2021 Tesla Model X

41 complaints on file, page 1 of 3.

1. Filed Sep 17, 2026Failure Jul 11, 2025Plymouth, MNElectrical system, Adaptive cruise control, Steering

   While driving the car the dash board lit up with several failures related to auto pilot and auto steering. The car would not engage auto pilot or cruise control and the dashboard showed messages that the car driver assist has failed, lane departure warning, blind spot warning and required immidiate service. Per Tesla, the problem was with the steering rack and had to be replaced and was not covered by any warranty.

   NHTSA complaint 11765058
2. Filed Aug 27, 2026Failure Aug 26, 2026Winston-Salem, NCUnknown or other, Vehicle speed control

   Please see attached letter to Tesla outlining issues.

   NHTSA complaint 11760103
3. Filed May 31, 2026Failure May 20, 2022Boca Rotaon, FLBody

   Both Garnish - Fender - Front - LH Right side and Left side come loose when driving in rain. The force of wheels pushing rain water on the fender garnish causes both the left and right fender garnish 4 push clips to come loose. When this fender garnish breaks and flies off it could hit a pedestrian, another car on the road or the car it is installed on causing an accident

   NHTSA complaint 11741161
4. Filed Oct 24, 2025Failure Sep 26, 2025Stafford, VASteering

   Steering got stuck on the road while driving. I couldnt move or change lanes. It was really scary. Then I slowed down and then I had tp pull out of the road to the shoulder. Then I waited for 20-30 mins and restarted the car. Then it worked. I was able to go home. I contacted Tesla and they said they need to look into the issue. At the service center, now they are saying they need to replace entire steering system and the cost is 5000. This is not fair and unprofessional. And it is very scary experience.

   NHTSA complaint 11695485
5. Filed Oct 21, 2025Failure Oct 1, 2025Balboa Island, CASteering

   Heavy steering warning. Steering gear left hand drive.

   NHTSA complaint 11694883
6. Filed Aug 26, 2025Failure Jun 2, 2025Oakland, CAElectrical system, Latch

   While driving our screen shut down, autopilot and GPS stopped working and the doors would not open. My kids were stuck on multiple occasions and had to climb through the front seats. Tesla has already confirmed that the Driver Assistance System ECU (Turbo A and Turbo B processors) is a known issue. Over 1600 cases reported. This defect disables safety-critical driver-assist functions without warning, which meets the federal definition of a safety defect under 49 U.S.C. § 30102. Provide a free remedy to owners — including replacement at no cost — as required by 49 U.S.C. § 30120. Telsa denied coverage because we are out of warranty. I asked whether the known issue has been reported and why it is not being covered as a known safety defect. Because the problem involves loss of a safety system, it should not be treated as routine maintenance or wear and tear. It is a known safety defect and therefore must be reported and remedied at Tesla’s expense. Tesla refuse to address my concern and would only let me talk to store manager. They told me I had to email business resolutions to get more information. I have not heard back. I was forced to spend $2k to get my car fixed

   NHTSA complaint 11683268
7. Filed Jul 17, 2025Failure Jul 10, 2025Denton, TXSteering

   After completing a 17.5-hour, ~1,000-mile non-stop road trip from Florida to Texas using Autopilot with no interventions or issues, the following week this vehicle experienced a sudden and total steering failure while slowly turning through my residential neighborhood. The steering locked up without warning and caused the car to drift partially into the opposing lane. No power steering warning was shown prior to the failure. Tesla Service diagnosed and replaced both the Front Body Controller (Part #1585663-00-C) and the Steering Gear Assembly (Part #1070801-00-F) under warranty. This is an extremely dangerous failure scenario — had it occurred at high speed, the outcome could have been catastrophic. I am reporting this to ensure it’s documented and investigated, as it appears consistent with similar steering failure complaints in 2021+ Model X vehicles.

   NHTSA complaint 11674412
8. Filed Jul 9, 2025Failure Jul 7, 2025Olympia, WAUnknown or other

   Driving speed limit of 50 miles an hour on a two lane road and went to push the accelerator pedal and the entire assembly snapped completely off and was unable to continue driving the car

   NHTSA complaint 11672170
9. Filed Jun 20, 2025Failure Dec 4, 2024Tampa, FLSuspension

   Summary: The front suspension defect on my 2021 Model X, confirmed by St. Petersburg Service Center (Invoice #3000S0013156326), presents a serious safety hazard. Timeline & Concern: Reported Dec 4, 2024, under ESA. Example of Tesla’s delay tactics—service was scheduled only after warranty lapsed. Issue diagnosed in May 2025 as a faulty front upper control arm. Safety risk: Failure could lead to loss of control. I request a safety investigation to prevent similar unsafe compromises.

   NHTSA complaint 11668235
10. Filed Jun 20, 2025Failure Jun 17, 2025San Clemente, CAWarning, Assist, Steering

    My car has 50,000 miles on it and is just over 4 years old. The steering column has failed causing it to not be able to steer. The service for this is a new steering column at a cost of over $5,000.00. The Y models and 3 models had a recall on this issue. Now it looks like the X models are having the issue as well. The consumer should not be responsible for this. It is dangerous. It is expensive to fix. A steering column should not fail at 50,000 miles. I am not the only person who has been faced with this issue. Tesla service even confirmed that they are seeing this on the X models. I think an investigation should be done. How many $5,000.00 repairs for safety has the consumer been saddled with?

    NHTSA complaint 11668225
11. Filed Jun 2, 2025Failure Jun 2, 2025Murrieta, CASteering

    Steering assist error code. Car has less than 25,000 miles and Tesla is reporting this is common and the steering rack needs to be replaced and the steering gear left hand drive. Tesla Temecula also said there was a system malfunction that caused it but they do not dig into that they just do the service for $5100. Looking online this is common.

    NHTSA complaint 11664453
12. Filed May 6, 2025Failure May 6, 2025Berkeley, CABody

    My 2021 Tesla Model X has a serious safety issue with the driver’s door. When opened, the door swings freely with no support or soft-close resistance and can slam shut or fling wide open unexpectedly. This poses a danger to passengers and nearby people or property. I believe this issue may relate to a latch or hinge mechanism malfunction, and I am concerned about the lack of a safety interlock. I have reported this to Tesla, and they have not acknowledged it as a warranty or safety concern. I am submitting this complaint in the interest of safety for myself and other drivers of this model. I have videos and more detail but this site only allows static photos.

    NHTSA complaint 11659206
13. Filed Feb 3, 2025Failure Feb 3, 2025Lynn, MAVisibility/wiper

    Windshield cracked due to defrosting; yes available for inspection upon request. If the windshield shatters due to defrosting this is serious safety risk and what can happen while driving is limited less. Vehicle was inspected by Tesla located in Peabody, Massachusetts and the representative stated they are aware, and this is why they tell customers to warm the vehicle up before turning on defrosting, in all the vehicles I've owned windshield cracking from defroster being on has never happened or been an issue. Also through research I found other Tesla owners have experienced similar. No there were no warnings of this happening outside of reading other Tesla owners experiencing this similar situation.

    NHTSA complaint 11640531
14. Filed Jan 9, 2025Failure Jun 2, 2024Irvine, CAAdaptive cruise control, Automatic emergency braking, Blind spot detectionCrash

    This complain is regarding the recent recall regarding FSD tesla Smart Summon failures. Incident date June 02, 2024 Car was parked in a parking lot outside a movie theater. I was less than 20 feet away from car with clear visibility, and tried smart summon. Car pulled out of the parking making an acute turn damaging driver side door, and front bumper of car parked next to it. Tesla was contacted immediately regarding this malfunction of smart summon and requested them to stop offering this service to owners as it is dangerous. They took 3 months to conduct an internal investigation but refused to share written results. Instead read a generic statement from their website. Still not received a copy of the investigation. Tesla also refused to take take financial responsibility for the damage and their false claim. Smart Summon is dangerous and Tesla should not be allowed to advertise.

    NHTSA complaint 11635046
15. Filed Dec 7, 2024Failure Sep 25, 2024Denton, TXLatch

    Unintended, unexpected opening of front frunk hood while driving slowly in a parking lot into a strong wind gust. I did not deploy frunk switch and Secondary latch apparently inoperative

    NHTSA complaint 11629420
16. Filed Oct 17, 2024Failure Oct 7, 2024Centreville, VAUnknown or other

    12v Battery is keep discharging in every two to three months. Tesla service can't find issues or not telling me what is the reason. I have got 5 replacements of 12v battery in last one year. So I think there is a issue in car or bug they are not able to fix it because of limitation. Please let me know how to handle this.

    NHTSA complaint 11620318
17. Filed Sep 25, 2024Failure Aug 1, 2024Lincoln, NEAssist, Warning, Steering

    Alerts: UI_a020 - Steering Assist Reduced APP_w264 - Lane Departure features unavailable This incident happened suddenly during a normal commute from work to home. It caused the steering of the vehicle to be very heavy and difficult to control which could have potentially led to an unwanted accident on the road. There root cause seems to be a failure in the steering rack component of the car. It is a very common and prevalent issue with Tesla vehicles, and complaints on various Tesla forums and Reddit threads about this same issue. There also has been NHTSA investigations in the past regarding this. The failure caused the loss of safety functionality such as Lane Keeping Assistance, Lane Departure Assistance, Autopilot and FSD. Tesla Service Center diagnosed the alerts as a steering rack hardware failure and is charging almost $5000 to replace the part. Given that this is such a prevalent issue among so many Tesla vehicles, it needs to be addressed by the manufacturer and should be a safety recall and not on the customer to pay out of pocket.

    NHTSA complaint 11616404
18. Filed Sep 3, 2024Failure Aug 19, 2024Flagstaff, AZSteering

    Steering rack failure: replacement needed for Model X 2021 at approximately 55K miles. From Tesla Service Center: Concern: Customer states: Alerts - Steering assist reduced/Steering may require increased effort. Repair Notes: Performed vehicle data review found alerts for steering rack assembly, inspected steering rack harness connections found good connections, inspected for any outside influence found none. Found steering rack has non-serviceable internal fault. Recommend steering rack assembly replacement and alignment check. Correction: Steering Rack (Remove & Replace) - Remove and Replace Part Quantity and Labor Hours $4,641.46 + taxes

    NHTSA complaint 11612318
19. Filed Jun 19, 2024Failure Jun 19, 2024Villanova, PASteering

    I was driving and the car started changing lanes. The steering became heavy and I was barely able to move it and required extreme force. Tesla screen displayed ( steering assist reduced ). I almost died. I was facing cars on both directions and was barely able to get my self to a safe spot. There was no warning before this happened. The car is currently with dealer The steering became acutely extremely heavy and unresponsive and locked on a busy road

    NHTSA complaint 11595384
20. Filed Jun 1, 2024Failure May 26, 2024Lafayette, CASteering

    The steering locked up and it would not move. This happened as I was driving on a road at about 35 miles per hour. I could not steer until I dropped the car speed under 10 miles an hour and using great force was able to navigate the car to safety. I had the car towed to Tesla for repair. They kept it about 4 days and returned it. Within 40 miles of driving the car gave a notification that the steering was "reduced". I was in the car with my [XXX] daughter and about to get on the freeway. I immediately pulled over and had the car towed again to Tesla for repair. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

    NHTSA complaint 11591867