reverse. In May 2026 the vehicle experienced a CV joint failure at 20,411 miles — approximately 1,000 miles after the January repair. The RAM ProMaster 3500 is front wheel drive and CV joints connect directly to the transmission. The recurring failures following the repair present a serious safety concern. The December repair receipt is 10 pages and January is 5 the unit is currently at an authorized mopar shop. Please let us know if you require those receipts.

    NHTSA complaint 11739413
14. Filed May 8, 2026Failure Aug 19, 2025Spokane, WABack over prevention

    The contact owns a 2021 Ram 3500 Promaster. The contact received notifications of NHTSA campaign numbers: 25V552000 (BACK OVER PREVENTION) and 25V552000 (BACK OVER PREVENTION). However, the parts to do the recall repair were not yet available. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. The contact stated that he is unable to rent the vehicles due to the recall.

    NHTSA complaint 11736522
15. Filed May 8, 2026Failure Aug 19, 2025Spokane, WABack over prevention

    The contact owns a 2021 Ram 3500 Promaster. The contact received notifications of NHTSA campaign numbers: 25V552000 (BACK OVER PREVENTION) and 25V552000 (BACK OVER PREVENTION). However, the parts to do the recall repair were not yet available. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. The contact stated that he is unable to rent the vehicles due to the recall.

    NHTSA complaint 11736521
16. Filed May 7, 2026Failure Apr 29, 2026Friendswood, TXPower train, Unknown or other, Vehicle speed control

    12/2020 First the TPS sensor failed at 1,000 miles and almost caused an accident. Would not go over 25mph, was shifting hard, and the service engine light was on. Verified and replaced at dealership. Second, the rear view camera stopped working while backing up and almost caused an accident - no back windows - major safety issue. Replaced by me as they have no replacement for it even though its under recall. No warnings. Third, the transmission was shifting hard and fell out while I was driving on the freeway at 55,000. Damaged transmission and crankshaft and joints. Verified and replaced at dealership. No warnings, no lights Fourth, the transmission bolt was found loose, hard shifts, and has an internal breakdown at 71,000 miles. Verified first by independent shop - they tightened the bolt for me and is now sitting at the dealership waiting on another transmission that has been verified and approved under warranty. No warnings, no lights

    NHTSA complaint 11736324
17. Filed Apr 28, 2026Failure Apr 11, 2025Turlock, CAUnknown or other

    I have had ongoing issues with the backup camera not related to current recall 25v-552. The image on the dash screen would flip between upside down and right side up. It still the flipped image after being “fixed”. After the dealership “fixed” that problem, it would flip and reverse the image. That was subsequently “fixed” by replacing the dash monitor. However, the poor picture quality during both day and night makes the camera unsafe to use. During the day the image may be completely or partially whited out with glare. At night there are lines and distortion across the screen. In. Addition, the new unit does not monitor van diagnostic information which could impact safety. The van is currently back in shop for another attempt to fix camera system.

    NHTSA complaint 11734434
18. Filed Apr 12, 2026Failure Aug 26, 2025Fort Lauderdale, FLWarnings, Electrical system

    My 2021 Ram ProMaster 2500 has two open safety recalls with no remedy available: NHTSA Recall 25V-552 (rearview camera FMVSS 111 compliance issue) issued August 26, 2025 NHTSA Recall 25V-720 (cooling fan fire risk) issued October 23, 2025 As of April 2026, no remedy has been provided for either recall. The vehicle is used commercially for rental income, and the lack of a repair has caused financial loss of approximately $500–$1,000 per month. One of the recalls involves a potential vehicle fire risk. The prolonged delay without a remedy is concerning for both safety and financial reasons.

    NHTSA complaint 11730629
19. Filed Mar 31, 2026Failure Feb 2, 2025Boulder, COUnknown or other

    The backup camera failed and the screen is black with an error message. In a large cargo van it becomes nearly impossible to see behind you. The problem was reported to the RAM dealer in Broomfield, they inspected the camera and agreed it needed to be replaced. This issue had been going on for a full year at least.

    NHTSA complaint 11728228
20. Filed Mar 25, 2026Failure Feb 14, 2026Knoxville, TNEngine, Power train, Unknown or other

    On [XXX], while driving my 2021 Ram ProMaster 2500 at highway speed in Florida, the van suddenly lost all power and came to a near stop, then re-engaged. Vehicles were in front and behind me, creating an immediate risk of serious collision, injury, or death. I pulled over ~30 minutes, restarted, but it could not exceed 20 mph while RPMs were high. AutoZone confirmed limp mode and advised a dealer. I drove it home to Port Charlotte, then had it towed to Gettel Dodge Chrysler Jeep Ram, Punta Gorda, FL, where after two weeks it was diagnosed with a failed transmission requiring replacement. The transmission can be inspected at the dealership. No warning lamps appeared before failure. Problem confirmed by AutoZone and the dealer. I contacted Stellantis (Case #[XXXX], contact Regina Knox; dealership contact Noel), but repair assistance was denied. The van also has two active recalls, including risk of rolling out of park, unremedied. This transmission failure constitutes a serious and imminent safety defect, creating a hazard to myself and the public. I request NHTSA investigate this defect, compel Stellantis to repair it at their cost, and consider any further regulatory action necessary to prevent injury or death. Vehicle info: 2021 Ram ProMaster 2500, 130,000 miles, VIN [XXX] . INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

    NHTSA complaint 11727047